Changing The Fuel Pump - KTM 690 Enduro R EU 2012 Repair Manual

12 FUEL TANK, SEAT, TRIM
12.9

Changing the fuel pump

Danger
Fire hazard Fuel is highly flammable.
–
Never refuel the vehicle near open flames or burning cigarettes, and always switch off the engine first. Be careful that no
fuel is spilt, especially on hot vehicle components. Clean up spilt fuel immediately.
–
The fuel in the fuel tank expands when warm and may emerge if overfilled. Follow the instructions on refueling.
Warning
Danger of poisoning Fuel is poisonous and a health hazard.
–
Fuel must not come into contact with the skin, eyes, or clothing. Do not breathe in the fuel vapors. If contact occurs with
the eyes, rinse with water immediately and contact a physician. Immediately clean contaminated areas on the skin with
soap and water. If fuel is swallowed, contact a physician immediately. Change clothing that is contaminated with fuel.
Store fuel properly in a suitable canister and keep away from children.
Warning
Environmental hazard Improper handling of fuel is a danger to the environment.
–
Do not allow fuel to get into the ground water, the ground, or the sewage system.
–
Mount and tighten screws
Guideline
Screw, side cover
202036-12
Finishing work
–
Disconnect the battery. (
–
Mount the seat. (
–
Set the clock. (
Preparatory work
–
Switch off all power consumers and switch off the engine.
–
Remove the seat. (
–
Disconnect the battery. (
–
Drain the fuel from the fuel tank into a suitable container.
Main work
–
Remove screws
202036-12
–
Lift the rear fairing.
–
Remove screws
202037-12
.
1
p. 83)
p. 63)
p. 98)
p. 62)
p. 82)
.
1
.
2
M6 5 Nm (3.7 lbf ft)
68