Advertisement
CEILING MOUNT
AIR HANDLERS
INSTALLATION INSTRUCTIONS
IMPORTANT SAFETY INSTRUCTIONS
The following symbols and labels are used throughout this manual
to indicate immediate or potential safety hazards. It is the owner's
and installer's responsibility to read and comply with all safety
information and instructions accompanying these symbols. Failure
to heed safety information increases the risk of personal injury,
property damage, and/or product damage.
O
NLY PERSONNEL THAT HAVE BEEN TRAINED TO INSTALL
(
SERVICE OR REPAIR
HERINAFTER
SPECIFIED IN THIS MANUAL SHOULD SERVICE THE EQUIPMENT
MANUFACTURER WILL NOT BE RESPONSIBLE FOR ANY INJURY OR
PROPERTY DAMAGE ARISING FROM IMPROPER SERVICE
. I
PROCEDURES
F
YOU
RESPONSIBILITY FOR ANY INJURY OR PROPERTY DAMAGE WHICH MAY
. I
,
RESULT
N ADDITION
IN JURISDICTIONS THAT REQUIRE ONE OR MORE
LICENSES TO SERVICE THE EQUIPMENT SPECIFIED IN THIS MANUAL
ONLY LICESNSED PERSONNEL SHOULD SERVICE THE EQUIPMENT
I
,
MPROPER INSTALLATION
THE EQUIPMENT SPECIFIED IN THIS MANUAL WITHOUT PROPER
TRAINING MAY RESULT IN PRODUCT DAMAGE
PERSONAL INJURY OR DEATH
PROP 65 WARNING
FOR CALIFORNIA CONSUMERS
Cancer and Reproductive Harm
www.P65Warnings.ca.gov
HIGH VOLTAGE!
D
ISCONNECT ALL POWER BEFORE SERVICING OR INSTALLING
. M
THIS UNIT
ULTIPLE POWER SOURCES MAY BE PRESENT
F
AILURE TO DO SO MAY CAUSE PROPERTY DAMAGE
PERSONAL INJURY OR DEATH
D
O NOT CONNECT TO OR USE ANY DEVICE THAT IS NOT DESIGN
C
ERTIFIED BY THE MANUFACTURER FOR USE WITH THIS UNIT
,
PROPERTY
DA MA GE
PER SONAL
/OR
PERFORMANCE AND
HAZARDOUS CONDITIONS MAY RESULT FROM
-
THE USE OF SUCH NON
APPROVED DEVICES
IO-416H
07 / 2019
WARNING
, "
")
SERVICE
THE EQUIPMENT
,
SERVICE
THIS
UNIT
YOU
,
ADJUSTMENT
SERVICING OR REPAIR OF
,
PROPERTY DAMAGE
.
-
WARNING
,
.
WARNING
,
INJ UR Y
REDU CED
.
,
,
ADJUST
. T
HE
,
OR SERVICE
ASSUME
,
.
,
0140M00517-A
.
. S
ERIOUS
UN IT
CO can cause serious illness including permanent brain
damage or death.
Advertencia especial para la instalación de calentadores ó manejadoras
de aire en áreas cerradas como estacionamientos ó cuartos de servicio.
Las emisiones de monóxido de carbono pueden circular a través
del aparato cuando se opera en cualquier modo.
El monóxido de carbono puede causar enfermedades severas
como daño cerebral permanente ó muerte.
RISQUE D'EMPOISONNEMENT AU MONOXYDE DE CARBONE
Cette ventilation est nécessaire pour éviter le danger d'intoxication
au CO pouvant survenir si un appareil produisant du monoxyde
de carbone continue de fonctionner au sein de la zone confinée.
B10259-216
B10259-216
B10259-216
Advertisement
Table of Contents
Related Manuals for Goodman ACNF18 Series
Summary of Contents for Goodman ACNF18 Series
- Page 1 CEILING MOUNT AIR HANDLERS INSTALLATION INSTRUCTIONS IMPORTANT SAFETY INSTRUCTIONS The following symbols and labels are used throughout this manual to indicate immediate or potential safety hazards. It is the owner’s and installer’s responsibility to read and comply with all safety information and instructions accompanying these symbols.
-
Page 2: Application Information
Place this unit as close to the space to be air conditioned as possible. CONSUMER AFFAIRS These units are U.L. listed for installations with zero clearance GOODMAN MANUFACTURING COMPANY, L.P. to combustible materials. If this unit is installed in a removable 7401 SECURITY WAY ceiling panel, ensure adequate space is available for servicing. - Page 3 Filters The depth of a running trap (Figure 2) should be either 1” or a depth that permits unrestricted condensate drainage without excessive Filters are not provided with unit, and must be supplied and air discharge. installed in the return air system by the installer. A field installed filter grille is recommended for easy and convenient access to Field experience has shown condensate drain traps with an open the filters for periodic inspection and cleaning.
- Page 4 LAYOUT FOR CEILING MOUNT AIR HANDLERS 3. The location of the unit should provide proper access for inspection and servicing. NOTE: The location of the unit is based on thorough consideration of the PRE-INSTALLATION CHECK POINTS. MODEL 1. Before locating the unit on the dropped ceiling, ensure the 1.5 TON 37 1/4 37 11/16...
-
Page 5: Special Instructions
SPECIAL INSTRUCTIONS ELECTRICAL CONNECTIONS This airhandler comes equipped with an evaporator coil with a check style flowrator assembly, an indoor blower and all necessary internal electrical wiring. For most installations with matching HIGH VOLTAGE! applications, no change to the flowrator orifice is required. ISCONNECT POWER BEFORE SERVICING ULTIPLE... -
Page 6: Maintenance
CONSTANT TORQUE (EEM) MOTORS ACNF25 and ACNF31 models utilize constant torque (EEM) motors. 24 V CONNECTIONS BLUE These motors come with a separate control box which is mounted on the side of the unit as shown in Figure 8. The harness from the YELLOW TO CONDENSING UNIT motor is inserted into the control box which has another harness... - Page 7 Air Filter(s) All central air moving comfort systems must include air filter(s). Locate these filters in either the equipment or return air duct system upstream of the equipment. The filter(s) removes dust and debris from the air thus helping to keep your conditioned space clean. More important, the filter keeps dust and debris from collecting on heat transfer surfaces thus maintaining optimum equipment efficiency and performance.
- Page 8 BLOWER CHART FOR ACNF Airflow rate delivered against Motor External Static Pressure, (CFM) Model Speed 0.1" 0.2" 0.3" 0.4" 0.5" High ACNF180XXX High ACNF240XXX High 1,075 1,005 ACNF300XXX ACNF25XXXX ACNF31XXXX NOTE: Ai rfl ow da ta for 240 Va c wi th dry coi l a nd no fi l ter i n pl a ce.
- Page 9 THIS PAGE WAS LEFT BLANK INTENTIONALLY...
- Page 10 THIS PAGE WAS LEFT BLANK INTENTIONALLY...
- Page 11 THIS PAGE WAS LEFT BLANK INTENTIONALLY...
- Page 12 Customer Services • Financing Options 5151 San Felipe, Suite 500, Houston, TX 77056 © 2011 - 2017, 2019 Goodman Manufacturing Company, L.P. is a registered trademark of Maytag Corporation or its related companies and is used under license. All rights reserved.