Table of Contents
Advertisement
Emergency Stopping
1. Pull out the stop/run key. See Figure 12.
Figure 12. Emergency Stop/Run Key.
2. Turn the fuel shut-off valve to the OFF position.
See Figure 13.
OFF
Fuel
Shut-Off
Valve
Figure 13. OFF Position of Fuel Shut-Off Valve.
3. Brush snow off engine and equipment.
4. Install the stop/run key into the key slot.
Operating
Angle of Operation
Continuous operation at angles up to 20° with no
less than 1/2 full fuel tank. Check oil level to assure
crankcase oil level is correct. Refer to Check Oil Level.
Intermittent operation, up to one minute at angles up
to 25° with 1/2 full fuel tank. Check oil level to assure
crankcase oil level is correct. Refer to Check Oil Level.
Stop/Run
Key
Pull Out
to Stop
Refer to the operating instructions of the equipment
this engine powers. Because of equipment design or
application, there may be more stringent restrictions
regarding the angle of operation.
NOTE: Do not operate this engine continuously
at angles exceeding 20° in any direction.
Engine damage could result from insufficient
lubrication.
Cooling
NOTE: If ice builds up on the retractable starter
screen or other cooling areas, stop the engine
immediately and clean. Operating the engine
with blocked or dirty air intake and cooling
areas can cause extensive damage due to
overheating. Refer to Clean Air Intake/
Cooling Areas.
Hot Parts can cause severe burns.
Do not touch engine while operating or
just after stopping.
Engine components can get extremely hot from operation. To
prevent severe burns, do not touch these areas while the engine
is running, or immediately after it is turned off. Never operate
the engine with heat shields or guards removed.
Engine Speed
NOTE: Do not tamper with the governor setting
to increase the maximum engine speed.
Overspeed is hazardous and will void the
engine warranty. The maximum allowable
high idle speed for these engines is 3750 RPM,
no load.
Maintenance Instructions
Maintenance, repair or replacement of the emission
control devices and systems, which are being
done at the customers expense, may be performed
by any non-road engine repair establishment or
individual. Warranty repairs must be performed by
an authorized Kohler Engine Service Center.
Accidental Starts can cause severe
injury or death.
Disconnect and ground spark plug
leads before servicing.
Disabling engine. Accidental starting can cause severe injury
or death. Before working on the engine or equipment, disable
the engine as follows: 1) Disconnect the spark plug lead(s).
2) Disconnect negative (-) battery cable from battery.
WARNING
WARNING
Advertisement
Table of Contents
