Table of Contents
Advertisement
Listed below are the parts covered by the Federal and California Emission Control Systems Warranty. Some parts listed below may require
scheduled maintenance and are warranted up to the first scheduled replacement point for that part. The warranted parts include the
following if they were present in the engine purchased:
•
Oxygen sensor (if equipped)
•
Intake manifold (if equipped)
•
Exhaust manifold (if equipped)
•
Catalytic muffler (if equipped)
•
Thermal reactor muffler (if equipped)
•
Spark advance module (if equipped)
•
Air filter, fuel filter, and spark plugs (only to first
scheduled replacement)
•
Crankcase breather
•
Air injection system (if equipped)
• Air pump or pulse valve assembly (if equipped)
• Control/distribution valve (if equipped)
• Distribution manifold (if equipped)
• Air hoses (if equipped)
• Vacuum lines (if equipped)
LIMITATIONS
This Emission Control Systems Warranty shall not cover any of the following:
(a) repair or replacement required because of misuse or neglect, improper maintenance, repairs improperly performed or replacements
not conforming to Kohler Co. specifications that adversely affect performance and/or durability and alterations or modifications not
recommended or approved in writing by Kohler Co.,
(b) replacement of parts and other services and adjustments necessary for required maintenance at and after the first scheduled replacement point,
(c) consequential damages such as loss of time, inconvenience, loss of use of the engine or equipment, etc.,
(d) diagnosis and inspection fees that do not result in eligible warranty service being performed, and
(e) any add-on or modified part, or malfunction of authorized parts due to the use of add-on or modified parts.
MAINTENANCE AND REPAIR REQUIREMENTS
The owner is responsible for the proper use and maintenance of the engine. Kohler Co. recommends that all receipts and records covering the
performance of regular maintenance be retained in case questions arise. If the engine is resold during the warranty period, the maintenance
records should be transferred to each subsequent owner. Kohler Co. reserves the right to deny warranty coverage if the engine has not been
properly maintained; however, Kohler Co. may not deny warranty repairs solely because of the lack of repair maintenance or failure to keep
maintenance records.
Normal maintenance, replacement or repair of emission control devices and systems may be performed by any repair establishment or
individual; however, warranty repairs must be performed by a Kohler authorized service center. Any replacement part or service that is
equivalent in performance and durability may be used in non-warranty maintenance or repairs, and shall not reduce the warranty obligations of
the engine manufacturer.
•
Ignition module(s) with high tension lead
•
Gaseous fuel regulator (if equipped)
•
Electronic control unit (if equipped)
•
Carburetor or fuel injection system (if equipped)
•
Fuel lines, fuel line fittings and clamps (if equipped)
•
Fuel metering valve (if equipped)
•
Evaporative system (if equipped)
• Canister (if equipped)
• Canister filter (if equipped)
• Vapor hose (if equipped)
• Orifice connector (if equipped)
• Fuel tank (if equipped)
• Fuel cap (if equipped)
• Primer bulb canister (if equipped)
15
Advertisement
Table of Contents
