Check Point Of Every 50 Hours; Check Point Of Every 100 Hours - Kubota GL6000 Workshop Manual

GL6000, GL7000, GL9000, GL11000, WSM

[3] CHECK POINT OF EVERY 50 HOURS

[4] CHECK POINT OF EVERY 100 HOURS

Checking Fuel Hose and Clamp Bands
CAUTION
• Stop the engine when attempting the check and change
prescribed below.
• Remember to check the fuel line periodically. The fuel line
is subject to wear and aging, fuel may leak out onto the
running engine, causing a fire.
1. Check to see that all fuel lines (2) and hose clamps (1) are tight
and not damaged.
2. If fuel lines (2) and hose clamps (1) are found worn or damaged,
replace or repair them at once.
3. The fuel line (2) is made of rubber and ages regardless of period
of service. Replace the fuel line (2) together with the hose clamp
(1) every two years and securely tighten.
4. However if the fuel lines (2) and hose clamps (1) are found
damaged or deteriorated earlier than two years, then change or
remedy.
IMPORTANT

• When the fuel line is disconnected for change, close both
ends of the fuel line with a piece of clean cloth or paper to
prevent dust and dirt from entering. Entrance of dust and
dirt causes malfunction of the fuel injection pump.
addition, particular care must be taken not to admit dust and
dirt into the fuel pump.
(1) Hose Clamp
Changing Engine Oil
CAUTION
• Be sure to stop engine before changing engine oil.
1. After warming up, stop the engine.
2. Place an oil pan underneath the engine.
3. Remove the oil drain plug (1) to drain the dirty engine oil
completely.
4. Inspect the drain plug gasket. Replace it damaged.
5. Reinstall the drain plug.
6. Fill the new engine oil up to the upper mark on the gauge.
IMPORTANT

• When using an oil of different maker or viscosity from the
previous one, drain an old oil.
• Never mix two different types' of oil.
• Use the proper SAE Engine oil according to ambient
temperatures.
Refer to "4. LUBRICANTS, FUEL AND COOLANT" (G-9).
(1) Oil Drain Plug
G-16
G GENERAL
(2) Fuel Line
W1035921
[A] GL6000, GL7000
[B] GL9000, GL11000
W1014131
KiSC issued 05, 2015 A
In