Prestige Solo 110 Installation And Maintenance Manual page 5

Table of Contents
10.1.8 Use of Antifreeze in the Boiler System.......................................................57
10.2 Filling the Boiler System ......................................................................................57
10.3 Check Low Water Cut-Off Device .......................................................................58
10.4 Check For Gas Leaks............................................................................................58
10.5 Check Thermostat Circuit .....................................................................................58
10.6 Inspection of Condensate Drain Assembly...........................................................58
SECTION XI - Start-Up Procedures
11.1 Final Checks Before Start-Up...............................................................................59
11.2 PRESTIGE Solo Start-Up.....................................................................................59
11.3 Check the PRESTIGE Solo and System...............................................................59
SECTION XII - Outdoor Reset Control
12.1 Mounting the Outdoor Sensor...............................................................................64
12.2 Wiring the Sensor..................................................................................................64
SECTION XIII - External Modulating Control
13.1 Wiring the Modulating Controller ........................................................................65
13.2 ACVMax Adjustment ...........................................................................................65
13.3 Programming of External Modulating Control.....................................................65
SECTION XV - Installation Record
SECTION XVI - Maintenance Schedule
16.1 Service Technician ................................................................................................69
16.2 Owner Maintenance ..............................................................................................69
SECTION XVII- Maintenance Procedures
17.1 Maintenance Procedures .......................................................................................70
17.2 Reported Problems................................................................................................70
17.3 Check Surrounding Area .....................................................................................70
17.4 Inspect Burner Area ..............................................................................................70
17.5 Check System Piping ............................................................................................70
17.6 Clean Condensate Drain Assembly.......................................................................71
17.7 Check Ventilation Air Openings ...........................................................................71
17.8 Inspect Vent and Combustion Air Piping..............................................................71
17.9 Check Boiler System.............................................................................................71
17.10 Check Expansion Tank..........................................................................................72
17.11 Check Boiler Relief Valve ....................................................................................72
17.12 Inspection of Ignitor..............................................................................................72
17.13 Check Ignition Wiring and Ground Wiring ..........................................................72
17.14 Check Control Wiring ...........................................................................................73
iv