Pcm Inspection; Pcm Removal/Installation; Automatic Transaxle Removal/Installation - Mazda 2002 6 Workshop Manual

6. Install the solenoid valve in the control valve body.
Tightening torque
7.8—10.8 N·m
{80—110 kgf·cm, 70—95.4 in·lbf}
7. Install the control valve body. (See
CONTROL VALVE BODY
8. Install the under cover.
9. Connect the negative battery cable.
10. Add ATF and, with the engine idling, inspect the
ATF level and inspect for leakage. (See
Automatic Transaxle Fluid (ATF) Level
Inspection.)
11. Carry out the mechanical system test. (See
12. Carry out the road test. (See
End Of Sie

PCM INSPECTION

1. Inspect the PCM. (See
End Of Sie

PCM REMOVAL/INSTALLATION

1. Remove and install the PCM. (See
End Of Sie

AUTOMATIC TRANSAXLE REMOVAL/INSTALLATION

1. Disconnect the negative battery cable.
2. Remove the battery and battery tray.
3. Remove the aircleaner component. (See
4. Remove the front tires and splash shield.
5. Remove the under cover.
6. Remove the steering gear and power steering pipe. (See
INSTALLATION.)
7. Remove the front auto leveling sensor. (See
INSTALLATION.)
8. Drain the ATF. (See K–13 AUTOMATIC TRANSAXLE FLUID (ATF)
Warning
• Improperly jacking a transaxle is dangerous. It can slip off the jack and may cause serious injury.
Caution
• To prevent the torque converter and transaxle from separating, remove the transaxle without
tilting it toward the torque converter.
9. Remove in the order shown in the figure.
10. Install in the reverse order of removal.
11. Adjust the headlight zeroset. (See
12. Add ATF to the specified level. (See
13. Carry out the mechanical system test. (See
Line
Service item
pressure
test
ATX replacement
ATX overhaul
Torque converter
replacement
Oil pump
replacement
Clutch system
replacement
× : Test to be performed after the service work
14. Carry out the road test. (See
AUTOMATIC TRANSAXLE
K–34
REMOVAL.)
K–12
K–6 MECHANICAL SYSTEM
K–9 ROAD TEST.)
F–45 PCM INSPECTION.)
F–43 PCM REMOVAL/INSTALLATION.)
F–10 INTAKE-AIR SYSTEM
T–32 FRONT AUTO LEVELING SENSOR REMOVAL/
T–31 HEADLIGHT
K–13 AUTOMATIC TRANSAXLE FLUID (ATF)
K–6 MECHANICAL SYSTEM
Test item
Time lag
Stall test
test
×
× × ×
× ×
×
× ×
K–9 ROAD TEST.)
TEST.)
REMOVAL/INSTALLATION.)
N–10 STEERING GEAR AND LINKAGE REMOVAL/
REPLACEMENT.)
ZEROSET.)
TEST.)
A6E5614W045
A6E561418880W01
A6E561418880W02
A6E561401030W07
REPLACEMENT.)
K–29
K