General Information; Care Of Enamelled Parts; Care Of Glass; Installation - Napoleon OS10-3 Installation And Operation Instructions Manual

4

General information

Nominal heat
output
max speed
34.100 BTU/hr .31 US gal/hr
10 kW 1.20 litre/h
Nominal heat output
29 000 Btu/h (8.50 kW)
** 1 pint = 0.568 litre 1 quart = 1.136 litres
1 litre = 1.760 pints 1 litre = 0.879 quart
Pints, quarts and gallons are Canadian unless otherwise noted.

Care of enamelled parts

Do not use abrasive cleaners to clean these parts. Buff lightly with a clean, dry cloth. Porcelain enamel components must
be handled with care. The baked-on finish is "glasslike". If struck, it will chip. Touch-up paint is available through your
Napoleon dealer.

Care of glass

If the glass is not kept clean permanent discolouration and / or blemishes may result. Normally a hot burn will clean the
glass. The most common reason for dirty glass is running the unit at a low burning rate. If it is necessary to clean the glass,
use a soft cloth with a nonabrasive cleaner. Coarse cleaning materials may cause scratches or otherwise damage the
glass. Scratches can develop into cracks or breaking of the glass.
The glass is very strong for maximum performance. However, always close the door gently. If the glass should ever crack
while the fire is burning, do not open the door until the fire is out and do not operate the stove again until the glass has been
replaced with new borosilicate glass, available from your Napoleon / Wolf Steel Ltd. dealer. DO NOT SUBSTITUTE
MATERIALS. Check gaskets and seals regularly.

INSTALLATION

Unit and specifications

WARNING : Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage.
Refer to this manual. For assistance or additional information consult a qualified installer, service agency or the oil
supplier.r
Document n° 1092-1 EN ~ 04/02/2002
Oil consumption **
min speed
.066 US gal/hr
1/4 litre/h
Connection to a L.VENT chimney
Oil consumption at nominal speed
0.26 US gal/h (1.0 l/h)
1 gallon = 4.546 litres
1 litre = 0.22 gal
DO NOT CLEAN GLASS WHEN HOT !
Chimney draft required
max speed min speed
.072" w.c.g .032" w.c.g
18 Pa 8 Pa
1 US gal = 3.785 litres
Flue outlet outside
Weight
diameter
260 lbs 5 inches
118 kg 120-125-127 mm
Chimney draft
0.07" w.c. (17 Pa)
Figure 1