Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Maxum 2700 SE SPORT EXPRESS CRUISER
Summary of Contents for Maxum 2700 SE SPORT EXPRESS CRUISER
-
Page 3: Engine Serial Number
This document discloses subject matter in which Maxum has proprietary rights. The information and design disclosed herein were originated by and are the prop- erty of Maxum. Neither receipt nor possession thereof confers or transfers any right to reproduce, copy, alter or disclose the document or any part thereof, any information contained therein, or to construct boats or any item from it, except by written permission from or written agreement with Maxum. -
Page 4: Table Of Contents
CONTENTS Chapter 1: Welcome Aboard! Chapter 4: Controls Dimensions and Tank Capacities Steering Layout View Shift/Throttle Dealer Service Power Trim and Tilt Warranty Information Trim Tabs Boating Experience Engine & Accessory Guidelines Chapter 5: Navigation & Communications Equipment Engine & Accessory Literature VHF Radio (If Equipped) Safety Standards Compass... - Page 5 Chapter 8: Appliances & Chapter 12: Electrical System Entertainment Systems 12 Volt DC System Batteries Refrigerator Fuses and Circuit Breakers Electric Stove (If Equipped) 12 Volt Accessory Outlets Battery Switch Alcohol/Electric Stove (If Equipped) Alternator Audio & Visual Equipment Battery Charger Dockside Cable TV (If Equipped) 120 Volt AC System Shore Power...
- Page 6 Hazard Boxes & Symbols The hazard boxes and symbols shown below are used throughout this Supplement to call attention to potentially dan- gerous situations which could lead to either personal injury or product damage. Read ALL warnings carefully and follow ALL safety instructions. DANGER! This box alerts you to immediate hazards which WILL cause severe personal injury or death if the warning is ignored.
-
Page 7: Chapter 1: Welcome Aboard
• Buy replacement parts from any authorized Maxum dealer. Warranty Information • Maxum offers an Express Limited Transferable Warranty on each new Maxum purchased through an authorized Maxum dealer. • A copy of the Express Limited Transferable Warranty was included in your owner’s packet. -
Page 8: Boating Experience
Chapter 1: Welcome Aboard! Boating Experience WARNING! CONTROL HAZARD! A qualified operator must be in control of the boat at all times. DO NOT operate your boat while under the influence of alcohol or drugs. If this is your first boat or if you are changing to a type of boat you are not familiar with, obtain handling and operating experience before assuming command of the boat. -
Page 9: Safety Standards
Chapter 1: Welcome Aboard! Safety Standards DANGER! FALLING and ROTATING PROPELLER HAZARD! NEVER allow anyone to ride on parts of the boat not designed for such use. • Sitting on seat backs, lounging on the forward deck, bow riding, gunwale riding or occupying the transom platform while underway is especially hazardous and will cause personal injury or death. -
Page 10: Special Care For Moored Boats
Chapter 1: Welcome Aboard! Special Care For Moored Boats NOTICE • To help seal the hull bottom and reduce the possibility of gelcoat blistering on moored boats, apply an epoxy barrier coating. The barrier coating should be covered with several coats of anti-fouling paint. -
Page 11: Carbon Monoxide (Co)
Chapter 1: Welcome Aboard! Carbon Monoxide (CO) DANGER! • Carbon monoxide gas (CO) is colorless, odorless, tasteless, and extremely dangerous. • All engines, generators, and fuel burning appliances produce CO as exhaust. • Prolonged exposure to low concentrations or very quick exposure to high concentrations will cause BRAIN DAMAGE or DEATH. -
Page 12: Where And How Co Can Accumulate
Chapter 1: Welcome Aboard! Where and How CO Can Accumulate Stationary Conditions That Increase CO Accumulations Include: A. Using engine, generator, or other fuel burning device when boat is moored in a confined B. Mooring too close to another boat that is using its space. -
Page 13: Trip Checklist
Chapter 1: Welcome Aboard! Trip Checklist ❏ Make sure you know where the exhaust outlets are located on your boat. ❏ Educate all passengers about the symptoms of CO poisoning and where CO may accumulate. ❏ When docked, or rafted with another boat, be aware of exhaust emissions from the other boat. ❏... -
Page 14: More Information
Chapter 1: Welcome Aboard! More Information For more information about how you can prevent carbon monoxide poisoning on recreational boats and other ways to boat more safely, contact: United States Coast Guard National Marine Manufacturers American Boat & Yacht Council, Association (NMMA) Inc. -
Page 15: Boat Lifting
• When lifting any boat, always use a spreader bar. The spreader bar must be equal to the width of the boat at the lifting point. LIFTING SLING LABELS (TYPICAL PORT & STARBOARD) MAXUM 47" 158" • Always follow the lift equipment’s instructions and requirements. -
Page 16: Chapter 2: Locations
Chapter 2: Locations Exterior Views Hull views TRANSOM STERN EYES (STRONG POINTS) MACERATOR OVERBOARD DRAIN (IF EQUIPPED) BILGE DRAIN PLUG ZINC PLATE TRIM TABS PORT HULLSIDE ANCHOR LOCKER DRAIN COCKPIT DRAINS GALLEY SINK DRAIN WATER HEATER DRAIN GENERATOR EXHAUST (IF EQUIPPED) WATER TANK VENT STARBOARD HULLSIDE COCKPIT DRAINS... -
Page 17: Deck Views
Chapter 2: Locations Deck Views FOREDECK CLEATS (STRONG POINTS) ANCHOR DEAD END NAVIGATION LIGHTS WINDLASS SPOTLIGHT 10 HATCH WINDLASS CONTROLS ANCHOR LOCKER DRAIN ANCHOR ROLLER HIDDEN HORN AFT DECK CLEATS (STRONG POINTS) WASTE PUMP-OUT DECK FITTING GRAB RAILS CITY WATER INLET WATER FILL DECK FITTING SHORE POWER INLETS FUEL FILL DECK FITTING... - Page 18 Chapter 2: Locations COCKPIT GRAB RAIL TRANSOM SHOWER WINDLASS CIRCUIT FAUCET BREAKER (IF EQUIPPED) COURTESY LIGHT BATTERY SWITCH...
-
Page 19: Helm
Chapter 2: Locations Helm NOTE: TYPICAL HELM LAYOUT SHOWN ACTUAL LAYOUT MAY VARY DEPENDING ON ENGINE AND ACCESSORY OPTIONS 10 11 12 13 14 15 16 17 18 19 20 TEMP GAUGE 10 WIPER SWITCH 19 FORWARD BILGE PUMP OIL GAUGE 11 ANCHOR LIGHT 20 AFT BILGE PUMP COMPASS... -
Page 20: Component Locations
Chapter 2: Locations Component Locations 12 Volt Accessory Outlets: (1) At the helm on the dash panel. (2) Above the refrigerator. Air Conditioner Seawater Intake Seacock: In the engine compartment on the starboard side. Air Conditioner Unit: On the starboard side. Access is through the wall cutouts in the mid-berth. Batteries: On the port side of the engine compartment. -
Page 21: Chapter 3: Propulsion & Related Systems
Chapter 3: Propulsion & Related Systems Engine Read and understand the engine operation and maintenance manuals before starting or doing any maintenance on the engine. Engine Room Ventilation System WARNING! FIRE/EXPLOSION HAZARD • Use of the blower system is NOT A GUARANTEE that explosive fumes have been removed. •... -
Page 22: Fuel System
Chapter 3: Propulsion & Related Systems Fuel System WARNING! FIRE/EXPLOSION HAZARD! • It is very important that the fuel system be inspected thoroughly the first time it is filled and at each subsequent filling. • For your safety and the safety of your passengers, the fueling instructions in the Cruiser & Yacht Owner’s Manual must be carefully followed. -
Page 23: Fuel Fill And Vent
Chapter 3: Propulsion & Related Systems Fuel Fill and Vent • The fuel fill fitting is marked “GAS” or “DIESEL”. • The fuel tank vent is located below the fuel fill. • If you experience difficulty filling either fuel tank, see if the fuel fill hose or fuel tank vent hose is kinked or collapsed. -
Page 24: Quick Oil Drain System
Chapter 3: Propulsion & Related Systems Quick Oil Drain System QUICK OIL DRAIN SYSTEM TRANSOM OIL DRAIN HOSE OIL DRAIN PLUG ENGINE OIL PAN GARBOARD DRAIN PLUG DRAW CORD BILGE GARBOARD DRAIN To drain the engine oil: 1. Remove the boat from the water. 2. -
Page 25: Chapter 4: Controls
Chapter 4: Controls Steering This boat features a power assisted rack-and- pinion steering system. Check the fluid level in the power steering reservoir every time you use your boat. Boat steering is not self-centering. STEERING CABLE SHIFT/THROTTLE LEVER SHIFT/THROTTLE CABLE Shift/Throttle WARNING! LOSS OF CONTROL HAZARD! -
Page 26: Trim Tabs
Chapter 4: Controls Trim Tabs WARNING! LOSS OF CONTROL HAZARD! Improper use of trim tabs will cause loss of control! • DO NOT allow anyone unfamiliar with trim tabs to use them. • DO NOT use trim tabs in a following sea as they will cause broaching or other unsafe handling characteristics. -
Page 27: Chapter 5: Navigation & Communications Equipment
Chapter 5: Navigation & Communications Equipment Before using these systems for the first time, read and understand the instruction manuals and observe the following: VHF Radio (If Equipped) Your boat may include a VHF (Very High Frequency) radio. The VHF radio can be used to access weather reports, summon assistance or contact other vessels as permitted by the FCC (Federal Communications Commission). -
Page 28: Chapter 6: Plumbing
Chapter 6: Plumbing Bilge Pumps NOTICE Discharge of oil, oil waste or fuel into navigable waters is prohibited by law. Violators are sub- ject to legal action by the local authorities. FORWARD BILGE PUMP IS AFT BILGE PUMP IS LOCATED LOCATED UNDER THE ENTRY STEPS IN ENGINE COMPARTMENT BILGE PUMPS &... -
Page 29: Autofloat Switches
Chapter 6: Plumbing Bilge Pump Testing Bilge pumps are critical to the safety of your boat. Check the bilge pumps often to make sure they are working. Individually test each pump as follows: BILGE PUMP 1. Turn On bilge pump switch at helm. COMPONENTS 2. -
Page 30: Seawater Systems
Chapter 6: Plumbing Seawater Systems Seacocks CAUTION! SYSTEM DAMAGE HAZARD! • Before using a seawater intake system, make sure that the system’s seacock is in the OPEN position before the system is started and keep the seacock Open until the system is shut Off. •... -
Page 31: Freshwater System
Chapter 6: Plumbing Freshwater System WARNING! • Only use safe drinking (potable) water in your boat’s freshwater system. • Only use a sanitary drinking water hose to fill the water tank or connect to city water. • Never use a common garden hose for drinking water. FRESHWATER ROUTING WITH GENERATOR FRESHWATER ROUTING... -
Page 32: Freshwater System Winterization
Chapter 6: Plumbing Freshwater System Winterization CAUTION! WATER SYSTEM DAMAGE HAZARD! Never blow compressed air through the water system when all of the faucets are Closed. Turn On the water system switch. Open all of the faucets and showers and let the water system drain completely. Turn Off the water system switch. -
Page 33: Water Heater
Chapter 6: Plumbing Water Heater WARNING! HOT HAZARD! Water heated by the water heater can reach temperatures hot enough to scald the skin. CAUTION! WATER HEATER DAMAGE HAZARD! • DO NOT turn On the water heater electrical circuit on the AC panel until the water heater tank is COMPLETELY filled with water. -
Page 34: City Water Inlet
Chapter 6: Plumbing City Water Inlet CAUTION! FLOODING & SWAMPING HAZARD! • NEVER leave the boat unattended while using the "city water" feature. • Any leak or break in the system may allow large amounts of water to accumulate in the bilge that could cause swamping of the batteries and engine or sinking of the boat. -
Page 35: Shower Drains
Chapter 6: Plumbing Shower Drains SUMP PUMP BOX SHOWER DRAIN SHOWER DRAIN THRU-HULL • The shower is drained into a sump box. SHOWER SUMP BOX IS ACCESSED • A float switch automatically turns On the sump pump. THROUGH FLOOR CUT OUT UNDER •... -
Page 36: Marine Head With Holding Tank
Chapter 6: Plumbing Marine Head With Holding Tank Your boat comes equipped with a marine head (toilet) and waste holding tank system. Read the manufacturer’s oper- ation and maintenance manual. The holding tank is plumbed to a waste fitting on the deck for dockside pump-out. •... -
Page 37: Vacuflush (If Equipped)
Chapter 6: Plumbing VacuFlush (If Equipped) MARINE HEAD TO VACUUM PUMP HOLDING TANK VENT VACUUM PUMP TO HOLDING TANK HOLDING TANK VACUUM PUMP WASTE PUMP-OUT DECK FITTING FILTER The VacuFlush head system uses a vacuum generator and freshwater from the water tank to flush waste from the toi- let into the holding tank. -
Page 38: Macerator (If Equipped)
Chapter 6: Plumbing Macerator (If Equipped) NOTICE Check with local authorities for regulations regarding the legal use of marine head systems. OVERBOARD DISCHARGE BALL VALVE HOLDING TANK VENT MACERATOR (IF EQUIPPED) HOLDING TANK VENT HOSE WASTE PUMP-OUT DECK FITTING MARINE HEAD TO HOLDING TANK HOLDING TANK To use the macerator to pump waste directly into the water (where regulations permit): 1. -
Page 39: Chapter 7: Deck Equipment
Chapter 7: Deck Equipment Canvas CAUTION! Take down and securely stow the convertible top, side curtains and back cover before transporting your boat by road. Canvas top installation: 1. Slide the swivel ends (A) of the main bow (B) over the side windshield frames (C) and insert the pins (D). 2. -
Page 40: Windlass (If Equipped)
Chapter 7: Deck Equipment Windlass (If Equipped) CAUTION! PRODUCT DAMAGE HAZARD! • DO NOT pull the boat to the anchor using the windlass or continue to operate the windlass if it has stalled or is overloaded. Your boat may feature an anchor windlass. Read and follow the manufacturer’s instruction manual before using the anchor windlass for the first time. -
Page 41: Electric Stove (If Equipped)
Chapter 8: Appliances & Entertainment Systems NOTICE Always keep an approved ABC-type fire extinguisher in galley area. All appliances installed on your boat come with their own manuals. These manuals contain detailed instructions and important safeguards. Thoroughly read and understand these manuals before using your boat’s appliances. •... -
Page 42: Alcohol/Electric Stove (If Equipped)
Chapter 8: Appliances & Entertainment Systems Alcohol/Electric Stove (If Equipped) DANGER! CARBON MONOXIDE POISONING HAZARD! • The alcohol stove is a source of dangerous carbon monoxide gas (CO). • BEFORE using the alcohol stove, open doors and windows to make sure there is enough fresh air for ventilation. - Page 43 Chapter 9: Convertible Seats, Beds, & Tables Dinette/V-Berth SALON TABLE V-BERTH BUNK The dinette table can be removed and the dinette area can be converted into the V-Berth. 1. Remove the table (A) and the table leg (B). 2. Lift the dinette seat cushions (C). 3.
-
Page 44: Companion Seat
Chapter 9: Convertible Seats, Beds, & Tables Cockpit Companion Seat The companion seat folds forward to reveal a storage compartment underneath the seat. Aft Cockpit Table/Sunlounge The aft cockpit table and table leg can be removed and the seating can be converted into a flat sunlounge. 1. -
Page 45: Care And Maintenance
Chapter 10: Lights Care and Maintenance All of the lights installed on your boat are of top quality, but you should be aware that failure may periodically occur for a variety of reasons: 1. There may be a blown fuse - replace the fuse. 2. -
Page 46: Air Conditioning System (If Equipped)
Chapter 11: Heating & Air Conditioning Air Conditioning System (If Equipped) DANGER! CARBON MONOXIDE POISONING HAZARD! Dangerous carbon monoxide gas (CO) can be brought into the boat through the air conditioning system. CAUTION! SYSTEM DAMAGE HAZARD! The air conditioning system’s seacock must be OPENED before turning On the air conditioner and must remain OPEN during use. -
Page 47: Chapter 12: Electrical System
Chapter 12: Electrical System DANGER! EXTREME FIRE, SHOCK & EXPLOSION HAZARD! • To minimize the risks of fire and explosion, NEVER install knife switches or other arcing devices in the fuel compartments. • NEVER substitute automotive parts for marine parts. Electrical, ignition and fuel system parts were designed and manufactured to comply with rules and regulations that minimize risks of fire and explosion. -
Page 48: Volt Dc System
Chapter 12: Electrical System 12 Volt DC System Batteries The batteries supply electricity for lights, accessories, engine and generator (if equipped) starting. The Electrical section of Chapter 8, in the Cruiser & Yacht Owner’s Manual, provides battery, care and maintenance instructions. Fuses and Circuit Breakers •... -
Page 49: Battery Switch
Chapter 12: Electrical System Battery Switch CAUTION! ENGINE & ELECTRICAL SYSTEM DAMAGE HAZARD! NEVER change the battery switch position while the engine is running. It can cause damage to your boat’s engine alternator. NOTICE Since the batteries on your boat were dealer-installed, the battery switch positions listed below may vary. -
Page 50: Battery Charger
Chapter 12: Electrical System Alternator The engine alternator will keep the batteries properly charged when running at cruising speeds. Battery Charger CAUTION! ENGINE & ELECTRICAL SYSTEM DAMAGE HAZARD! NEVER run the boat’s engine and the battery charger at the same time. CAUTION! The battery charging systems (alternator and battery charger) installed on your boat are designed to charge conventional lead-acid batteries. -
Page 51: Volt Ac System
Chapter 12: Electrical System 120 Volt AC System CAUTION! WATER HEATER DAMAGE HAZARD! • DO NOT turn On the water heater AC panel electrical circuit until the water heater tank is COMPLETELY filled with water. • The tank is full if water flows from the tap when the hot water is turned On in the galley. •... -
Page 52: Shore Power
Chapter 12: Electrical System Shore Power DANGER! FIRE, EXPLOSION & SHOCK HAZARD! • DO NOT alter shore power connectors and use only compatible connectors. • Before connecting or disconnecting the shore power cord to your boat, make sure all break- ers and switches on the AC master panel are turned OFF. -
Page 53: Connecting To Shore Power
• The dual shore power system is designed so that each line is independent of the other except when the AC power transfer switch is used. Connecting To Shore Power NOTE: SINGLE INLET STANDARD DUAL INLETS WITH AIR CONDITIONER (IF EQUIPPED) TYPICAL SHORE POWER INLET SHORE POWER INLET(S) MAXUM... - Page 54 Chapter 12: Electrical System DUAL SHORE POWER AC PANEL (IF EQUIPPED) LINE 1 VOLTMETER LINE 2 LINE 2 DOCKSIDE MASTER SELECTOR SWITCH VOLTMETER TRANSFER DOCKSIDE MASTER LINE 1 LINE 2 POLARITY POLARITY LIGHT LIGHT 10 AMPS 15 AMPS 20 AMPS 15 AMPS 5 AMPS 15 AMPS...
-
Page 55: Generator (If Equipped)
Chapter 12: Electrical System Generator (If Equipped) DANGER! CARBON MONOXIDE POISONING HAZARD! • Generators are a source of dangerous carbon monoxide gas (CO). Check the generator exhaust system for leaks before each use. WARNING! FIRE/EXPLOSION HAZARD! • Use the bilge blowers for a minimum of four minutes before starting the generator. •... -
Page 56: Generator Use
Chapter 12: Electrical System Generator Use AC PANEL, DUAL SHORE POWER & GENERATOR MASTER BREAKER LOCKOUTS DOCKSIDE MASTER GENERATOR MASTER SWITCHES PRE HEAT START SELECTOR SWITCH STOP BLOWER 1. Run the bilge blowers for a minimum of four minutes before starting the generator. •... -
Page 57: Electrical Routings
Chapter 12: Electrical System Electrical Routings Forward Deck Electrical Harness NOTE: VIEW IS UNDERSIDE OF DECK DASH SPEAKERS 11 HORN HEAD NAVIGATION LIGHTS 12 GALLEY LIGHTS LIGHT SWITCHES WINDLASS CONTROLS 13 AFT BERTH LIGHTS WIPERS SPOTLIGHT V-BERTH LIGHTS 10 COURTESY LIGHTS Aft Deck Electrical Harness NOTE: VIEW IS UNDERSIDE OF DECK FUEL FILL GROUND... -
Page 58: Hull Electrical Harness
Chapter 12: Electrical System Hull Electrical Harness TRIM TAB PUMP AUTOMATIC FIRE EXTINGUISHER 15 BLOWER MOTOR ENGINE PLUG FORWARD BILGE PUMP 16 TRIM/TILT PUMP WATER PUMP 10 SHOWER SUMP PUMP 17 VACUUM FLUSH (IF EQUIPPED) AFT BILGE PUMP 11 STEREO 18 DASH PLUGS FUEL TANK 12 GALLEY... -
Page 59: Battery System
Chapter 12: Electrical System Battery System ENGINE GROUND ENGINE BATTERIES TRIM/TILT PUMP GENERATOR DASH PLUGS BATTERY SWITCH 120 Volt AC System WATER HEATER AIR CONDITIONER PUMP (IF EQUIPPED) BATTERY CHARGER AIR CONDITIONER AIR CONDITIONER SWITCH PANEL (IF EQUIPPED) STOVE HEAD OUTLET MICROWAVE 10 REFRIGERATOR GALLEY OUTLET... -
Page 60: Bonding Harness
Chapter 12: Electrical System Bonding Harness ZINC PLATE MACERATOR (IF EQUIPPED) BILGE DRAIN PLUG AIR CONDITIONER PICKUP GENERATOR PICKUP AIR CONDITIONER STRAINER GENERATOR STRAINER 10 AIR CONDITIONER PUMP FUEL FILTER 11 AIR CONDITIONER UNIT HEAD PICKUP... -
Page 61: Wire Diagrams
Chapter 12: Electrical System Wire Diagrams AC Electrical System... - Page 62 Chapter 12: Electrical System AC Electrical System With Generator (If Equipped)
-
Page 63: Dc Electrical System
Chapter 12: Electrical System DC Electrical System... -
Page 64: Engine Electrical System
Chapter 12: Electrical System Engine Electrical System... -
Page 65: Important Records
Important Records Selling Dealer Key Numbers Name Of Dealership Ignition Other Address Electronics Phone/FAX/E-mail Manufacturer Model Name/Number Sales Manager Serial Number Service Manager Manufacturer Model Name/Number Engine Serial Number Manufacturer Model Name/Number Engine Serial Number Manufacturer Model Name/Number Oil Type/SAE Quarts per Engine Filter Type Serial Number... -
Page 66: Float Plan
Float Plan Before going boating, fill out a copy of this float plan (or similar) and leave it with a reliable person whom you can depend on to contact the Coast Guard or other rescue organization, if you do not return as scheduled. Description of Boat Persons on Board Registration/Documentation Number... - Page 67 Float Plan Survival Equipment Trip Expectations Number of PFDs Flares (Yes/No) Mirror (yes or no) Departing From Smoke Signals (Yes/No) Flashlight (Yes/No) Food (Yes/No) Departure Date Departure Time Water (Yes/No) Anchor (Yes/No) Raft/Dinghy (Yes/No) Stopover 1 Paddles (Yes/No) EPIRB (Yes/No) Other Arrive No Later Than: Date Arrive No Later Than: Time...
- Page 68 Owner’s Notes...
- Page 69 Owner’s Notes...
- Page 70 Owner’s Notes...