Safety Information - BuckMaster CDVB200 Owner's Operation And Installation Manual

SAFETY INFORMATION

WARNINGS
IMPORTANT: Read this owner's
manual carefully and completely be-
fore trying to assemble, operate, or
service this cast stove and burner sys-
tem. Improper use of this cast stove
and burner system can cause serious
injury or death from burns, fire, explo-
sions, electrical shock, and carbon
monoxide poisoning.
DANGER: Carbon monoxide poison-
ing may lead to death!
This cast stove with burner system is a
vented product. This cast stove with
burner system will not produce any gas
leakage into your home if properly in-
stalled. This cast stove with burner sys-
tem must be properly installed by a quali-
fied service person. The glass door must
be properly seated and sealed. If this unit
is not properly installed by a qualified
service person with glass door properly
seated and sealed, gas leakage can occur.
Carbon Monoxide Poisoning: Early
signs of carbon monoxide poisoning re-
semble the flu, with headaches, dizziness,
or nausea. If you have any of these signs,
the cast stove with burner system may
not have been installed properly. Get
fresh air at once! Have cast stove and
burner system inspected and serviced by
a qualified service person. Some people
are more affected by carbon monoxide
than others. These include pregnant
women, people with heart or lung disease
or anemia, those under influence of alco-
hol, and those at high altitudes.
Propane/LP gas and natural gas are both
odorless. An odor-making agent is added
to each of these gases. The odor helps
you detect a gas leak. However, the odor
added to these gases can fade. Gas may
be present even though no odor exists.
Make certain you read and understand all
warnings. Keep this manual for refer-
ence. It is your guide to safe and proper
operation of this cast stove and burner
system.
WARNING: Any change to this stove
or burner system or its controls can be
dangerous.
WARNING:
A. Due to high temperatures, the appliance should be located out of traffic and away
from furniture and draperies.
B. Children and adults should be alerted to the hazards of high surface temperature
and should stay away to avoid burns or clothing ignition.
C. Young children should be carefully supervised when they are in the same room as
the appliance.
D. Clothing or other flammable material should not be placed on or near the appli-
ance.
E. Any safety screen or guard removed for servicing an appliance must be replaced
prior to operating the appliance.
F. Installation and repair should be done by a qualified service person. The appli-
ance should be inspected before use and at least annually by a professional service
person. More frequent cleaning may be required due to excessive lint from car-
peting, bedding material, etcetera. It is imperative that control compartments,
burners and circulating air passageways of the appliance be kept clean.
G. Only the door design with this appliance shall be used.
CAUTION:
1. This appliance is only for use with the type of gas indicated on the rating plate. This
appliance is not convertible for use with other gases.
2. For propane/LP burner system, do not place propane/LP supply tank (s) inside any
structure. Locate propane/LP supply tank (s) outdoors. To prevent performance prob-
lems, do not use propane/LP fuel tanks of less than 100 lbs. capacity.
3. If you smell gas
•
Shut off gas supply
•
Do not try to light any appliance
•
Do not touch any electrical switch; do not use any phone in your building
•
Immediately call your gas supplier from a neighbor's phone. Follow the gas sup-
plier's instructions
•
If you can not contact your gas supplier, call the fire department
4. Never install the stove in a recreational vehicle
5. Do not modify the burner or stove under any circumstances. Any parts removed for
servicing must be replaced prior to operating stove or burner system.
6. Turn burner system off and let cool before servicing, installing, or repairing. Only a
qualified service person should install, service, or repair the stove or burner system.
Have burner system inspected annually by qualified service person.
7. Have venting system inspected annually by a qualified service person. If needed, have
venting system cleaned or repaired. See Cleaning and Maintenance, page 25.
8. Do not use this stove to cook food or burn paper or other objects.
9. This appliance, when installed, must be electrically grounded in accordance with local
codes or, in the absence of local codes, with the National Electrical Code, ANS/NFPA
70, or the Canadian Electrical Code, CSA C22.1.
10. Do not install stove directly on carpeting, vinyl tile, or any combustible material other
than wood. The stove must set on a metal or wood panel extending the full width and
depth of the stove.
11. Do not operate burner system if any log is broken.
12. Do not use a blower insert, heat exchanger insert, or other accessory not approved for
use with this stove.
13. "Do not use this appliance if any part has been under water. Immediately call a quali-
fied service technician to inspect the appliance and to replace any part of the control
system and any gas control which has been under water."
"Young children should be carefully supervised when they are in the same room
as the appliance. Toddlers, young children and others may be susceptible to acci
dental contact burns. A physical barrier is recommended if there are at risk indi
viduals in the house. To restrict access to a fireplace or stove, install an adjustable
safty gate to keep toddlers, young children and other at risk individuals out of the
room and away from hot surfaces."
This appliance complies with National Safety Standards and is tested and listed to
ANSI Z21.88-2009 and CSA 2.33-2009.
1