Yamaha F30A Service Manual page 276

Index
A.
Abbreviation ................................................1-3
Adjusting the dashpot ...............................4-17
Adjusting the pilot screw ...........................4-15
Adjusting the throttle cable..........................3-8
Adjusting the throttle link.............................3-8
Adjusting the trim sensor cam
(R model) ................................................7-32
After the test run .......................................1-20
Assembling the carburetor ........................4-14
Assembling the cylinder block...................5-49
Assembling the cylinder head ...................5-36
Assembling the drive shaft........................6-16
Assembling the forward gear ....................6-16
Assembling the friction plate .......................7-9
Assembling the fuel pump...........................4-6
Assembling the gear pump .......................7-44
Assembling the lower case .......................6-15
Assembling the manual starter .................5-10
Assembling the oil seal housing................6-16
Assembling the propeller
shaft assembly ..........................................6-8
Assembling the propeller
shaft housing assembly ............................6-9
Assembling the PTT motor .......................7-37
Assembling the starter motor ....................8-11
Assembling the tilt cylinder .......................7-48
Assembling the upper case.......................7-21
B.
Backlash ...................................................6-26
Bleeding the PTT unit ...............................7-50
Bleeding the PTT unit (installed)...............7-51
Bottom cowling..........................................7-11
Bow view.....................................................8-2
Bracket unit ...............................................3-12
Break-in.....................................................1-19
C.
Carburetor.................................................4-10
Carburetor unit ............................................4-7
Changing the engine oil ..............................3-4
Changing the gear oil................................3-13
Charging system .......................................8-25
Checking the anode ..................................3-15
Checking the battery .................................3-16
Checking the battery (E and W model) .....1-15
Checking the bearing ................................6-14
Checking the brush holder
and brush ...................................... 7-37
Checking the camshaft .............................5-35
Checking the carburetor............................4-12
i-1
Checking the CDI unit............................... 8-19
Checking the charge coil .......................... 8-17
Checking the compression pressure .......... 5-1
Checking the connecting
rod big end side clearance ..................... 5-46
Checking the connecting rod
small end inside diameter and
big end inside diameter .......................... 5-45
Checking the cooling water passage .......... 3-7
Checking the cooling water pilot hole ....... 1-19
Checking the crankpin oil clearance......... 5-46
Checking the crankshaft ........................... 5-46
Checking the crankshaft journal
oil clearance ........................................... 5-48
Checking the cylinder bore ....................... 5-43
Checking the cylinder head ...................... 5-30
Checking the diaphragm and valve ............ 4-5
Checking the drive shaft ........................... 6-14
Checking the electrical component............. 8-7
Checking the engine idle speed ............... 3-11
Checking the engine oil .............................. 3-4
Checking the engine oil level.................... 1-14
Checking the engine shut-off switch
(E and W model)..................................... 8-19
Checking the engine shut-off switch
(M model) ............................................... 8-18
Checking the engine start switch .............. 8-13
Checking the engine start switch
and engine shut-off switch...................... 1-18
Checking the filter..................................... 7-43
Checking the fuel filter .........................3-3
Checking the fuel joint ................................ 4-5
Checking the fuel joint and fuel hose
(fuel joint to carburetor) ............................ 3-3
Checking the fuel pump .............................. 4-4
Checking the fuel system ......................... 1-14
Checking the fuse..................................... 7-52
Checking the fuse (E and W model)......... 8-13
Checking the gear oil................................ 3-13
Checking the gear oil level ....................... 1-15
Checking the gear pump .......................... 7-43
Checking the gear pump housing............. 7-43
Checking the gear shift
and throttle operation.............................. 1-16
Checking the gear shift operation............... 3-9
Checking the hydraulic tilt unit.................. 7-29
Checking the ignition coil.......................... 8-16
Checking the ignition spark ...................... 8-15
Checking the ignition timing...................... 3-11
Checking the lighting coil.......................... 8-25
Checking the lower case .......................... 6-15
,
8-11
Checking the lower unit for air leakage .... 3-14
Checking the manual starter....................... 5-9
,
4-4
67C3K11