Table of Contents
Advertisement
SERVICE AND TECHNICAL DATA
PREVENTIVE
MAINTENANCE TIPS
Life Fitness products are backed by the engineering excellence and
reliability of Life Fitness and are one of the most rugged and trouble-
free pieces of exercise equipment on the market today. Commercial Life
Fitness equipment are among the most popular of aerobic trainers in
health clubs, colleges and military facilities worldwide.
Warning: Safety of the equipment can be maintained only if the
equipment is examined regularly for damage or wear. Keep the
equipment out of use until defective parts are repaired or replaced. Pay
special attention to parts that are subject to wear, as outlined below.
The following preventive maintenance tips will keep the Life Fitness
product operating at peak performance:
• Locate the product in a cool, dry place
• Apply the lubricant to a cotton cloth, then wipe on the upper area of
the lower fore/aft sliders as needed. Note: only a few drops of lubricant
are required per usage.
• Clean the display console and all exterior surfaces with an approved or
compatible cleaner (see Life Fitness approved cleaners) and a microfibre
cloth
• Long fingernails may damage or scratch the surface of the console; use
the pad of the finger to press the selection buttons on the console
• Clean the top surface of the pedals regularly
• Keep the pedal straps fastened securely when using the bikes
LIFE FITNESS APPROVED
LUBRICANT
Break Free(R), Life Fitness part number SK50-P005-0000.
LIFE FITNESS APPROVED CLEANERS
Two preferred cleaners have been approved by Life Fitness reliability
experts: PureGreen 24 and Gym Wipes. Both cleaners will safely and
effectively remove dirt, grime and sweat from equipment. PureGreen 24
and the antibacterial force formula of Gym Wipes are both disinfectants
that are effective against MRSA and H1N1. PureGreen 24 is available
in a spray which is convenient for gym staff to use. Apply the spray to
a microfibre cloth and wipe down the equipment. Use PureGreen 24 on
the equipment for at least two minutes for general disinfection purposes
and at least 10 minutes for fungus and viral control. Gym Wipes are large,
durable pre-moistened wipes to use on the equipment before and after
workouts. Use Gym Wipes on the equipment for at least two minutes for
general disinfection purposes.
Contact customer support services to order these cleaners (1 800 351
3737 or email: customersupport@lifefitness.com).
LIFE FITNESS COMPATIBLE
CLEANERS
Mild soap and water or a mild non-abrasive household cleaner can
also be used to clean the display and all exterior surfaces. Use a soft
microfibre cloth only. Apply the cleaner to the microfibre cloth before
cleaning. DO NOT use ammonia or acid-based cleaners. DO NOT use
abrasive cleaners. DO NOT use paper towels. DO NOT apply cleaners
directly to the equipment surfaces.
30
PREVENTIVE MAINTENANCE
SCHEDULE
ITEM
WEEKLY
MONTHLY
BI-ANNUALLY
CONSOLE OVERLAYS
Clean
Inspect
BOTTLE HOLDERS/ACCESSORY TRAYS
Clean
CONSOLE MOUNTING BOLTS
Inspect
HARDWARE
Inspect
FRAMES
Clean
Inspect
PLASTIC COVERS
Clean
Inspect
Inspect
PEDALS AND STRAPS
Clean
Inspect
SEAT AND HANDLEBAR
Lubricate
FORE/AFT SLIDERS
WARRANTY
WARRANTY INFORMATION: LifeCycle GX
WHAT IS COVERED?
This Life Fitness commercial exercise equipment ('Product') is warranted
to be free of all defects in material and workmanship.
WHO IS COVERED?
The original purchaser or any person receiving a newly purchased
Product as a gift from the original purchaser. Warranty will be voided on
subsequent transfers.
HOW LONG IS IT COVERED?
All coverage is provided by specific Product according to the guidelines
listed on the warranty coverage chart.
WHO PAYS TRANSPORTATION AND
INSURANCE FOR SERVICE?
If the Product or any covered part must be returned to a service facility
for repairs, we, Life Fitness, will pay all transportation and insurance
charges for the first year. You are responsible for transportation and
insurance charges during the second and third years (if applicable).
WHAT WE WILL DO TO CORRECT
COVERED DEFECTS
We will ship to you any new or rebuilt replacement part or component or,
at our option, replace the Product. Such replacement parts are warranted
for the remaining portion of the original warranty period.
WHAT IS NOT COVERED
Any failures or damage caused by unauthorised service, misuse,
accident, negligence, improper assembly or installation, debris
resulting from any construction activities in the Product's environment,
rust or corrosion as a result of the Product's location, alterations or
modifications without our written authorisation or by failure on your part
to use, operate and maintain the Product as set out in your operation
manual ('manual').
One type RJ45 interchangeable network-ready and fitness
entertainment port is supplied with the Product. This port complies
with the FitLinxx CSAFE specification dated 4 August 2004 stating:
4.75VDC to 10VDC; maximum current of 85mA. Any Product damage
caused by a load exceeding this FitLinxx CSAFE specification is not
covered by warranty.
All terms of this warranty are void if this product is moved
beyond the continental borders of the United States of America
(excluding Alaska, Hawaii and Canada) and are then subject to
the terms provided by that country's local authorised
Life Fitness representative.
WHAT YOU MUST DO
Retain proof of purchase; use, operate and maintain the Product as
specified in the manual; notify customer support services of any
defect within 10 days after discovery of the defect; if instructed,
return any defective part for replacement or, if necessary, the entire
Product for repair.
OPERATION MANUAL: It is VERY IMPORTANT THAT YOU READ THE
MANUAL before operating the Product. Remember to perform the
periodic maintenance requirements specified in the manual to assure
proper operation and your continued satisfaction.
HOW TO GET REPLACEMENT
PARTS AND SERVICE
Refer to page one of this manual for your local service contact
information. Reference your name, address and the serial number of
your Product (consoles and frames may have separate serial numbers).
They will tell you how to get a replacement part or, if necessary,
arrange for service where your Product is located.
EXCLUSIVE WARRANTY
THIS LIMITED WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES
OF ANY KIND EITHER EXPRESSED OR IMPLIED, INCLUDING BUT NOT
LIMITED TO THE IMPLIED WARRANTIES OF MERCHANTABILITY AND
FITNESS FOR A PARTICULAR PURPOSE, AND ALL OTHER OBLIGATIONS
OR LIABILITIES ON OUR PART. We neither assume nor authorise any
person to assure for us any other obligation or liability concerning the
sale of this Product. Under no circumstances shall we be liable under
this warranty, or otherwise, of any damage to any person or property,
including any lost profits or lost savings, for any special, indirect,
secondary, incidental or consequential damages of any nature arising
out of the use of or inability to use this Product. Some states do not
allow the exclusion or limitation of implied warranties or of liability
for incidental or consequential damages, so the above limitations or
exclusions may not apply to you.
CHANGES IN WARRANTY NOT
AUTHORISED
No one is authorised to change, modify or extend the terms of this
limited warranty.
EFFECT OF STATE LAWS
This warranty gives you specific legal rights and you may have other
rights which vary from state to state.
OUR PLEDGE TO YOU
Our products are designed and manufactured to the highest
standards.
We want you to be completely satisfied with our products and will
do everything possible under the terms of this warranty to keep you
secure in knowing you have bought the best!
WARRANTY COVERAGE
FIVE YEARS
THREE YEARS
ONE YEAR
6 MONTHS
90 DAYS
STRUCTURAL FRAME
X
CONSOLE
X
PEDALS
X
MECHANICAL COMPONENTS
X
(cranks, flywheel, handlebar,
handlebar post, seat post, bearings,
seat and handlebar adjustment
mechanisms, drive mechanisms,
resistance mechanisms)
WEARABLE ITEMS
(saddle, upholstery, pedal straps,
water bottle holders)
LABOR
COSMETIC COMPONENTS
X
SPECIFICATIONS
• Designed use: Heavy/commercial
• Maximum user weight: 350lbs
• Display type: LCD
• Pedal speed range: 60-140rpm
• Pedal: 3.5" x 3.5" dual-sided SPD compatible
• Drive type: Multi-ribbed resistance levels: 20
• Console display 1: Resistance level, rpm, heart rate, calories per hour,
calories, distance, speed, time
• Console display 2: Speed max, speed average, rpm max, rpm average,
calories per hour average, maximum heart rate, % of maximum
heart rate
PHYSICAL DIMENSIONS
• Length: 54.6" (139cm)
• Width: 23" (58.5cm)
• Height: 39.5" (100cm)
• Weight: 111 lbs (50.5 kg)
•
Max User Weight: 350lbs (158kg)
SHIPPING DIMENSIONS
Length - 49.6" (126 cm)
Width - 9.6" (24.5 cm)
Height - 40.8" (104 cm)
Weight - 62 kg
X
X
31
© 2014 Life Fitness
Hide quick links:
Advertisement
Table of Contents
