Page 2
INTRODUCTION This service manual describes the latest service information for the IC-M1V/IC-M1EURO V VHF MARINE TRANSCEIVER at the time of publication. MODEL VERSION SYMBOL U.S.A. IC-M1V S.E.Asia Italy Europe IC-M1EURO V United Kingdom Germany To upgrade quality, all electrical or mechanical parts and inter- nal circuits are subject to change without notice or obligation.
Low power only, * Momentary high power, * Receive only NOTE: Channels 3, 21, 23, 61, 64, 81, 82 and 83 CANNOT be used by the general public in USA waters. ‘ ‘ WX CHANNEL LIST ([IC-M1V] only) Frequency (MHz) Frequency (MHz) Weather...
SECTION 2 INSIDE VIEWS • MAIN UNIT EEROM (IC7: HN58X2432TI) (IC9: HD6433835SC94H) CPU system clock (X2: CR-610, 7.9872 MHz) IF filter (FI1, FI2: SFPC450E T001, 450 kHz) IF discreminator crystal (X1: CDBCA450CX24, 450 kHz) FM IF IC (IC1: TA431136FN (D, EL)) Microphone amplifier (IC4: NJM2902V) AF analog switch...
SECTION 3 DISASSEMBLY AND OPTION INSTRUCTIONS • Removing the Rear panel • Removing the MAIN unit Rear panel MAIN unit Rubber Rear panel Front panel (2 × 20 mm), and 4 screws (2 × 3.5 mm, silver) from q Unscrew 7 screws Unscrew 2 screws (2 ×...
SECTION 4 CIRCUIT DESCRIPTION 4-1 RECEIVER CIRCUITS 4-1-3 2ND IF AND DEMODULATOR CIRCUITS (MAIN AND RF UNITS) 4-1-1 ANTENNA SWITCHING CIRCUIT (RF UNIT) The 2nd mixer circuit converts the 1st IF signal to a 2nd IF The antenna switching circuit functions as a low-pass filter signal.
4-1-5 SQUELCH CIRCUIT (MAIN UNIT) 4-2-3 DRIVE/POWER AMPLIFIER CIRCUITS The noise squelch circuit cuts out AF signals when no RF (RF UNIT) signals are received. By detecting noise components in the The signal from the VCO circuit passes through the trans- AF signals, the squelch circuit switches the AF mute switch.
4-4 POWER SUPPLY CIRCUITS 4-3 PLL CIRCUIT (RF UNIT) VOLTAGE LINES A PLL circuit provides stable oscillation of the transmit fre- quency and receive 1st LO frequency. The PLL output com- LINE DESCRIPTION pares the phase of the divided VCO frequency to the refer- The voltage from the attached battery pack.
4-5 PORT ALLOCATIONS 4-5-1 CPU (MAIN UNIT; IC9) Port Port Description Description number name number name BATT Input port for the low battely detection. Outputs S4 regulator control signals. Outputs the AF mute swtich control Outputs speaker select signal signal when the voice scrambler is SPSEL Low : The internal...
SECTION 5 ADJUSTMENT PROCEDURES 5-1 PREPARATION IC-M1V/M1EURO V can be adjusted by sending adjustment data to the RS-232C port via a PC. When you adjust the IC- M1V/M1EURO V, the optional CS-M1V ADJ (Rev. 1.0 or later), *OPC-973 ADJUSTMENT SOFTWARE CLONING AND ADJUSTMENT are required.
ADJUSTMENT SPFTWARE’S SCREEN DISPLAY EXAMPLE CS-M1V ADJ Rev.1.0 File Option COM 1: OPEN Connect Reload (F5) Disp para : Connect IC-M1V/M1EURO V [A / D] [D / A] with PC via an RS-232C serial cable FRQCON : 2 . 16V MKEY 4 . 30V...
5-2 PLL AND TRANSMITTER ADJUSTMENTS Select an operation using [↑] / [↓] keys, then set specified value using [←] / [→] keys on the connected computer keyboard. MEASUREMENT ADJUSTMENT ADJUSTMENT CONDITION VALUE UNIT LOCATION • Operating channel : ch 16 Use the adjustment program.
5-4 TRIMMER ADJUSTMENT ADJUSTMENT MEASUREMENT POINT ADJUSTMENT ADJUSTMENT CONDITION VALUE UNIT LOCATION UNIT ADJUST 1 • Operating channel : ch 16 Connect the spec- High-harmonics com- SPURIOUS • [H/L] switch : High panel trum analyzer to the ponents are minimum ([M1EURO V] •...
Page 17
IC-M1EURO V RF UNIT TOP VIEW TX sprious adjustment ([IC-M1EURO V] only) 5 - 6...
SECTION SECTION 8 PARTS LIST SEMI-CONDUCTOR INFORMATION 8 - 1 TRANSISTORS AND FETS 8 - 2 DIODES NAME SYMBOL INSIDE VIEW NAME SYMBOL INSIDE VIEW NAME SYMBOL INSIDE VIEW DA204U 2SA1588 GR 2SK880 Y HSM88AS TR 2SA1162 GR orange 2SB1132 R BARB 3SK166 2 HVU17TRF...
9 - 2 RF AND VR UNITS The combination of this page and the next page shows The combination of this page and the next page shows RF UNIT IC-M1V RF UNIT IC-M1EURO V the unit layout in the same configuration as the actual the unit layout in the same configuration as the actual P.C.
Page 28
P.C. Board. actual P.C. Board. RF UNIT IC-M1EURO V RF UNIT IC-M1V • BOTTOM VIEW • BOTTOM VIEW VR UNIT • BOTTOM VIEW RF UNIT SQLV...
9 - 3 MAIN UNIT The combination of this page and the next page shows the unit layout in the same configuration as the actual • TOP VIEW P.C. Board. SPEAKER...
Page 30
The combination of this page and the previous page • BOTTOM VIEW shows the unit layout in the same configuration as the actual P.C. Board. MICROPHONE AFOUT SPEAKER OPTIONAL UNIT RXOUT TXOUT — MICOUT OPST OPTIN — BTYPEI BP-215 RF UNIT J1 9 - 5...