Related Manuals for Winnebago Minnie Winnie Premier
Summary of Contents for Winnebago Minnie Winnie Premier
- Page 1 Rev. 1413140826 Part No. 161500-14-036 Copyright 2013 Winnebago Industries, Inc. All rights reserved.
-
Page 3: Table Of Contents
TABLE OF CONTENTS 1 – INTRODUCTION About this Manual ..........................1-1 Safety Messages Used in this Manual ....................1-1 Pre-Delivery Inspection ........................1-2 Front Axle Tire Alignment ....................... 1-2 Service and Assistance ........................1-2 Reporting Safety Defects ........................1-2 Occupant and Cargo Carrying Capacity Label ................. 1-3 Vehicle Certification Label ....................... - Page 4 Table Of Contents Battery Boost Switch ........................3-5 Air Conditioner/Heater – Automotive (Dash) .................. 3-5 Radio In-Dash/Rearview Monitor System ..................3-5 Engine Access – Interior ........................3-6 Engine Cooling System ........................3-6 Tires ..............................3-7 Suspension Alignment and Tire Balance ..................3-7 Air Springs –...
- Page 5 Table Of Contents Water Pump ............................7-2 Disinfecting Your Fresh Water System .................... 7-3 Shower Hose Vacuum Breaker ......................7-4 Toilet ..............................7-4 Drainage System (P-Traps) ....................... 7-4 Waste Water System ......................... 7-5 Waste Water System - Waste Pump (Model 27QP) ................. 7-6 Holding Tank Heater ........................
- Page 6 Table Of Contents Exterior Lights ..........................11-4 Interior Soft Goods ......................... 11-4 Cabinetry – Cleaning ........................11-5 Solid Surface Countertop – Corian® ....................11-5 Tables and Countertops ........................11-6 Galley Sink ............................. 11-6 Range and Refrigerator ........................11-6 Vinyl Flooring ..........................11-7 Bathroom ............................
-
Page 7: Introduction
The instructions included in this manual are intended as a guide, and in no way DANGER indicates a hazardous situation extend the responsibilities of Winnebago which, if not avoided, will result in death or Industries beyond the standard written serious personal injury. -
Page 8: Pre-Delivery Inspection
National Highway Traffic Safety Administration delivery inspection of the chassis and all (NHTSA) in addition to notifying Winnebago motorhome components. Industries, Inc. As a part of the pre-delivery inspection... -
Page 9: Occupant And Cargo Carrying Capacity Label
SECTION 1 – INTRODUCTION or go to their website at http://www.safercar.gov or write to: Administrator, NHTSA 1200 New Jersey Avenue S.E. Washington, D.C. 20590 You can also obtain other information about motor vehicle safety from the NHTSA website at http://www.safercar.gov OCCUPANT AND CARGO CARRYING CAPACITY LABEL This label is affixed in the driver’s area next to... -
Page 10: Vehicle Certification Label
These pressure levels must be maintained to assure proper handling, safety, 2. Chassis manufacture date. and fuel economy. 3. Month and year of manufacture at Winnebago ® 9. Rear Axle Wheel Configuration: Single or Industries Dual as it relates to the inflation. -
Page 11: Specifications And Capacities
55 gal. Notes: All information is based upon the most recent data available. Visit the Winnebago Industries, Inc. web page – www.winnebagoind.com – for the most current product information. The height of each model is measured to the top of the tallest standard feature and is based on the curb weight of a typically equipped unit. The actual height of your vehicle may vary by several inches depending on chassis or equipment variations. -
Page 12: Owner And Vehicle Information
Motorhome Serial Number ___________________________________________________________ Chassis Vehicle Identification No. (VIN) ________________________________________________ Vehicle Mileage at Delivery __________________________________________________________ Selling Dealer Name ________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ ® YOUR WINNEBAGO INDUSTRIES DEALER /SERVICE CENTER Name ____________________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ Contact ____________________________________________Phone ________________________ CHASSIS SERVICE CENTER... -
Page 13: Safety And Precautions
SECTION 2 – SAFETY AND PRECAUTIONS GENERAL WARNINGS DRIVING SAFETY • Only seats equipped with seat belts are to be occupied while the vehicle is moving. WARNING • Make sure all passengers have seat belts fastened. Lap belts should fit low on the hips and upper thighs. -
Page 14: Fuel And Propane Gas
SECTION 2 – SAFETY AND PRECAUTIONS • Do not adjust tilt steering in a moving vehicle. • Do not operate the cruise control on icy or WARNING extremely wet roads, winding roads, in heavy traffic, or in any other traffic situation where a constant speed cannot be maintained. -
Page 15: Propane Gas Leaks
SECTION 2 – SAFETY AND PRECAUTIONS • Open doors and other ventilating openings. • Leave the area until odor clears. DANGER • Have the propane system checked and leakage source corrected before using again. Do not use gas cooking appliances for Failure to comply could result in death or comfort heating. -
Page 16: Carbon Monoxide Alarm
RV application. We that is also listed for RV application. We recommend obtaining a replacement from your ® recommend obtaining a replacement from your Winnebago Industries dealer. ® Winnebago Industries dealer. Further Information... -
Page 17: Smoke Alarm
VEHICLE WITH ENGINE RUNNING FOR recommend obtaining a replacement from your AN EXTENDED PERIOD. ® Winnebago Industries dealer. Do not run engine in confined areas, such as a Further Information garage, except to move vehicle into or out of the See the manufacturer’s information in your... -
Page 18: Electrical
We recommend obtaining a replacement only from your Winnebago MAINTENANCE ® Industries dealer or a reliable RV parts supplier. -
Page 19: Using Slider Windows As Emergency Exits
SECTION 2 – SAFETY AND PRECAUTIONS Escape Window (Lift both red safety latch handles UP and push window OUT) -Typical View Escape Window (Lift both red safety latch handles UP and push window OUT) -Typical View Using Slider Windows As Emergency Exits Some coaches are required to have a slider window as an alternate exit. -
Page 20: Slideout Rooms
SECTION 2 – SAFETY AND PRECAUTIONS ventilation may allow formaldehyde and other SLIDEOUT ROOMS contaminants to accumulate in indoor air. Ventilation to dilute the indoor air may be obtained from a passive or mechanical ventilation system. Always be sure to thoroughly WARNING ventilate your recreational vehicle before and during each use. -
Page 21: Roof And Ladders
SECTION 2 – SAFETY AND PRECAUTIONS thoroughly and quickly. Avoid grease buildup warranty period, Winnebago Industries will not near the stove or sink. Clean the exhaust fan provide any financial assistance to the repair of above the stove often. the condition. -
Page 22: Roadside Emergency
However, if an proper towing equipment to use. emergency requires you to change the tire ® Winnebago Industries does not assume yourself, please exercise extreme caution and responsibility for damage incurred while towing read all tire changing information in the chassis this vehicle. -
Page 23: Jump Starting
SECTION 2 – SAFETY AND PRECAUTIONS For information on what to do in case of overheating, consult your chassis manual. WARNING Stay out from beneath the motorhome while it is suspended by the towing assembly. Do not allow passengers to occupy a towed vehicle. -
Page 25: Driving Your Motorhome
SECTION 3 – DRIVING YOUR MOTORHOME The information in this section refers only to features installed or adapted to the dash and Folding Dinette Seat Back driver compartment area by Winnebago ® Industries . It also includes passenger seating in the living area of the coach. -
Page 26: Child Restraints
SECTION 3 – DRIVING YOUR MOTORHOME protection of the safety belt, never let more than one person use the same safety belt at any one WARNING time, and do not let the safety belts become damaged by pinching them in the doors or in the seat mechanism. -
Page 27: Keys
SECTION 3 – DRIVING YOUR MOTORHOME may have a greater chance of being injured in an accident if they are seated in a child restraint system which is not properly secured. A child restraint system is designed to be secured in a vehicle seat by a lap belt or the lap belt portion of a lap-shoulder belt. -
Page 28: Mirrors - Power Sideview Exterior
SECTION 3 – DRIVING YOUR MOTORHOME Further Information See your chassis manual for instructions on activating, operating, and canceling hazard warning flashers. MIRRORS – POWER SIDEVIEW EXTERIOR –If Equipped Always adjust mirrors for maximum rear visibility before traveling. Make sure the seat is adjusted for proper vehicle control and that you •... -
Page 29: Battery Boost Switch
SECTION 3 – DRIVING YOUR MOTORHOME Further Information RADIO IN-DASH/REARVIEW Refer to the manufacturer’s user manual MONITOR SYSTEM provided in your InfoCase for further information. –If Equipped The radio in your coach can receive AM/FM BATTERY BOOST SWITCH stereo stations. It also has a CD/DVD player for your listening enjoyment through quality high- The Battery Boost switch can be used to draw output speakers located in several areas of the... -
Page 30: Engine Access - Interior
SECTION 3 – DRIVING YOUR MOTORHOME Ford Chassis • TRK - Press for manual tuning. Press and hold for seek tuning. • To remove engine cover, unlatch the two • 8 - EJECT - Press to eject the CD/DVD upper and the two lower latches located on each side of the engine cover. -
Page 31: Tires
SECTION 3 – DRIVING YOUR MOTORHOME NOTE: Your chassis engine cooling system is also cause the vehicle to “pull” to the right or left. filled with special extended-life coolant Have your dealer inspect your vehicle’s that is not the same as common anti- suspension and steering components periodically freeze available at retail outlets. -
Page 32: Lights
SECTION 3 – DRIVING YOUR MOTORHOME Air Spring Rear Air Spring Valves (Located inside left rear wheel well -Typical View LIGHTS All exterior lights should be checked for proper operation each time the vehicle is prepared for a trip. Any bulbs which fail to light should be checked and replaced, when necessary, with a new bulb of the same size. -
Page 33: Appliances And Systems
SECTION 4 – APPLIANCES AND SYSTEMS The appliances installed in your motorhome are manufactured by reputable RV appliance makers and have been tested by independent laboratories to meet all applicable standards and codes set for RV appliances. See Section 2 - Safety and Precautions of this manual for any safety and precautions you need to take regarding the operation of your appliances. -
Page 34: Refrigerator Service Access Compartment
SECTION 4 – APPLIANCES AND SYSTEMS REFRIGERATOR SERVICE ACCESS COMPARTMENT (Exterior) The exterior refrigerator service compartment allows access to the rear of the refrigerator for inspection, maintenance, and service. To Open -Typical View 1. Use a screwdriver or coin to turn the latch knobs to the vertical position as shown. -
Page 35: Range
SECTION 4 – APPLIANCES AND SYSTEMS RANGE WARNING The Range and optional Oven in your motor home operate on propane gas and will provide most of the functions of the range in your home. Gas cooking appliances need fresh air for safe operation. -
Page 36: Microwave Oven
SECTION 4 – APPLIANCES AND SYSTEMS At the touch of a button this panel will display MICROWAVE OVEN the fresh water and holding tank levels, propane gas tank level, plus the house battery condition. -If Equipped You can start the generator or turn on the water Refer to the manufacturer’s user guide located pump and water heater. -
Page 37: Water Heater - Gas
SECTION 4 – APPLIANCES AND SYSTEMS If a tank is about 1/4 full, the monitor will Refer to the Water Pump information register an empty tank because the fluid level is elsewhere in this section for additional below the 1/3 sensor even though there is still information on the water pump and initial start- fluid in the tank. -
Page 38: Pressure-Temperature Relief Valve
SECTION 4 – APPLIANCES AND SYSTEMS • The “Pilot Out” light will glow for about 10- 15 seconds, then it will go out. The “Heater Water Heater Exterior Service Access On” indicator will remain lit. • If the “Pilot Out” light comes on during Normally there is an air gap at the top of the operation, it means that the burner has gone water heater tank, which acts as a pressure buffer. -
Page 39: Propane Gas Furnace
SECTION 4 – APPLIANCES AND SYSTEMS 2. Move SYSTEM switch from Off to Heat and set the desired temperature using the Temp Selector slider. 3. Furnace fan should start to blow immediately after setting the thermostat. 4. After about 30 seconds, the furnace burner should light. -
Page 40: Ducted Roof Air Conditioning System
SECTION 4 – APPLIANCES AND SYSTEMS DUCTED ROOF AIR CONDITIONING SYSTEM The furnace thermostat also controls ducted roof air conditioner operation when the Thermostat switch is placed in “Cool” position. All cooling functions controlling to setpoint have a short cycle protection time delay of three minutes. -
Page 41: Propane Gas
SECTION 5 – PROPANE GAS PROPANE GAS SUPPLY Tank Gauge & Tank Fill Overflow Sender The propane gas system supplies fuel for the Valve Valve gas range/oven, water heater, furnace, and refrigerator (while in gas mode). When used and handled properly, this system is safe and economical and provides modern living conveniences wherever you travel. -
Page 42: Safe Use Of The Propane Gas System
SECTION 5 – PROPANE GAS to the National Propane Gas Association, propane gas outlets in the United States do not WARNING offer any other type of liquefied petroleum gas than propane to the general public.) Check local phone directory yellow pages for locations of Do not fill propane container(s) to more local propane gas refilling stations or bulk than 80 percent of capacity. -
Page 43: Propane Gas Warnings And Precautions
SECTION 5 – PROPANE GAS Propane gas also contains an odor additive PROPANE GAS WARNINGS that you can smell if propane is present in the air. AND PRECAUTIONS Here are a few precautions to observe that will help you to use the propane gas system safely: It is illegal for vehicles equipped with propane tanks to travel on certain roadways or through •... -
Page 44: Propane Gas Pressure Regulator
SECTION 5 – PROPANE GAS WARNING WARNING Propane cylinders shall not be placed or Visually inspect the pressure regulator stored inside the vehicle. Propane vent periodically for blockage by cylinders are equipped with safety accumulated debris or insect nests, etc. devices that relieve pressure by Vent obstruction could result in excessive discharging propane to the atmosphere. -
Page 45: Propane Vaporization In Cold Weather
SECTION 5 – PROPANE GAS This means that in extremely cold weather when a large volume of gas is being used by the furnace for heating, it is possible to experience a loss of gas pressure. At first, this problem may appear to be caused by an empty tank or a regulator freeze-up, but is actually caused by failure of the liquid gas to vaporize as fast as it is needed by the furnace. -
Page 47: Electrical
SECTION 6 – ELECTRICAL Your coach is equipped with an electrical the power converter automatically changes a system consisting of two separate voltages: portion of the 120-volt current to 12-volt DC current. All equipment in the motorhome that is • 12-volt DC system (battery current);... - Page 48 SECTION 6 – ELECTRICAL 30 Amp Receptacle WARNING • Swivel the small cover section upward to access the cord passage. This connection is for 110/125 Volt AC, 60 Hz 30 Ampere supply. Do not exceed circuit rating. Exceeding the circuit rating may cause a fire and result in death or serious injury.
-
Page 49: Power Center
SECTION 6 – ELECTRICAL power fails, contact the park attendants and have them check the fuse or breaker for your supply NOTICE receptacle. POWER CENTER Do not block the converter cover vents in any way. The converter generates heat (Converter) while operating and needs unrestricted The power converter is generally located in a airflow for proper cooling. -
Page 50: Circuit Breakers - House 120-Volt Ac
SECTION 6 – ELECTRICAL reset, take immediate steps to correct the cause of ELECTRICAL OUTLETS – overheating. A portion of the house 12-volt load HOUSE 120-VOLT AC (lights or motors or both) should be turned off to reduce total load. Also, inspect the power A number of standard household electrical converter to make sure ventilation is not outlets are provided throughout the coach for... -
Page 51: Electrical Generator - 120-Volt
SECTION 6 – ELECTRICAL WARNING WARNING The GFCI will not completely eliminate Do not plug the power cord into the the risk of electrical shock. Infants and generator receptacle while the generator small children may still be affected. is running. Electrical shock can cause personal injury. -
Page 52: House Batteries
SECTION 6 – ELECTRICAL 1. Do not simultaneously operate the generator and will withstand the frequent drain-and- and a power vent, which could draw exhaust recharge cycles that occur under the demanding gases into the vehicle. conditions of a camping outing. 2. -
Page 53: Battery Access
SECTION 6 – ELECTRICAL House Batteries -Typical View House/Coach Battery Disconnect Switch (Located near entrance door) -Typical View C AU T I ON BATTERY ACCESS Battery compartment must be closed and The house/coach batteries are located in a latched. Failure can cause injury. compartment beneath the interior entrance steps. - Page 54 SECTION 6 – ELECTRICAL The two best defenses against sulfating Further precautions are: and insufficient charge are to: • Check the state of charge periodically to avoid discharge or sulfating. 1. Turn off the House/Coach Battery Disconnect switch to avoid parasitic discharge (the trickle To ensure that the battery will always accept discharge caused by directly connected and hold a charge, follow these simple...
-
Page 55: Circuit Breakers And Fuses - House 12-Volt Dc
An explosion can occur resulting in personal injury. Chassis Battery If your coach is going to be unoccupied for ® two weeks or more, Winnebago Industries recommends disconnecting the chassis battery in Functional Non-Functional your coach to avoid battery discharge. - Page 56 SECTION 6 – ELECTRICAL Automotive Chassis and House 12-Volt Circuit Breakers (Located inside passenger compartment) -Typical View 6-10...
-
Page 57: Plumbing
SECTION 7 – PLUMBING The tank is filled through the Tank Fill FRESH WATER SYSTEM Connection located on the side of the vehicle. The Fresh Water System provides water to the City Water Connection galley sink, shower, bathroom lavatory, toilet, and water heater. -
Page 58: Water Pump
SECTION 7 – PLUMBING Disconnecting from City Water 1. Turn the city water supply OFF. 2. Disconnect hose from the coach and replace the cap on the City Water Connection. 3. Turn the Water Pump Switch(es) ON. WATER PUMP When your coach is not connected to a city Unscrew bowl water supply, water is supplied from the fresh and remove to... -
Page 59: Disinfecting Your Fresh Water System
SECTION 7 – PLUMBING Initial Waterline Priming DISINFECTING YOUR FRESH 1. Ensure that all water drain valves are closed, WATER SYSTEM including water heater valve. ® (As required by NFPA 1192 Standard on 2. Turn Water Pump switch to “OFF” position. Recreational Vehicles) 3. -
Page 60: Shower Hose Vacuum Breaker
SECTION 7 – PLUMBING 5. Drain the water tank and refill with fresh If items are placed into the shower tub before water. shower valve vacuum release is complete, they may become wet. 6. Open each faucet again and run fresh water to flush chlorinated water from the lines. -
Page 61: Waste Water System
SECTION 7 – PLUMBING If you should experience a sewer odor, pour 1st - Pull Black Waste Tank Drain approximately 1 cup of water down each sink and valve to drain black water (sewage) shower drain in the coach. tank - then close. WASTE WATER SYSTEM (Holding Tanks) The drainage system is self-contained and... -
Page 62: Holding Tank Level Indicators
SECTION 7 – PLUMBING Using On-Site Sewer Hook-Ups The black water holding tank contains the sewage from the toilet and may include the The sewage drain hose may remain attached to bathroom lavatory on some models. The gray the dump outlet and be routed out the bottom of water holding tank contains the waste water from the compartment while the motor home is parked the galley sink, shower, and may include... -
Page 63: Dumping Holding Tanks
SECTION 7 – PLUMBING Dumping Holding Tanks NOTE: DO NOT OPEN BOTH VALVES AT ONCE. Do not open the Gray Waste Tank 1. Remove sewage drain hose from rear bumper Drain valve until the black tank is storage. drained and dump valve closed to avoid 2. -
Page 64: Holding Tank Heater
SECTION 7 – PLUMBING miles to dislodge the solids. A few starts and stops will aid in the process. Then reconnect the sewage drain hose and drain in the normal manner. NOTE: Always keep sewage drain outlet capped while sewage connection is not in use. Holding Tank Level Indicators See “Systems Monitor Panel”... -
Page 65: Waterline & Tank Drain Valves
SECTION 7 – PLUMBING NOTE: The holding tank heater pads are electrical resistant-type heating elements. This type of heating element typically uses a large amount of current while operating. If the tank heaters are used without a recharging source, they will drain the house batteries in a relatively short period. -
Page 66: Water Heater Bypass And Antifreeze Siphon Valves
SECTION 7 – PLUMBING WINTERIZING PROCEDURE You can winterize the water and plumbing system of your coach using the following method. Blow Out Procedure (Drain and purge waterlines using compressed air) 1. Level the Motor Home. If the coach is not WATER HEATER BYPASS AND level, there may be “low points”... - Page 67 NOTE: It is not necessary to add antifreeze to the system. A “blow-out” plug can be the toilet since the flush valve will be ® ® purchased at any Winnebago or Itasca closed. dealer. Do not add automotive antifreeze or...
- Page 68 SECTION 7 – PLUMBING Your drainage and fresh water systems are now winterized. See instructions for removal from storage in Section 11 - Maintenance and Storage. 7-12...
-
Page 69: Water System Drain Valve Locations
SECTION 7 – PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS MODEL SYSTEM DRAIN VALVE LOCATIONS 27QP Waterlines • Two (2) valves under stove. Access by removing panel under stove. Also, place the tip of your finger inside the city water connection and gently press the backflow valve (small “button”... -
Page 71: Entertainment
SECTION 8 – ENTERTAINMENT 3. Rotate TV back to center position and press TV – (SWING-OUT) straight back towards wall. You will hear a –If Equipped “click” when the TV is secured into locked position. (Typical View - your coach may vary in appearance according to floorplan) Further Information Your coach may be equipped with a TV... -
Page 72: Tv Antenna - Digital
SECTION 8 – ENTERTAINMENT • The TV screen will display the DVD player WARNING logo when the correct input is selected. Never allow the antenna to touch Play DVD electrical power lines or any other • Press “OPEN/CLOSE” on DVD player to electrical wires. -
Page 73: Tv Signal Amplifier
SECTION 8 – ENTERTAINMENT 3. Rotate the Attenuator Dial fully CLOCKWISE. 4. Press Release Button on the Rotational Knob • Power and rotate antenna (until maximum number of Switch LED lights illuminate on the Signal Meter). NOTE: LED lights will illuminate from left to right. -
Page 75: Furniture And Softgoods
SECTION 9 – FURNITURE AND SOFTGOODS BOOSTER SEAT CUSHION -If Equipped The driver and co-pilot seats may feature a Booster Seat Cushion which provides increased seat height and added comfort while in the lounge seating position. The Booster Seat Cushion must not be used when the vehicle is in motion. - Page 76 SECTION 9 – FURNITURE AND SOFTGOODS • Keep the rungs of the ladder clean and dry while in use. Do not step onto the rungs if the rungs are wet, or if your shoes are wet or carry debris that could result in a loss of footing. •...
-
Page 77: Sofa/Bed Conversion
SECTION 9 – FURNITURE AND SOFTGOODS SOFA/BED CONVERSION Lock Rod -If Equipped Sofa to Bed • Pull OUT on security latch (located on front of sofa) to release sofa seat. 2. Lift the dinette cushions upward and push table straight down. Security Latch (Located on front of sofa) - Pull OUT to release... -
Page 78: U-Shaped Dinette/Bed Conversion
SECTION 9 – FURNITURE AND SOFTGOODS Reverse steps to convert back into dinette seating. Once the table is up, engage the lock rod by 2. Lift edges of the dinette cushions up and push pushing the lock rod up. the dinette table straight down. Make sure the table is lowered as far as it will go so when arranging the cushions to cover the bed area, WARNING... -
Page 79: Fold And Tumble
SECTION 9 – FURNITURE AND SOFTGOODS FOLD AND TUMBLE –If Equipped (Typical View – Your coach may differ in appearance) 4. Arrange cushions to cover bed area. NOTE: Use the back dinette seat cushion and two bolster cushions to cover the dining table. -
Page 80: Roller Shades (Manual) - Solar/Blackout
CABINETRY –If Equipped People are drawn to the natural beauty of ® wood. At Winnebago Industries , our craftsmen work with the art found in each piece of wood to create cabinets of superior quality, backed by the Winnebago Industries warranty. - Page 81 SECTION 9 – FURNITURE AND SOFTGOODS Stains are likely to exaggerate the difference between open and closed grains and other markings in wood. Grain variation and color change should be expected. As hardwood ages, it will darken when exposed to different types of light.
-
Page 83: Slideout Rooms
SECTION 10 – SLIDEOUT ROOMS SLIDEOUT ROOM LOCK SYSTEM The Ignition Key must be in the “on” or accessory position and the park brake engaged to operate the sliderooms. SLIDEOUT ROOM OPERATION – ELECTRIC WARNING Slideout Switch Your motorhome may have more than (Your coach may have one or more one slideout room. - Page 84 SECTION 10 – SLIDEOUT ROOMS • Ensure exterior compartment doors are closed so that they will not interfere with slideout WARNING operation. • Check inside and outside the vehicle to make sure that there are no people who could be CRUSH HAZARD.
-
Page 85: Slideout Room - Extreme Weather Precaution
SECTION 10 – SLIDEOUT ROOMS • The house battery may be low on charge. Plug SLIDEOUT ROOM – EXTREME in the external power cord (shoreline), start WEATHER PRECAUTION the engine, or start up the generator (if equipped). This may assist slideout room Certain extreme weather conditions, such as operation. -
Page 86: Slideout Emergency Retraction (Lippert)
SECTION 10 – SLIDEOUT ROOMS For specific motor faults, the green LED light NOTE: If slideout room fails to retract using the will blink 1 time for Motor 1 and 2 times for Manual Override method, see “Slideout Motor 2. The red LED light will blink from 2 to Emergency Retraction”... - Page 87 SECTION 10 – SLIDEOUT ROOMS 3. Remove the top (4) pan head screws and top (4) flat head screws at the top of the aluminum trim. Slideout Motor (Located behind slideout wipe seal) • Use a screwdriver to push slideout motor UP (disengage).
-
Page 88: General Slideout Care
SECTION 10 – SLIDEOUT ROOMS Slideout Room Seal Care and 7. When the slideout room is fully retracted, secure the room with a support item (e.g. 2x4 Maintenance wood board) above the interior slideout room While most household cleaners work well for to secure room during travel. -
Page 89: Maintenance And Storage
• Have the sealant replaced if you notice any of attention. Delaying these repairs may allow water the above. Your local Winnebago Industries leakage and result in damage to interior ceiling dealer has the correct and necessary parts and and body panels, upholstery, etc., which is not experience to help you maintain your sealants. -
Page 90: Exterior Finish
SECTION 11 – MAINTENANCE AND STORAGE weight to the vehicle. This, in effect, reduces the • Wash with cool water out of direct sunlight amount of cargo you can carry and remain within using a mild liquid soap (any “no-tears” baby GVWR and GAWR limits. -
Page 91: Exterior Graphic Care
SECTION 11 – MAINTENANCE AND STORAGE If the finish begins to look dull or discolored, • Wash graphics with plain soap and water or it may need to be cleaned with a polishing or any car wash detergent. Rinse thoroughly. cleaning compound formulated for gel-coated •... -
Page 92: Exterior Lights
EXTERIOR LIGHTS motorhome is parked for an extended ® period of time. Most Winnebago Industries vehicles have polycarbonate lenses on exterior lamps, which are very sensitive to a variety of chemical solvents and cleaners. -
Page 93: Cabinetry - Cleaning
SECTION 11 – MAINTENANCE AND STORAGE CABINETRY – CLEANING WARNING Wooden items may be cleaned with a soft cloth and a good quality wood finish cleaning product. When cleaning upholstery and fabric, do Vinyl simulated wood panels may be cleaned not use lacquer thinner, nail polish with a mild, water-based cleaner and a soft cloth. -
Page 94: Tables And Countertops
SECTION 11 – MAINTENANCE AND STORAGE keep your countertop looking its best and GALLEY SINK minimize care efforts. (An occasionally sanding with a medium grade (120 grit) sandpaper will Stainless Steel remove any cut marks accumulated on the sink Care and Cleaning Instructions cover bottom). -
Page 95: Vinyl Flooring
SECTION 11 – MAINTENANCE AND STORAGE Treatment of Stains VINYL FLOORING Acids, alkali, alcoholic beverages, coffee, soft drinks, ketchup, fruit, fruit juices, food, Care and Maintenance vegetables, mustard, ink, and iodine: You can easily maintain the beauty of your • Remove the stain with lukewarm water and a vinyl flooring with little effort, by following cloth or sponge. -
Page 96: Doors And Windows
SECTION 11 – MAINTENANCE AND STORAGE Tub and Shower Walls 5. Fully charge the batteries. Batteries must have at least 80% charge to survive The tub and shower walls in the bathroom freezing temperatures and long period of should be cleaned with mild soap and warm non-use. -
Page 97: Vehicle Storage - Removal
SECTION 11 – MAINTENANCE AND STORAGE that can be damaged by freezing temperatures. Information at the beginning of this section. See “Winterizing Procedures” in Section 7 - Resealing is quite simple and the material is Plumbing. quickly and easily applied. Appropriate compounds are available from your dealer. -
Page 98: Coach Maintenance Chart
SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System ... - Page 99 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items: ...
-
Page 100: Miscellaneous
SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants ... -
Page 101: Loading The Vehicle
SECTION 12 – MISCELLANEOUS NOTE: We recommend that you dump all LOADING THE VEHICLE holding tanks before traveling to avoid carrying unnecessary weight. NOTE: Your motorhome’s load capacity is designated by weight, not by volume, so you cannot necessarily use all available WARNING space when loading your motorhome. - Page 102 SECTION 12 – MISCELLANEOUS Corner Weighing (Side-to-Side) You will first drive only your front wheels onto the scale pad, then drive ahead so that the The most accurate method of weighing a whole vehicle is on the scale, then finally pull off motorhome is to weigh each “corner”...
-
Page 103: Car Or Trailer Towing
SECTION 12 – MISCELLANEOUS axle is 12,000 lbs., then the load on each rear dual Because of individual vehicle use and loading set (left rear duals or right rear duals) should not habits, we recommend weighing the vehicle exceed 6,000 lbs. while fully loaded to avoid exceeding any of the listed Gross Weight Ratings. -
Page 104: Trailer Wiring Connector
SECTION 12 – MISCELLANEOUS Check state regulations on trailer weight and TRAILER WIRING trailer brake requirements to be sure you select CONNECTOR the right equipment before towing. Before descending a steep or long grade when Your coach is pre-wired for trailer or car towing a trailer, reduce speed and shift into a towing lights with a 7-pin socket. -
Page 105: Entrance Door Prop Rod
350 The tow vehicle brakes may be rated for lbs. All Winnebago Industries models operation at GVWR, not GCWR. equipped with a Class IV hitch have a... -
Page 106: Power Awning
SECTION 12 – MISCELLANEOUS Operating the Awning • Press and Hold the Power Awning switch IN or OUT to extend or retract the awning as desired. Ignition Lockout System The Ignition Lockout System will disable the extend function while the vehicle ignition key is in the On position. -
Page 107: Roof Ladder
SECTION 12 – MISCELLANEOUS • Make sure you are physically capable to ROOF LADDER safely use the ladder. Strength, flexibility, and stability are required. –If Equipped • Be aware that the vehicle may sway as you climb the ladder. Do not use the ladder in high WARNING winds. -
Page 108: Humidity And Condensation
SECTION 12 – MISCELLANEOUS Humidity and Condensation Moisture condensing on the inside of windows is a visible indication that there is too much humidity inside the coach. Excessive moisture can cause water stains or mildew, which can damage interior items such as upholstery and cabinets. - Page 109 INDEX About this Manual ..........................1-1 Air Conditioner Filter ..........................4-8 Air Conditioner/Heater – Automotive (Dash) ..................3-5 Air Springs – Rear Helper ........................3-7 Audio-Video System Basic Operation ....................8-1 Bathroom .............................. 11-7 Battery Access ............................6-7 Battery Boost Switch ..........................3-5 Battery Care ............................
- Page 110 Index Fire Extinguisher ............................. 2-5 Fold and Tumble ............................. 9-5 Fold-Down Dinette Seat ......................... 3-1 Formaldehyde Information ........................2-8 Fresh Water System ..........................7-1 Front Axle Tire Alignment ........................1-2 Front Overhead Bunk ..........................9-1 Fuel and Propane Gas ..........................2-2 Galley Sink ............................
- Page 111 Index Refrigerator Service Access Compartment ..................... 4-2 Reporting Safety Defects ........................1-2 Roadside Emergency ..........................2-10 Roller Shades (Manual) - Solar/Blackout ....................9-6 Roof ..............................11-1 Roof and Ladders ............................ 2-9 Roof Ladder ............................12-7 Safe Use of the Propane Gas System ...................... 5-2 Safety Messages Used in this Manual ....................
- Page 112 Index Water Heater – Gas ..........................4-5 Water Heater Bypass and Antifreeze Siphon Valves ................7-10 Water Pump ............................7-2 Water System Drain Valve Locations ....................7-13 Waterline & Tank Drain Valves ......................7-9 Weighing Your Loaded Vehicle ......................12-1 Windows ...............................