Engine Compartment; Brake Fluid - Mercedes-Benz Sprinter Operator's Manual

G WARNING
Coolant contains glycol and is therefore toxic.
Do not swallow the coolant. See a doctor
immediately if you swallow coolant.
Make sure that coolant does not come into
contact with skin, eyes or clothing. In case of
contact with eyes, rinse immediately with
plenty of clean water. Clean affected areas of
skin and clothing with soap and water
immediately. Change any affected clothing
immediately.
G
WARNING
If antifreeze comes into contact with hot
components in the engine compartment, it
may ignite. There is a risk of fire and injury.
Let the engine cool down before you add
antifreeze. Make sure that antifreeze is not
spilled next to the filler neck. Thoroughly
clean the antifreeze from components before
starting the engine.
! Take care not to spill any coolant on
painted surfaces. You could otherwise
damage the paintwork.
Example: cap and coolant expansion tank
Checking the coolant level
Stop your vehicle as far away from traffic
X
as possible on level ground.
Switch off the engine.
X
Secure the vehicle to prevent it from rolling
X
away.
Open the hood ( page 240).
X
Y

Engine compartment

Slowly turn cap : half a turn counter-
X
clockwise to allow excess pressure to
escape.
Turn cap : further and remove it.
X
Check the coolant level.
X
If the coolant reaches the maximum mark
on coolant expansion tank ;, there is
enough coolant in coolant expansion
tank ;.
Adding coolant
If the coolant drops under the minimum
X
mark on coolant expansion tank ;, add
coolant to the maximum mark.
Observe the information on coolant
mixture ratio and water quality in the
"Technical data" section (
prevent damage to the engine cooling
system, use only approved corrosion
inhibitor/antifreeze that comply with the
Mercedes-Benz Specifications for Service
Products.
Replace cap : and turn it clockwise to
X
tighten.
Start the engine.
X
After approximately 5 minutes, switch off
X
the engine and allow it to cool down.
Check the coolant level again and add
X
coolant if necessary.
Close the hood.
X

Brake fluid

G
WARNING
Brake fluid is hazardous to health. Do not
swallow brake fluid. See a doctor immediately
if you swallow brake fluid.
Make sure that brake fluid does not come into
contact with skin, clothing or eyes. Rinse
affected areas with plenty of clean water and
consult a doctor if necessary.
Always wear gloves and eye protection when
topping up brake fluid.
245
page 324). To
Y
Z