Table Of Contents - JEM Glaciator X-Stream User Manual

HEAVY FOG GLACIATOR
SPECIFICATION
HEAT EXCHANGER
3.5KW heater (@240V)
Wide bore steel vaporizing coil
Ceramic thermal trip for over-temperature protection
Electronic Temperature control using thermocouple
FLUID SYSTEM
Oscillating piston high pressure fluid pump
Low fluid detection by electronic sensor
5L fluid container (1.3 US Gal.)
Maximum fluid consumption 120mL/minute
REMOTE CONTROL OPTIONS
DMX512 decoder:
Required Channels = 2
Output is proportional for all levels above 12%
Channels supported = 1 to 511
Valid start codes = 0 (dimmer data only)
Full framing error detection implemented
Analogue control via standard JEM Multifunction Contoller.
PLC interface for simple switching control of the system.
CONTROL PANEL
2 x LED displays with 4 button keypad
Output level control from 0 to 100% for Fog
Timer range:
Delay time (toF) 0 seconds - 90 seconds
Run time (ton) 0 seconds - 90 seconds
REFRIGERATION UNIT
1 HP compressor with PWM electronic control
Uses refrigerant R404A (1.2 Kg)
OUTPUT CONNECTION
Ducting adaptor to accept 150mm (6") flexible ducting
POWER REQUIREMENTS (dependant on model)
Input voltage 230V,50Hz single phase (32A supply)
Input power (max) 4.893KW @ 230V
Current (max) 22.2A
Input voltage 208V,60Hz single phase (32A supply)
Input power (max) 4.325KW @ 208V
Current (max) 21.9A
Power connection is via 32A 3 pin IEC appliance inlet (230V machines)
or fixed cable (208V machines).
20
USER
GUIDE
USER GUIDE CONTENTS
Introduction
Features
Safety Guidelines
Machine Layout
Commissioning The Machine
Remote Control Options
DMX Operation
The Display
The Fluid System
Local Remote Fluid System
Refrigeration System Control
Evaporator Fan Control
Condenser Temperature Control
Control Panel Functions
The Timer
Basic Operation
Interface Options For Glaciator X-stream
Display Messages
Basic Fault Finding
Specification
Connections
Fuse Ratings
Filter Maintenance
© 2003 Martin Professional A/S, Denmark.
All rights reserved. No part of this manual may be reproduced, in any form or
by any means, without permission in writing from Martin Professional A/S,
Denmark.
HEAVY FOG GLACIATOR
2
2
3
4
5
5
6
8
10
11
12
13
13
14
15
16
17
18
19
20
21
21
21
USER
GUIDE
1