Log Placement (4 Log Set) - Empire Comfort Systems DVP42DP31N-2 Installation Instructions And Owner's Manual

Before you begin: This fireplace is supplied with a set of four
ceramic fiber logs. Do not handle these logs with your bare hands.
Always wear gloves to prevent skin irritation from ceramic fibers.
After handling logs, wash your hands gently with soap and water
to remove any traces of fiber.
The positioning of logs is critical to safe and clean operation of this
fireplace. Sooting and other problems may result if the logs are not
properly and firmly positioned in the fireplace. Please refer to Figure
58, Figure 59, and Figure 60 and corresponding WARNING, when
completing the following log placement steps.
1. Remove Decorative Doors (where applicable) by opening and
lifting straight up.
2. Remove Decorative front. See Page 55.
3. Release two glass frame spring clamps at bottom of firebox
4. Place rear log (#1) onto two pins on rear log support.
5. Place front left log (#2) onto two left, front pins on burner pan.
6. Place front right log (#3) onto two right, front pins on burner
pan.
7. Place top branch (#4) onto one pin on rear log and one pin on
the front left log.
8. Place decorative rock in front of grates and sides of main burner.
ATTENTION: Do not place decorative rock on logs or on burner.
The decorative rock should only be placed on the fireplace floor.
9. After all logs are properly positioned, place small "dime" size
pieces of Rockwool lightly across the front round "blue flame"
ports. Place the ember material (Rockwool pieces) side by side.
Do not stack more than one layer of embers across the burner
ports. See Figure 58.
10. Replace glass door onto firebox.
11. Secure the two glass frame spring clamps at bottom of firebox.
12. Replace Decorative Front. See Page 55.
13. Replace Decorative Doors (where applicable) by aligning hinges
over posts.
Page 34

LOG PLACEMENT (4 LOG SET)

Figure 58
WARNING
Failure to position the parts in accordance with this diagram
or failure to use only parts specifically approved with this
appliance may result in property damage or personal injury.
Attention: Do not use Figure 59 or Figure 60 to order logs. Refer
to parts view on page 58 and parts list on pages 56 and 57 to order
logs and/or ember material for your appropriate fireplace model.
Log Set Parts List
Index Part
Number Number
1 R10349
2 R10350
3 R10351
4 R10352
WARNING
If flame lifts off burner and goes out, verify insulation and
retainer were removed. See pages 15 and 22.
Figure 59
Figure 60
Description
Rear Log
Front Left Log
Front Right Log
Top Branch
31457-1-0513