Remote Wall Switch - Majestic fireplaces GBR36 Homeowner's Installation And Operating Manual

GBR Series B-Vent Gas Fireplace
U.S.: Consult the current National Fuel Gas Code,
ANSI Z223.1/NFPA 54/
Canada: CSA - B149.1 installation code.
Always check for gas leaks with a mild
soap and water solution. Apply water/soap
solution with brush only - do not over ap-
ply. NEVER test with an open flame.
The gas control is equipped with a captured screw type
pressure test point, therefore it is not necessary to pro-
vide a 1/8" test point up stream of the control.
When using copper or flex connector use only approved
fittings. Always provide a union so that gas line can
be easily disconnected for burner or fan servicing.
See gas specification for pressure details and ratings.
NOTE: If flex connector is used, it must be kept inside
of the appliance. (Fig. 5)
1/2" Gas Supply
1/2" x 3/8" Shut-off Valve
FP598
Fig. 5 Typical gas supply installation.

Remote Wall Switch

1. Thread wire through the electrical knockout located
on side of unit. Do not cut wire or insulation on
GF598
metal edges. Ensure that wire is protected. Run the
nvb GAS SUPPLY INSTALL
other end to a conveniently located wall receptacle
12/4/97
box.
2. Attach wire to switch and install switch into recep-
tacle box. Attach cover plate to switch.
3. Connect wiring to gas valve. Refer to Figure 6 or 7,
depending upon which diagram is appropriate.
CAUTION: DO NOT WIRE MILLIVOLT
REMOTE WALL SWITCH FOR GAS APPLI-
ANCE TO A 120V POWER SUPPLY. For light-
ing instructions, refer to Page 13.
8
3/8" Nipple
3/8" Union
3/8"
Nipple
R Models
On/Off
Switch
Fig. 6 Remote switch wiring for R Models.
Honeywell Ignition
PILOT
HONEYWELL S8600 B IGNITION MODULE
PV GND
MV MVPV
(BURNER)
WHITE
BLACK
BLACK
WHITE
NOVA SIT 822 VALVE
120 VAC RTN 24 VAC HOT
WHITE BLACK
WHITE
BLACK
24 VAC RTN
120 VAC HOT
40VA
GREEN
TRANSFORMER
Fig. 7 Remote switch wiring for E Models.
Pilot
Thermodisk
Valve
HV105
HV105
Generic Gas Valve
9/22/99 djt
WHITE
24V
24V SENSE SPARK
GND
WHITE
BLACK
BLACK
BLACK
WHITE
ON-OFF
SWITCH
FP670
NOVA SIT 822 VALVE WIRING DGRM.
(w/ Honeywell S8600 B Ignition Module)
4/30/98
7412955
FP670