Servicing The Engine Oil - Toro GrandStand 74534TE Operator's Manual

Cleaning the Foam Air Cleaner Element
Service Interval: Every 25 hours
1. Wash the foam element in liquid soap and warm
water. When the element is clean, rinse it thoroughly.
2. Dry the element by squeezing it in a clean cloth.
Important: Replace the foam element if it is
torn or worn.
Servicing the Paper Air Cleaner
Element
Service Interval: Every 50 hours—Clean the paper air
cleaner element.
Every 200 hours—Replace the paper
air cleaner element.
1. Clean the paper element by tapping gently to remove
dust. If it is very dirty, replace the paper element
with a new one (Figure 42).
2. Inspect the element for tears, an oily film, or damage
to the rubber seal.
3. Replace the paper element if it is damaged.
Installing the Foam and Paper Elements
Important: To prevent engine damage, always
operate the engine with the complete foam and
paper air cleaner assembly installed.
1. Carefully slide the foam element onto the paper air
cleaner element (Figure 42).
2. Place the air cleaner assembly onto the air cleaner
base or hose and secure it (Figure 42).
3. Place the air cleaner cover into position and tighten
the cover knob (Figure 42).

Servicing the Engine Oil

Service Interval: Before each use or daily—Check the
engine oil level.
After the first 8 hours—Change the
engine oil.
Every 100 hours—Change the engine
oil. (more often in dirty or dusty
conditions)
Every 200 hours—Change the engine
oil filter.
Note: Change the oil more frequently when the
operating conditions are extremely dusty or sandy.
Note: There are different oil capacities for the different
models listed in this manual. Ensure the correct amount
of oil is used.
Important: Remember to add 80% of the oil and
then gradually fill it to the full mark on the dipstick.
Oil Type: Detergent oil (API service SF, SG, SH, SJ
or SL)
Engine Oil Capacity: 58 ounces (1.7 liter) with the
filter removed; 51 ounces (1.5 liter) without the filter
removed
Viscosity: Refer to the table below
Checking the Engine Oil Level
Note: Check the oil when the engine is cold.
WARNING
Contact with hot surfaces may cause personal
injury.
Keep hands, feet, face, clothing and other body
parts away the muffler and other hot surfaces.
Important: Do not overfill the crankcase with oil
because damage to the engine may result. Do not
run engine with oil below the low mark because the
engine may be damaged.
1. Disengage the PTO, move the motion control levers
to the neutral locked position and set the parking
brake.
2. Stop the engine, remove the key, and wait for all
moving parts to stop before leaving the operating
position (Figure 44).
35
Figure 43