Kenmore SF22-804 Repair Manual

Date: 12/28/07
Parts& RepairServices
S LR% (/g
LAS H
SF22-804
Page 1 of 6
To Be Read During Regular Working Hours
Division 22, Source 790
Kenmore by EHP 24" Gas Self Clean Wall Ovens
Poor Combustion
JOB CODE &
TYPE OF FLASH MAJOR HEADING SUB HEADING
DESCRIPTION
[] Safety PROC ID:
[] Credit GPT-320 Built-In Wall Oven General Repair Per Service
SPECIAL INSTRUCTIONS:
DO NOT ORDER PARTS. The kit will be shipped directly to the customer.
SPECIAL CALL CLOSE INSTRUCTIONS at end of Flash.
790.30472400
Kenmore Model Numbers
790.30473400 790.30473401 790.30474400
790.30479400
Serial# Range
NF401xxxxx -
NF610xxxxx
CONDITION:
Under certain conditions during prolonged or extended broiling times, gas may build up within the
oven cavity and escape as flames when the oven door is opened.
CORRECTION:
To correct this situation install Kit #628.903077-9010 which will reduce the cooling fan speed in bake
and broil modes. In the self-clean cycle the cooling fan will operate at high speed.
NOTES:
• Models with Serial #s NF61 lxxxxx and above have incorporated the dual speed operation and do
not require this kit.
• Only THIS REPAIR is covered by this Service Flash.
- If you are on a call for another reason, and the unit falls within the models and serial numbers in
this flash, call the Pro-Team @1-888-549-4557 and request another Service Order be created.
Advise the customer not to use the broil function until the oven has the kit installed.
- If repairs other than the repair referenced in this flash are required, an additional Service Order
MUST be created.
Parts included in Kit # 628.903077-9010
1 Switch
1 Screw
1 Speed Nut
1 Thermostat -120 °
2 Screws
1 Resistor
#318120711
#73200-2080
#73204-1650
#318003613
#73201-2140
#73213-2350
1 Screw
1 Wire #1 8in .250/skinned
2 Wire #2&3 8in .250/piggyback
2 Wire #4&5 8in .250/.187
1 Wire Nut Connector
1 Instruction Sheet
#73201-2140
#318052584
#318052585
#318052586
#73213-2290
#318205012
Confidential Information -For Internal Use Only
DEPARTMENT 702HSX - Leo Steinys
DEPARTMENT 702PSO - Bob Vondale