SAFETY INFORMATION CAUTION This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.
Page 3
[Important Check Points for Good Servicing] In this manual, procedures that must be performed during repairs are marked with the below symbol. Please be sure to confirm and follow these procedures. 1. Product safety Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by following the safety instructions described in this manual.
2. EXPLODED VIEWS AND PARTS LIST OTES : • Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List. • The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.
Page 7
(1) PACKING SECTION PARTS LIST Mark No. Description Part No. Mark No. Description Part No. Remote Control Assy CXC4064 Cord Assy CDE7804 Polyethylene Bag CEG1171 Screw Assy CEA5328 Cord Assy YDE5010 Screw BYC30P100FTB Polyethylene Bag See Contrast table(2) Screw BYC40P180FTB Polyethylene Sheet CNM4338 Carton...
3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM 3.1 SCHEMATIC DIAGRAM(GUIDE PAGE) Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST". Large size SCH diagram RCA IN(50 Hz) 400 mVrms to 6.5 Vrms = -5.74 dBs to 18.5 dBs CONTROL PCB BB ON GAIN TYP...
Page 11
AMP PCB AMP UNIT Consists of AMP PCB CONTROL PCB LED PCB NOTE : Symbol indicates a resistor. Decimal points for resistor The > mark found on some component parts indicates No differentiation is made between chip resistors and and capacitor fixed values the importance of the safety factor of the part.
4. PCB CONNECTION DIAGRAM 4.1 AMP PCB Capacitor Connector NOTE FOR PCB DIAGRAMS AMP PCB 1.The parts mounted on this PCB SIDE A include all necessary parts for several destination. For further information for SIDE B Chip Part P.C.Board respective destinations, be sure to check with the schematic dia- gram.
Page 19
SIDE A SPEAKER OUTPUT SPEAKER OUTPUT CN101 CN1351 PRS-D1000M/XU/UC...
5. ELECTRICAL PARTS LIST NOTE: Parts whose parts numbers are omitted are subject to being not supplied. • The part numbers shown below indicate chip components. • Chip Resistor RS1/_S___J,RS1/__S___J Chip Capacitor (except for CQS..) CKS.., CCS.., CSZS..The > mark found on some component parts indicates the importance of the safety factor of the part. •...
Page 27
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No. Q 915 (B,120,69) Chip Transistor DTC114TUA L 202 (A,289,56) Ferri-Inductor CTF1007 Q 916 (B,126,69) Transistor 2SC4081 L 211 (A,252,61) Ferri-Inductor CTF1007 Q 917 (A,109,67) Transistor DTA114EU L 301 (A,236,140) Choke Coil 18.25 µH CTH1350 Q 918 (A,94,67) Transistor...
Page 28
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No. R 166 RS1/16S472J R 338 (A,188,178) RS1/2PMF100J R 167 RS1/16S222J R 339 (A,193,178) RS1/2PMF100J R 168 RS1/16S101J R 340 (A,210,178) RS1/2PMF100J R 169 RS1/16S822J R 341 (A,223,178) RS1/2PMF100J R 170 RS1/16S153J R 342...
Page 29
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No. R 606 (A,49,138) RD1/2PM220J R 960 (B,129,43) RS1/16S473J R 607 (A,63,137) RD1/2PM220J R 961 (A,128,39) RD1/4PU222J R 608 (A,184,113) RD1/2PM102J R 962 (A,23,97) RD1/2PM121J R 901 (A,33,70) RD1/2PM220J R 963 (A,24,150) RD1/2PM121J...
Page 30
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No. C 216 (A,256,66) CKSRYB103K50 C 342 (A,189,57) 10 µF/100 V CEAT100M2A C 217 (A,252,69) CKSRYB104K50 C 343 (A,199,57) 10 µF/100 V CEAT100M2A C 219 (B,249,59) CKSQYB103K50 C 344 (A,193,39) CFTNA103J50 C 221...
Page 31
Circuit Symbol and No. Part No. C 920 (A,106,67) CKSRYB103K50 C 921 (A,123,69) CEAT220M50 C 922 (B,105,56) CKSRYB103K50 C 923 (A,103,58) CEAT101M16 C 924 (B,108,58) CKSRYB103K50 C 925 (B,110,51) CKSRYB223K50 C 926 (A,112,49) CEAT100M50 C 927 (B,117,49) CKSRYB223K50 C 928 (A,119,49) CEAT100M50 C 929...
6. ADJUSTMENT 6.1 OFFSET VOLTAGE ADJUSTMENT - Connection Diagram AMP PCB (SIDE A) POWER TERMINAL SPEAKER SPEAKER OUTPUT OUTPUT mV Meter Rg = 1k Rg = 1k - Offset Voltage Adjustment Measurement condition Measurement point Adjustment point Adjustment Method mV Meter : 0 ± 15 mV Power on SP OUT VR301...
7. GENERAL INFORMATION 7.1 DIAGNOSIS 7.1.1 DISASSEMBLY Removing the Case (Fig.1) Case Remove the two screws. Remove the five screws and then remove the Case. Fig.1 Removing the Amp Unit (Fig.2) Disconnect the connector. Remove the six screws. Remove the nine screws and then remove the Amp Unit.
Need help?
Do you have a question about the PRS-D1000M Series and is the answer not in the manual?
Questions and answers