This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to cause cancer, birth defects or other reproductive harm. Health & Safety Code Section 25249.6 - Proposition 65 L 13942296513 u163 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be u163 installed before shipment. Please be sure to follow this method especially if it is specified in this manual. PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. u163 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
See the table below for the items to be checked regarding video and audio: Item to be checked regarding audio Distortion Noise Volume too low Volume too high Volume fluctuating Sound interrupted L 13942296513 u163 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
- Lubricants and Glues list Name Jig No. Remarks Bond GEM1017 Applying to Chemical Capacitor etc. (*) Bond GYL1006 Applying to Thermistor (*) You can use GEM1017 even if the color is defferent from the original ones. L 13942296513 u163 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Remove the nine screws and then remove the Case. Case Fig.1 L 13942296513 Note) When removing the case, remove it from the positioning side. Removal from the opposite side may deform the positioning pin. (Fig.2) Positioning pin Fig.2 u163 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Page 15
Amp Unit Fig.3 L 13942296513 Note) Remove a screw for MODE SELECT only when switching over the mode selection.You do not have to remove this screw when removing the unit board. (Fig.4) Screw for MODE SELECT Fig.4 u163 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Page 16
*Be aware not to apply bond on contact point of connector, * TACK-FREE TIME 5 minutes seat area of screw. * TACK-FREE TIME 10 minutes u163 Note) When applying bond to two Film Capacitors (C887 and C888) , attach them and apply bond. PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Page 17
When installing a Spring for holding of Thermistor, Place a Thermistor at the center of FET such that tighten a screw while pushing down the spring. the rightmost terminal of FET and the Thermistor terminal are separated by 1 mm or more. PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
8. EACH SETTING AND ADJUSTMENT 3 7 63 1515 0 8.1 ADJUSTMENT - Adjustment Point AMP UNIT (SIDE A) VR801 T201 VR201 CN108 CN501 RCA INPUT VR161 T161 CN891 SP OUTPUT L 13942296513 Q866 Q869 Q870 Q865 DC voltmeter u163 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Page 19
Offset → ±VH → Offset → ±VH → Offset Rough adjustment of VR center is permissible, so check the offset at first and last. Note: When connecting or adjusting the lead, be careful not to short-circuit it with other portions. L 13942296513 u163 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) 9.1 PACKING L 13942296513 u163 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Page 21
Remote Control Assy CXC4064 Polyethylene Bag CEG1171 Polyethylene Bag(EW5) CEG1317 Lock Tie CNV-754 Unit Box(UC) CHG6198 Unit Box(EW5) CHG6199 Owner's Manual,Installation Manual Part No. Language CRD4227 English, French, Spanish CRD4226 English, Spanish, German, French, Italian, Dutch, Russian L 13942296513 u163 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Page 23
Please exchange it for new parts when you remove the Holder Unit from the product. Reattachment of the Holder Unit having once peeled off may possibly leak the light from an aperture generated by the weak adhesion of two-sided tape. u163 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Page 24
BBZ30P060FTC(3 x 6) BSZ30P060FTC(3 x 6) Holder and Panel Thermistor, Transistor BBZ30P060FTB(3 x 6) CBA2011(3 x 8 Tapping Screw) CBA2011(3 x 8 Tapping Screw) L 13942296513 Badge Terminal Cover CBA2115(M2.6 x 6) YBA5002(M6 x 10 Flat-head Screw) u163 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Symbol indicates a capacitor. identical designation. No differentiation is made between chip capacitors and 0.022 R022 discrete capacitors. Guide page -4.0 dBs Detailed page BB OFF GAIN NORMAL -3.8 dBs -3.8 dBs CN1351 > L 13942296513 1000P u163 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
10.2 REMOTE CONTROL UNIT 3 7 63 1515 0 REMOTE CONTROL UNIT BASS BOOST CONTROL DTC114EUA CN561 L 13942296513 DTC114EUA u163 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
11.2 REMOTE CONTROL UNIT 3 7 63 1515 0 SIDE B REMOTE CONTROL UNIT SIDE A REMOTE CONTROL UNIT CN561 12dB L 13942296513 BASS BOOST CONTROL u163 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Page 40
(A,123,96) RD1/4PU392J D 854 (B,267,157) Diode UDZS27(B) R 141 (A,132,111) RD1/4PU101J R 142 (A,123,111) RD1/4PU472J D 855 (B,264,157) Diode UDZS27(B) R 143 (B,115,122) RS1/16S223J D 861 (A,240,178) Diode ERA92-02VH R 144 (A,132,119) RD1/4PU221J D 901 (B,154,65) Diode MA111 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Page 41
R 607 (B,278,212) 10 kΩ CCN1152 R 310 (B,225,165) RS1/16S2201F R 608 (B,283,212) RS1/16S182J R 311 (B,210,169) RS1/16S2201F R 611 (B,295,142) RS1/16S820J R 401 (B,139,181) RS1/16S103J R 612 (B,286,210) RS1/16S101J R 402 (B,145,181) RS1/16S103J R 613 (B,295,209) RS1/16S122J PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Page 42
(A,53,128) 4 700 µF/25 V CCH1738(P45) C 204 (A,59,173) CQMA472J50 R 904 (B,162,48) RS1/16S104J C 205 (A,105,174) CQMA472J50 R 905 (B,159,59) RS1/16S473J C 206 (B,124,163) CKSRYB223K50 R 906 (B,162,59) RS1/16S472J R 907 (B,157,59) RS1/16S473J C 207 (A,116,141) CEAT221M25 R 908 (B,164,59) RS1/16S472J PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Page 43
(B,269,171) CKSRYB272K50 C 863 (B,236,165) CKSRYB104K50 C 552 (B,262,176) CKSRYB103K50 C 864 (A,240,169) CEAT100M50 C 553 (B,267,187) CKSRYB272K50 C 865 (A,230,169) CEAT101M16 C 554 (A,290,188) CEAT100M50 C 866 (B,231,53) CKSRYB474K16 C 555 (B,262,182) CKSRYB103K50 C 867 (B,225,41) CKSQYB472K50 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Page 44
D 1366 (B,21,11) Diode UDZS16(B) D 1367 (B,29,16) Diode UDZS16(B) S 1351 (A,6,11) Switch(BASS BOOST) CSD1128 RESISTORS R 1351 (B,15,16) RS1/16S103J R 1352 (B,18,18) RS1/16S102J R 1353 (B,31,21) RS1/16S103J R 1354 (B,31,16) RS1/16S102J R 1359 (B,16,8) RS1/16S102J u163 PRS-D1200SPL/XU/UC http://www.xiaoyu163.com...
Need help?
Do you have a question about the PRS-D1200SPL and is the answer not in the manual?
Questions and answers