Related Manuals for Valor Willow
Summary of Contents for Valor Willow
- Page 1 Operating & Installation Manual Willow Multifuel Stove Willow Multifuel Stove Schiffsausrüster PLEASE RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE Tel.: +49 ( 0 ) 40 - 88 90 100 www.toplicht.de...
- Page 2 SOME OF WHOSE BRAND NAMES ARE "CALCO", "PETROCOKE" OR "WONDERCO" MUST NOT BE BURNED IN THIS APPLIANCE TO USE THESE FUELS WILL INVALIDATE THE APPLIANCE GUARANTEE IF IN DOUBT CONTACT THE SOLID FUEL ASSOCIATION TELEPHONE NUMBER 0800 600 000 www.solidfuel.co.uk Willow Multifuel Stove...
-
Page 3: Table Of Contents
Annual Maintenance Air For Combustion Part List 19-20 Firebox Liner Panels GUARANTEE Removal of Throat Plate FINAL FACTORY CHECK LIST Fitting the Optional Floor Fixing Kit Fitting the Flue Outlet and Hotplate Flues & Chimneys 9 - 12 Willow Multifuel Stove... -
Page 4: Safety Notices
•Use gloves to provide additional grip. THE PRINCIPLE OF THE FIRE Your Willow Multifuel Stove is built to the highest standard of craftsmanship using the best materials and the most modern equipment available. It is a highly efficient and sophisticated piece of... -
Page 5: Check List
8. Rear liners AFS1093 9. Side liners AFS1091 10.Fire door handle AFS205 The model and Serial Number of your fire can be found stamped into the casing, centrally just below the bottom edge of the fire door aperture. Willow Multifuel Stove... -
Page 6: Technical Data
1 - 4 kW Room heater only output (kW) Height (mm) Width (mm) Depth (mm) Height to centre of rear flue Depth from back to centre of flue Flue diameter 102 (4”) Unpacked 31Kg Weight Kg Packed 35 Kg Willow Multifuel Stove... -
Page 7: Installation
To make movement easier internal fittings, grates, fan to either of these rooms is not recommended. firebox liners, flue outlets, hot plate, throat plate, etc., can be removed. Care should be taken to make sure that the hinges are not damaged during installation. Willow Multifuel Stove... -
Page 8: Firebox Liner Panels
FIREBOX LINER PANELS REMOVAL OF THE THROAT PLATE Blocked chimneys cause dangerous fumes to The Willow multifuel stove use firebox liner panels escape. Remove throat plate at least monthly to to the sides and back. The throat plate sits on top of clean. -
Page 9: Fitting The Flue Outlet And Hotplate
•Flue terminal. The stove must be connected to a suitable and efficient flue that provides a good up draught to safely take the products of combustion (fumes) from the stove outlet to the outside air. To ensure a Willow Multifuel Stove... -
Page 10: For All Appliances
England and Wales is available from The Sweeps): telephone 01785 811732 Stationery Bookshops and can also be www.chimneyworks.co.uk viewed at the ODPM website at www.safety.odpm.gov.uk/bregs/brads.htm Details on the relevant Building Regulations and BS British Standards are given in the "General Willow Multifuel Stove... - Page 11 INSTALLATION Willow Multifuel Stove...
- Page 12 INSTALLATION YPICAL ETAL NSULATED HIMNEY YSTEM O BE INSTALLED TO THE CHIMNEY MANUFACTURERS INSTRUCTIONS IN COMPLIANCE BS7566 P WITH BUILDING REGULATIONS AND Willow Multifuel Stove...
-
Page 13: Air Inlet Controls
PRIMARY AIR FOR MULTIFUEL Air enters the appliance through the control on the •Remove assembly from the appliance. bottom of the fire door. The Valor Willow has a single control knob which slides left to right. •Clean and/or adjust. Sliding the knob to the right will increase the amount of air intake to the stove. -
Page 14: Fire Door Glass
Fig. 12a fitting new door gasket •When the appliance is cold, open the fire door so that it is at right angles to the front of the fire. •Lift the fire door up off its hinges. Willow Multifuel Stove... -
Page 15: Fuels
Note: If you have sticky tar inside the appliance or chimney your wood is 'Green' or too wet. Recommended Reading: "Wood as Fuel" available from the Forestry Commission. Willow Multifuel Stove... -
Page 16: Lighting The Fire
•Light in the normal manner with paper and kindling, or use a fire lighter. •If using a gas poker be sure to remove it immediately the fire is alight. •When the fire is well alight regulate the burning Willow Multifuel Stove... -
Page 17: Extended Burning
Do not attempt to re-light the fire until the inspected and any damaged parts have been repaired cause of the fume emission has been identified and or replaced. This should be done by a competent corrected person such as a HETAS registered engineer. Willow Multifuel Stove... -
Page 18: Annual Maintenance
It is best cleaned by brushing down that may need replacing, from your Valor dealer. With with a clean shoe brush. Do not allow moisture to remain a wire brush clean inside the appliance paying attention on the appliance whilst cold or surface rust may form. -
Page 19: Part List
Part No. 1. Main Door Assembly Complete with Handle,Glass, AFS1098 Gaskets,Clips and Seal. 2. Throat Plate AFS1086 3. Fuel Grate AFS1087 4. Flue Spigot AFS009A 5. Operating Tool AFS008 6. Fire Door Locking Assembly AFS204 7. Ashpan AFS1088 Willow Multifuel Stoves... - Page 20 Gasket 12. Glass Clips with AFS1096 Gasket 13. Hinge kit Comprises 2 Hinges AFS047 & 4 Fixings Per Set. 14. Willow Airwash AFS1097 15. Fire Door Rope Kit Complete with AFS048 Door Rope Glue. 16. Optional Floor Fixing Kit. AFS1135...
-
Page 21: Guarantee
GUARANTEE Your Valor Willow stove carries a guarantee against defects of manufacture and faulty workmanship for a period of one year from the date of purchase. This does not apply to items which would be subject to fair wear or tear. Firebox liner panels, throat plate, door rope, door glass and gaskets are not covered by the guarantee. -
Page 22: Final Factory Check List
FINAL FACTORY CHECK LIST Model........Serial No......QUALITY FINISH I’ve checked it PARTS and it’s O.K. FLUE OUTLET GRATE FIREBOX LININGS THROAT PLATE Assembled by......AIR WASH DOOR CATCHES Checked by ........ ASH PAN OPERATING TOOL OPERATING INSTRUCTIONS Baxi Fires Division, Erdington, Birmingham, B24 9QP...