Page 1
Operating & Installation Manual Hamlet Multifuel Stove Valor Hamlet Multifuel Stove PLEASE RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE Baxi Fires Division, Wood Lane, Erdington, Birmingham B24 9QP Rev 1 Tel. 08706 061 064 July 2006 Fax. 0121 373 8181 AFS1283...
Page 2
TO USE THESE FUELS WILL INVALIDATE THE APPLIANCE GUARANTEE IF IN DOUBT CONTACT THE SOLID FUEL ASSOCIATION TELEPHONE NUMBER 0800 600 000 www.solidfuel.co.uk THE USE OF SPARE PARTS OTHER THAN THOSE SUPPLIED BY VALOR WILL INVALIDATE THE APPLIANCE GUARANTEE. Valor Hamlet Multifuel Stove...
Ash Removal Cleaning - Internal Surfaces Extended Burning Cleaning - Outer Finish Spare Parts List 23-25 Door Glass GUARANTEE Chimney Sweeping SERVICE RECORD Annual Maintenance FINAL FACTORY CHECKLIST Summer Storage / Non Usage Disassemble Airwash 15-16 Valor Hamlet Multifuel Stove...
• Avoid twisting at the waist. It is better to reposition your feet. Valor stoves are fitted with an "air wash" so called • Avoid upper body/top heavy bending. Do not because it provides a curtain of high speed preheat-...
Room Heater Only Output (kW) Height (mm) Width (mm) Depth (mm) Height to Centre of Rear Flue Depth from Back to Centre of Flue (mm) 127 (5”) Flue Diameter Weight Packed (Kg) 64 Kg Ideal Log Length (mm) Valor Hamlet Multifuel Stove...
(or openings) should be increased by 300mm for each kW of rated output. HEARTH The fire should be installed to stand on a constructional hearth of non-combustible materials Valor Hamlet Multifuel Stove...
Factory made insulated chimney complying with BS 4543: Part 2 (often called "Class 1 prefabricated metal chimney"). These types of chimney should be installed in accordance with the Building Regulations and BS 7566: Parts 1 to 4. Valor Hamlet Multifuel Stove...
Document J of the Building Regulations for Sweeps): telephone 01785 811732 England and Wales is available from The Stationery www.chimneyworks.co.uk Bookshops also viewed ODPM website www.safety.odpm.gov.uk/bregs/brads.htm Details on the relevant Building Regulations and BS British Standards are given in the "General Valor Hamlet Multifuel Stove...
Page 10
INSTALLATION Fig. 2. A Typical Rear Flue Layout Valor Hamlet Multifuel Stove...
Page 11
IEW OF REGISTER PLATE AND CLEARANCES FOR NON INSULATED FLUES A is minimum clearance for non-insulated flue = 1.5 x D to a non-combustible surface/material 3 x D to combustible surface/material Fig. 3. A Typical Top Flue Layout Valor Hamlet Multifuel Stove...
PANEL & THROAT PLATE ASSEMBLY The Valor Hamlet multifuel stove uses reflective liners to the sides and back of the firebox. A throat plate sits on top of the side and rear panels. These should come fitted to your fire, if however they are not, proceed as follows to fit them.
MULTIFUEL GRATE GRATE BAR REPLACEMENT GRATE The grates in the Valor Hamlet stove, comprises of After extended use it may be necessary to replace a series of reciprocating cast iron grate bars seated some of the grate bars. Periodic inspection of the on a pivoting "comb".
SERVICING & MAINTENANCE Note: Use only genuine Valor touch-up spray as CLEANING some paints interact. This could ruin the finish and invalidate the guarantee. INTERNAL SURFACES IMPORTANT - DOOR GLASS Under some circumstances soot can quickly build The door glass should remain clear during normal up on the throat plate and adjacent areas.
•Unscrew (Anti-clockwise) the airwash control re-order any items that may need replacing, from knob, see Fig. 10. your Valor dealer. With a wire brush clean inside •Move cover up by tapping each end of the front the appliance paying particular attention to the cover.
•Re-place the gaskets and line them up in relation to the door frame. See Fig.13. Fig. 15. Tightening The Glass Clips Fig. 13. Lining up the gasket Fig. 16. Finished Door Assembly Valor Hamlet Multifuel Stove...
17. •Refit the door and check to ensure it now sits square to the body and the central gap between each door is even, if not repeat above steps. Fig. 17. Adjusting The Door Hinges Valor Hamlet Multifuel Stove...
The Hetas Ltd, "Three tick" appliance approval only covers the use of the following fuels in this appliance;Phurnacite, Phurnacite Plus, Centurion, Maxibrite,Extracite,Pureheat, Blazebrite, Taybrite, Sunbrite (double/singles), Anthracite (large nuts), Ancit and Welsh Dry Steam Coal (large/small nuts). Valor Hamlet Multifuel Stove...
•Ensure that the multifuel grate and ash pan are in position and the fire doors are closed. •Set the air wash to one quarter open position. •Set the primary inlet to the fully open position •Light in the normal manner with paper and Valor Hamlet Multifuel Stove...
AIR INLET CONTROLS MULTI-PURPOSE OPERATING TOOL The Valor Hamlet multifuel stove has two air inlets: Your Valor Hamlet stove comes with a multi-pur- •The primary air inlet providing under draught to pose operating tool, which is used for riddling, set-...
It is necessary to maintain an ash layer on the upper surface of the grate bars, in order to protect A stove mitten is supplied with your Valor Hamlet them so de-ashing should cease as soon as the first multifuel stove, this is provided for the operation of red embers drop into the ash pan.
In the morning •Open the air control fully until embers begin to glow brightly and place pieces of fuel on the fire until it is well established. Valor Hamlet Multifuel Stove...
Hamlet Part Description (not to scale) Part No. 1. Fuel Retaining Bar AFS1192 2. Throat Plate AFS1019 3. Grate Bar AFS001 4. Hot Plate AFS010 5. Operating Tool AFS008 6. Ashpan AFS058 7. Flue Spigot AFS009 Valor Hamlet Multifuel Stove...
Page 24
8. Liner Set AFS1156 9. Side Liner AFS1058 10. Back Liner AFS1157 11. Glass Replacement Kit Complete AFS1278 with Gasket 12. Glass Clips AFS1010 13. Hinge kit Comprises 2 Hinges & 6 AFS1279 screws. 14. Airwash AFS1280 (Curved) Valor Hamlet Multifuel Stove...
Assembly Complete with Handle,Glass, AFS1281 Gaskets,Clips and Seal. AFS1282 17. Replacement Instruction Manual AFS1283 18. Fire Door Locking Assembly AFS1284 19. Stove Mitten. AFS1285 20. Rear Grate Bar Support AFS1277 21. Comb with Comb Extension AFS1276 Valor Hamlet Multifuel Stove...
Firebox liner panels, throat plate, door rope, door glass and gaskets are not covered by the guarantee. However, should you have any problems with your appliance please contact your Valor stockist who will have the knowledge and facilities to help you.
Work Carried Out Signature Date of Visit Should you have any questions about your Valor Hamlet Multifuel Stove that is not covered in this manual please contact your Valor retailer. Please keep all repair receipts safely. Please ensure you have this manual available when an engineer visits as they will complete the service record chart.
FINAL FACTORY CHECK LIST Model........Serial No......QUALITY FINISH I’ve checked it PARTS and it’s O.K. FLUE OUTLET HOT PLATE FUEL RETAINER BARS X2 GRATE BARS Assembled by......FIREBOX LININGS THROAT PLATE Checked by ........ AIR WASH DOOR CATCH ASH PAN OPERATING TOOL OPERATING INSTRUCTIONS STOVE MITTEN...