1. Manuals
  2. Brands
  3. Magikitch'n Manuals
  4. Broiler
  5. LPG-30
  6. Use and care instructions manual

Magikitch'n LPG-30 Use And Care Instructions Manual

Self-contained propane fueled outdoor charbroiler
Hide thumbs Also See for LPG-30:
Table of Contents

Advertisement

Quick Links

See also: Instructions for Using
COMMERCIAL COOKING APPLIANCES
Model LPG-30 & LPG-60
Self-Contained Propane Fueled
Outdoor Charbroiler
Use and Care Instructions
Model # _________________________
Serial # __________________________
Date: ___________________________
Retain this Manual for future reference
MAGIKITCH'N
P.O. BOX 501
CONCORD NH 03302-0501
509 ROUTE 3A
BOW NH 03304
800-258-3708
603-225-6684
FAX 603-225-8497
WWW.MAGIKITCHN.COM
L25-003 Rev 2
4/4/2002

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the LPG-30 and is the answer not in the manual?

Questions and answers

Related Manuals for Magikitch'n LPG-30

Summary of Contents for Magikitch'n LPG-30

  • Page 1 COMMERCIAL COOKING APPLIANCES Model LPG-30 & LPG-60 Self-Contained Propane Fueled Outdoor Charbroiler Use and Care Instructions Model # _________________________ Serial # __________________________ Date: ___________________________ Retain this Manual for future reference MAGIKITCH’N P.O. BOX 501 CONCORD NH 03302-0501 509 ROUTE 3A...

  • Page 2: Table Of Contents

    TABLE OF CONTENTS Safety Information Charbroiler Assembly and Installation Assembly Diagram Installing the Side Rack & Propane Tank on a 30” Unit Connecting the Gas Lines to the Propane Tanks Operating, Lighting and Cleaning Instructions Burner and Orifice Inspection Charbroiler Illustration and Parts List Tank Rack Illustration and Parts List 10.

  • Page 3: Safety Information

    1. SAFETY INFORMATION Safety instructions should be obtained from your local gas supplier and posted in a prominent location near the area of operation. These instructions are to be followed in the event of a gas leak. FOR YOUR SAFETY Do not store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance.
  • Page 4 1. SAFETY INFORMATION (continued) • Unit intended for mobile, non-permanent installation only. Adequate clearances (minimum of 3’) in front of the unit for servicing and proper operation must be maintained. Use only the legs and casters supplied with unit. Do not block the front or sides of unit. •...
  • Page 5 1. SAFETY INFORMATION (continued) • Caution: The gas pressure regulator(s) provided with this appliance must be used. The regulator is set for an outlet pressure of 10 inches water column. • Do not locate this appliance under overhead unprotected combustible surfaces. •...

  • Page 6: Charbroiler Assembly And Installation

    2. CHARBROILER ASSEMBLY and INSTALLATION These unassembled parts should be included in your charbroiler package (Figure 1): Item Number Description Cooking Grid (s) Radiants Frame Assembly Runner Tube Cover(s) Water Tub(s) Base Leg & Swivel Lock Caster Assemblies ASSEMBLY INSTRUCTIONS (Refer to Figures 1 &...

  • Page 7: Assembly Diagram

    3. ASSEMBLY DIAGRAM Figure 1 L25-003 Rev 2 4/4/2002...

  • Page 8: Installing The Side Rack & Propane Tank On A 30" Unit

    4. INSTALLING the SIDE RACK and TANK on the residential 30” UNIT Upper hold down bracket Tank rack body Pipe legs Regulator and hose assembly Lower tank bracket 20 lb. Tank (Some steps here will not be necessary if this is a new unit being assembled under Section 2) A.

  • Page 9: Connecting The Gas Lines To The Propane Tanks

    Upper hold down bracket Left side tank rack installed Right side tank rack installed Lower tank bracket Left side tank, regulator and hose assembly, installed Right side tank, regulator and hose assembly, installed Note the orientation of the hose assembly in each case CONNECTING the GAS LINES to the PROPANE TANKS A.

  • Page 10: Operating, Lighting And Cleaning Instructions

    7. OPERATION, LIGHTING and CLEANING • Assemble unit per installation and assembly instructions. • Fill water tubs to within ½” of top edges (this will control grease flare-ups, provide for ease of cleaning and keep cooked foods moist). Re-fill tubs with water when they evaporate to within ½” of the bottom of the tubs.

  • Page 11: Burner And Orifice Inspection

    Cleaning the Unit • Clean the unit regularly after use. • Cooking Top Grid: After removing from the unit, use warm soapy water and a stiff bristled brush or plastic pad. Cooking grid (top grid) must be removed to steam clean or pressure wash. Do not use steel wool or abrasive pads as they may degrade the metal finish.

  • Page 12: Charbroiler Illustration And Parts List

    9. CHARBROILER ILLUSTRATION Figure 10 L25-003 Rev 2 4/4/2002...
  • Page 13 CHARBROILER PARTS LIST Item LPG-60 LPG-30 Description Part No. Part No. Cooking Top Grid, Heavy Duty 3912-0525300 3912-0525300 Cooking Top Grid, Std (shown) 4100-0280400 4100-0280400 Radiant 5403-0500300-C 5403-0500300-C Screw & Nut, ¼-20 x 1-1/2” 4001-0485100/0485200 4001-0485100/0485200 Screw & Nut, ¼-20 x ½”...

  • Page 14: Tank Rack Illustration And Parts List

    TANK RACK ILLUSTRATION TANK RACK PARTS LIST Item LPG-30 Residential Description Part No. Wing Stud & Stop Nut 5299-1154900 Upper Hold Down Bracket 5414-1117600 Tank Rack Body 5414-1117800 Lower Tank Bracket 5414-1117700 Keps Screw & Acorn Nut 4001-0049600/0044100 Table 2...

  • Page 15: Warranty

    WARRANTY: ORIGINAL EQUIPMENT WARRANTY (For U.S. and Canada) MagiKich’n warrants to each original Buyer that its electrically-heated or gas-fired charbroilers / outdoor grills will be free from defects in material and workmanship for the period specified below. MagiKitch’n’s obligation under this warranty shall be limited to replacing or repairing, at its option, any part found to be defective within the specified warranty period.

This manual is also suitable for:

Lpg-60

Table of Contents