Table of Contents
Related Manuals for Magikitch'n 600 CE SERIES
Summary of Contents for Magikitch'n 600 CE SERIES
- Page 1 INSTALLATION – OPERATION - MAINTENANCE 31-01-12962 rev B L25-004 rev 0 5-2001 600 CE SERIES GAS BROILER MAGIKITCH’N P.O. BOX 501 CONCORD NH 03302-0501 509 ROUTE 3A BOW NH 03304 800-258-3708 603-225-6684 FAX 603-225-8497 WWW.MAGIKITCHN.COM...
- Page 2 INSTALLATION, SERVICING, OR CONVERSION OF THIS APPLIANCE TECHNICIANS/INSTALLERS IN CONFORMANCE WITH NATIONAL AND LOCAL REGULATIONS. WARNING: IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE OR MAINTENANCE CAN CAUSE PROPERTY DAMAGE, INJURY OR DEATH. READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING OR SERVICING THIS EQUIPMENT INSTRUCTIONS TO BE FOLLOWED IN THE EVENT THE USER SMELLS GAS MUST BE POSTED IN A PROMINENT LOCATION.
- Page 3 For installation or maintenance, contact your local dealer or authorized service agent. Installation or service by other than MagiKitch’n authorized service agencies or personnel may void warranty coverage. Call Pitco Frialator Technical Support at 603-225-6684 who will put you in touch with the proper local service organization or make service arrangements for you.
- Page 4 Installation Delivery and Location Broiler Assembly Gas Connection and Conversion Operation Broiler Set Up Lighting Instructions General Charbroiling Tips Maintenance Cleaning and Preventative Maintenance Accessory and Replacement Parts List 1-01-12962 rev B L25-004 rev 0 5-2001...
-
Page 5: Delivery And Location
Installation Delivery and Location DELIVERY Each broiler was carefully inspected and packaged before being tendered to the carrier. Upon delivery of your new broiler: • Uncrate the broiler and check for damage. Most carriers will accept claims for damage if they are notified within seven days of delivery and the shipping container is retained for inspection. -
Page 6: Broiler Assembly
1. Screw the legs into the threaded holes in the corners on the bottom of the broiler. 2. Place the broiler onto the legs. 3. Turn the adjustable leg feet to level the oven. Figure 1 1-01-12962 rev B L25-004 rev 0 5-2001... -
Page 7: Gas Connection
GAS CONNECTION An adequate gas supply is required for proper broiler performance. With all burners on “HIGH”, the manifold pressure should not show any appreciable drop. Fluctuations of more than 25% will create pilot problems and affect burner operation. WARNING!! This unit must be connected ONLY to the type of gas specified on the rating plate. -
Page 8: Operation
Operation Gas Connection and Conversion Information for 600-CE Model Broilers Appliance Country Category II2L3B/P II2L3P I2E+ II2E+3+ II2ELL3B/P II2H3P II2H3+ II2H3+ II2H3+ II2H3B/P II2H3B/P II2H3B/P II2H3B/P I3B/P II2H3P II2H3B/P II2E3B/P Runner Tube Orifice (mm) Type 624/648 0.87 0.87 0.52 0.52 Heat Input (kW) 16.5 14.9... - Page 9 Operation Broiler Set Up NOTE: After initial installation, the unit must be thoroughly cleaned prior to operation. Refer to the Maintenance section of this manual for cleaning instructions. Top Cooking Grid The cooking grid has two positions, flat or tilted. •...
-
Page 10: Lighting Instructions
Operation 1. Turn all burners to OFF. 2. Remove the top grid. 3. Remove the last radiant on the right. 4. Turn the shut off valve to ON. 5. Press and hold the reset (blue) button on the safety pilot valve. Wait 15–30 seconds. Light the runner tube. - Page 11 Operation General Charbroiling Tips PREHEATING The broiler must be preheated before cooking. We recommend a preheat time of 10-15 minutes. After preheating, the broiler will be hot enough to cook on without sticking and will produce the proper searing effect. COOK ZONES There are three separate cooking zones on your MagiKitch’n charbroiler:...
- Page 12 Operation MARKING PRODUCT 1. Place the product diagonally on the back 1/3 of a clean broiler grid. NOTE: For white fleshed product (chicken, fish) be sure Marking product to baste the product and brush the grid with pure vegetable oil. 2.
-
Page 13: Cleaning And Preventative Maintenance
Maintenance Cleaning and Preventative Maintenance Proper maintenance of your broiler will prolong the life of the appliance and ensure proper performance. DAILY CLEANING Top Grid 1. Remove the grid. 2. Use the MagiKitch’n scraper to remove any cooking debris from the rods, especially the underside. 3. - Page 14 Maintenance NOTE: This is a partial parts list for parts not shown here, call MagiKitch’n or a MagiKitch’n service representative. Always give the Model and Serial Numbers of your unit when ordering parts and accessories. Item Description Top grid Radiant Burner Burner clip Baffle, right side...
- Page 15 31-01-12962 rev B L25-004 rev 0 5-2001 31-01-12962 rev B L25-004 rev 0 5-2001 Maintenance Maintenance Figure 7...
- Page 16 MODEL SPECIFIC INSTRUCTIONS 31-01-12962 rev B L25-004 rev 0 5-2001 600 SERIES-CE GAS BROILER MAGIKITCH’N P.O. BOX 501 CONCORD NH 03302-0501 509 ROUTE 3A MAGIKITCH’N BOW NH 03304 A MAYTAG COMP 800-258-3708 180 Penn Am Dr ive Quakertown, Pen nsylvania 18951-2435 USA 603-225-6684 Telepho ne 800-441-1492 Fa...
- Page 17 Table of Contents 1. Lighting Instructions 2. Initial Set Up 3. SMB 600 Series Illustration 4. Accessories and Parts List 31-01-12962 rev B L25-004 rev 0 5-2001...
-
Page 19: Lighting Instructions
1. LIGHTING INSTRUCTIONS SMB 600 Series -CE Models with safety pilot 1. Turn all burners to OFF. 2. Remove the top grid. 3. Turn the shut off valve to ON. 4. Press and hold the reset (blue) button on the safety pilot valve. Wait 15–30 seconds. Light the runner tube. DO NOT release the reset button. -
Page 20: Initial Setup
SMB 600 Series -CE Models with safety pilot 2. INITIAL SET-UP SMB 600 Series-CE models COAL SUPPORT - The coal support must be installed so that it is pushed against the back wall of the unit. This creates an air gap over the runner tube to allow proper ventilation. COALS - Use only Magicoals supplied by MagiKitch’n. - Page 21 TYPICAL SMB 600 SERIES ILLUSTRATION Note: Your unit may vary from this typical diagram. 31-01-12962 rev B L25-004 rev 0 5-2001 (Model SMB 636 shown)
- Page 22 ACCESSORY / PARTS LIST FOR SMB 600 SERIES MODELS Not all parts are illustrated, nor are all parts are listed. If you need a part that is not listed here, call MagiKitch’n for a quote. Always have your model and unit serial numbers available when phoning or ordering. THESE PARTS SOLD THRU OUR DEALER NETWORK ONLY.
-
Page 23: Original Equipment Limited Warranty
MagiKitch'n appliances are designed to give you long and satisfactory service if installed and operated in accordance with our instructions. We warrant this appliance against defective workmanship and material for one year form installation or 15 months from ship date, and agree to replace free of charge and defective parts or equipment returned to us.
Need help?
Do you have a question about the 600 CE SERIES and is the answer not in the manual?
Questions and answers