Maintenance Schedule (For Diesel) Engine - Hyundai Grand i10 Owner's Manual

BA RHD 9_PB eng 7.qxd 8/27/2013 5:00 PM Page 17
NORMAL MAINTENANCE SCHEDULE - FOR DIESEL ENGINE
The following maintenance services must be performed to ensure good emission control and performance. Keep receipts for all
vehicle emission services to protect your warranty. Where both kilometres and time are shown, the frequency of service is deter-
mined by whichever occurs first.
* 1 : Check the engine oil level and leak every 500 km (350
miles) or before starting a long trip.
* 2 : Driving in ambient temperature over 40 °C (104 °F) or driv-
ing at constant highway speeds must conform the severe
driving condition.
* : The engine oil level should be checked regularly and main-
3
tained properly. Operating with an insufficient amount of oil
can damage the engine, and such damage is not covered
by warranty.
* : Inspect for excessive valve noise and/or engine vibration
4
and adjust if necessary. We recommend that an authorized
HYUNDAI dealer should perform the operation.
* 5 : When adding coolant, use only deionised water or soft
water for your vehicle and never mix hard water in the
coolant filled at the factory. An improper coolant mixture can
result in serious malfunction or engine damage.
* 6 : Manual transaxle fluid should be changed anytime the vehi-
cle has been submerged in water.
* 7 : If good quality petrols that meet Europe Fuel standards
(EN228) or equivalents including fuel additives is not avail-
able, one bottle of additive is recommended. Additives are
available from your authorised HYUNDAI dealer along with
information on how to use them. Do not mix other additives
* 8 : Maintenance schedule depends on fuel quality. If there are
some important matters like fuel flow restriction, surging,
loss of power, difficulty in starting problems etc, we
recommend replacing the fuel filter immediately regardless
of the maintenance schedule and consulting with an autho-
rised HYUNDAI dealer for details.
* 9 : Inspect drive belt tensioner, idler & alternator pulley, Starter
and all chassis electrical items. Correct or replace, if nec-
essary.
Maintenance
9 17