Table of Contents
Advertisement
4. Use care if shifting to a lower gear while travel ing
downhill. This could activate the trailer's surge
brakes for the duration of the downhill run and
cause overheating. Extend ed over heating could
result in complete loss of the trailer brakes.
To help prevent overheating, slow down while ap-
proaching the crest of a hill and maintain a slow,
controlled downhill speed. Apply brakes in short
intervals to allow time between brak ing for the
brakes to cool off.
In mountain regions, extra care is required due
to extreme braking conditions. If not equipped
with a "rugged duty towing package" use turn-
outs often to allow brakes to cool otherwise
loss of trailer brakes could result. Consult with
your Four Winns dealer regarding a "rugged
duty towing package" for your towing require-
ments.
5. When rounding turns on highways or streets, DO
NOT cut corners. Also, travel slowly over railroad
tracks.
6. If the trailer begins to "fishtail" when acceler a t i ng,
reduce speed until it ceases. If the trailer "fishtails"
again during acceleration, stop to investigate the
cause of the problem. Check for improper trailer
load and uneven weight distribution inside the
boat. Check the winch line and tie-downs. Also
check the tires for proper inflation or damage. If
neces sary, redistribute the load before continu ing.
For additional information on trailering, refer to the
"Boating Basics" manual included in the owner's
packet.
S - 5
MAINTENANCE
A. Care of Exterior Finish
When using the trailer, keep in mind the paint can
scratch and become marred during normal use. In
most cases, touch-up paint can be ordered. Please
contact a Four Winns dealer for assistance.
Some maintenance is required to maintain the finish
and minimize rusting. The trailer should be washed
and rinsed with clean water immediately after each
use. Depending upon use, waxing is recom mended
Trailer Information - Section S
twice a year. Use paste wax designed for enamel
paint.
On galvanized trailers with GatorHyde™, rinse all
exposed metal parts thoroughly with only clean water
after use. The Gatorhyde™ protective coating may
be cleaned with mild dishwashing soap in a bucket
of water along with a nylon boat brush. Rinse thor-
oughly with clean water.
To rejuvenate as well as UV protect worn and faded
GatorHyde™ you may purchase a product called
GatorGloss™. To place an order you can phone
Elastomer Specialties, Inc. at 918-485-2835 or Fax
918-485-2856.
B. Bunks
The bunks should be replaced if they are cracked,
warped, or evidence of dry-rot is found. The replace-
ment boards should be treated lumber of the same
length and width. Re-carpet bunks with high quality
exterior grade carpet.
DO NOT burn damaged or broken bunks
Toxic fumes will be released. Dispose of
bunks properly.
C. Swivel Jack
Keep the swivel jack clean of dirt, tar, and mud.
Lubricate every six months. The swivel jack's inner
ram should be lubricated with SAE 30 weight oil. The
top cover may be re moved to lubricate the gears with
wheel bearing grease.
Replace all worn and damaged parts. ALWAYS use
the manufacturer's replacement parts. Re placement
parts may be ordered through your Four Winns
dealer.
For more information on mainte nance, refer to the
manufact urer's litera ture included in the owner's
packet.
D. Brake Actuator & Coupling Assembly
When storing or parking your trailer, keep the brake
actuator and coupling assembly (coupler) off the
ground to prevent dirt buildup in the ball socket. Keep
the coupler clean of dirt, tar, and mud. Lubricate the
coupler with SAE 30 weight oil every six months or as
Owner's Manual Page 143
Advertisement
Table of Contents
