Craftsman 113.29501 Assembly, Operating Instructions And Parts List
Craftsman 113.29501 Assembly, Operating Instructions And Parts List

Craftsman 113.29501 Assembly, Operating Instructions And Parts List

12 inch radial saw

Advertisement

ASSEMBLY, OPERATING INSTRUCTIONS
AND PARTS LIST FOR
CRAFTSMAN
MODEL NUMBER 1
The Model Number will b e found on a plate attached t o your saw,
a t the left side of the base. Always mention the Model Number i n
a l l correspondence regarding the CRAFTSMAN RADIAL SAW or when
ordering repair parts.
C a r e f u l l y r e a d t h e instructions provided, observe t h e simple
s a f e t y precautions
use from your
n e w Craftsman
H O W TO ORDER REPAIR P A R T S - - - ,
All
Parts Listed herein may be ordered through SEARS, ROEBUCK A N D
CO.
or SIMPSONS-SEARS LIMITED. When ordering parts
the
catalog order house which serves the territory in which you live,
selling prices will be furnished on request or parts will be shipped a t
prevailing prices and you will be billed accordingly.
W H E N ORDERING
REPAIR PARTS, ALWAYS
INFORMATION AS S H O W N
The PART NUMBER
2.
The PART NAME
COAST T O COAST NATION-WIDE
F O R
YOUR CRAFTSMAN RADIAL S A W
I
SEARS,
INCH RADIAL SAW
13.29501
and
you
w i l l h a v e m a n y hours
tool.
IN
MODEL
3.
The
4.
NAME
The
SERVICE FROM SEARS
SEARS, ROEBUCK
SIMPSONS-SEARS LIMITED i n Canada
back u p your investment with quick,
expert mechanical service and genu-
ine CRAFTSMAN replacement parts.
If
a n d when you need repairs or serv-
ice, call on us t o protect your invest-
ment in this fine piece
AND C 0 . -
of
satisfactory
by
mail from
THE FOLLOWlNG
1 13.29501
NUMBER
-
of item
RADIAL SAW
and
A N D CO.
of
equipment.
, , , : .
...
.
...
.
...
.
I
I
J
U. S . A .
No.
63161
Part

Advertisement

Table of Contents
loading

Summary of Contents for Craftsman 113.29501

  • Page 1 The Model Number will b e found on a plate attached t o your saw, a t the left side of the base. Always mention the Model Number i n a l l correspondence regarding the CRAFTSMAN RADIAL SAW or when ordering repair parts.
  • Page 2 3 M I N U T E S of required reading for the home Crafts- safety in mind, permitting you to use the tool without man.. whether this i s your first purchase or you're c o n c e r n so long as certain basic rules are observed. an old hand at power tools.
  • Page 3 . . . ASSEMBLING AND ADJUSTING YOUR SAW POWER SMPPLY & MOTOR CONNECTIONS lead. (The black motor cord l e a d is al!Zidy-con MOTOR GREEN BROWN Connect the leads t o the BLUE The AC motor used in this saw i s a capacitor start, non- lead.
  • Page 4 NOTE: The seven basic "steps" that follow button will not snap into place immediately, the motor still too hot and must be allowed to cool for a while are essential in order to insure correct align- longer. (An audible click will indicate protector closed.) .
  • Page 5 set screw, the column key will be retracted out of the column tube keyway. The set screw in outer end of column tube key must b e loosened while adjustment i s being made and tightened with medium firm~icss after adjustment completed.
  • Page 6 ("A") (22, f. Recheck travel of blade tooth Turn the arm latch handle fi g ure 20) one-quarter turn countcrclockwisc b u t d o not. pull it out. g. After the cross-cut has been squared, Loosen (do not remove) two hex-head screws fig- install the radial arm cap figure...
  • Page 7 W h e n the saw blade is square with the table top, no light will b e visible between the square a n d face o f saw blode. Do not a:low the square t o rest against o tooth o f the saw.
  • Page 8 A T TA C HI N G A N D DETA C H I N G ..BLADE S A W Locate the motor carriage assembly midway arm ond tighten carriage lock knob figure 20). 2.
  • Page 9 Arm Latch Lever 12. Allen Wrenches 2. Swivel Latch Pin Knoh Rip Scale lndicator 14. Elevation Crank 15. Eevel lndex Indicator Radial A r m Scal e lndex Scale Carriage Lock Knob 18. Anti-Kickback Pawl Assemhl y Yoke Cl a mp Handle Switch Lock and Key 19.
  • Page 10 USE OF AND SWITCH Press the right-hand side of toggle switch lever to turn the saw Press left-hand side of switch to turn NOTE: This savt cannot be operated without O F F . the key, and likewise, the key cannot be re- moved trom the lock while the sow motor is LOWERING RADIAL A R M...
  • Page 11 PRECISION INDEXING Proceed .as follows: Craftsman Sow, normally acquire the habit of indexing Release the power cord from cord clamp a t rear of the machine in one direction only whenever a new setting radial arm. is made in preparation for a different operotion. For exam-...
  • Page 12 Using a screwdriver or similar tool, rotate the yoke Make sure the hole in yoke clamp figure clockwise (when looking 24) lines up with lock screw hole and install and tighten down) until the next hole will line up with the lock screw lock screw figure (See figure...
  • Page 13 A light film of oil can be wiped on the face of the column tube and keyway to lubricate the fit between this part and the key and column support. HOLE elevation crank shaft assembly. An oiling hole i s provided in the elevation shaft bearing bracket to facilitate the lubrication of the bearing support.
  • Page 14 Screw or nail the cross members on the in figure 34. Make sure the support is square. the top cross piece toward the opposite side as sIj0b.n in figure I f only o single support i s re q uired, .
  • Page 15 Figure to cutting, the saw guard a n d anti-kickback p a w l assembly Holes are located in the saw base that permit legs to be must be properl adjusted. Loosen the guard clamp screw desired. This i s accom- extended outward horizontally plished by removing three attaching screws in each leg, holding the guard to the motor a n d lower the nose o f the...
  • Page 16 IN-RIPPING refers to a - , - between the motor and the fence and arallel to ~ h e fence. (See figure To place the saw in this position, unlock the yoke, d i s e ~ ~ g a g c the swivel latch pin and rotate the clockwise (viewing it from t ! ~ e carl.iage) until the pointer on the "In-Ri "...
  • Page 17 This work is done with the Craftsman Moldin g Cutter Head and a set of cutters, depending upon the type of molding...
  • Page 18: Helpful Hints

    Figure B O R I N G shoe i s instantly pulled away from the brake lining motor does not start under load. When the motor is turned The saw may be converted to a horizontal drill f o r boring off, braking action takes place automatically.
  • Page 19 BENCH POWER TOOL GUARANTEE Keep cutting tools sucl) as saw blades, drills, rnold~rlg cutters, dodos, etc., sharp d o not force fecd work t o tile point where the motor speed is drasticnlly cared for a n d maintained, we will re lace or repair ot our more accurate cuts, resist overl~eating a n d pos:ib!c.
  • Page 20 PARTS CRAFTSMAN, 12- INCH RADIAL SAW, MODEL N . 1 13.29501 store or Catalog order store. Order parts by mail from Cotalog order house which serves the territory in which you In several instances, part numbers are listed for COMPLETE ASSEMBLIES. All parts are shipped prepaid within the live.
  • Page 21 CRAFTSMAN, 1 2- INCH RADIAL SAW, MODEL N . 1 13.29501 f ICUBE FOP E > PtODfD F O R EXPLODED Figure 51...
  • Page 22 12-INCH . 1 13.29501 CRAFTSMAN, RADIAL SAW, MODEL F I G U R E 5 2 P A R T S L I S T Part P a r t Description Description Assembly, Yoke 63126 Arm, Radial 30566 30567 Bumper...
  • Page 23 CRAFTSMAN, 12-INCH RADIAL S A W , MODEL N . 1 13.29501 EXPLODED VIEW Figure...
  • Page 24 CRAFTSMAN, 12-INCH RADIAL SAW, MODEL N . 1 13.29501 P A R T S F I G U R E 5 3 Part Part Description Description . . . 63146 Tube Assembly, Column 63116 Shaft Assembly, Elevating Crank 139416 *Screw, Set, 3/8-16 30509 Washer, End Play, No.
  • Page 25 CRAFTSMAN, 1 2-INCH RADIAL SAW, MODEL N . 1 13.29501...
  • Page 26 CRAFTSMAN, 12-INCH RADIAL SAW, MODEL N . 1 13.29501 F I G U R E 5 4 P A R T S L I S T Part Description Description 448001 Screw, No. Type Screw, No. Type 6-32 1 /4, 9404353...
  • Page 27 SAW, MODEL N . 1 13.29501 CRAFTSMAN, 12-INCH RADIAL Figure 55 F I G U R E 5 5 P A R T S L I S T Port P o r t N o . Description Description 63144 Guard Assembly 30505 *Wrench, Hex.
  • Page 28 MODEL N CRAFTSMAN, 1 2 - I N C H RADIAL SAW, . 1 13.29501 ..Figure 56 F I G U R E 5 6 P A R T S L I S T Part Part...
  • Page 29 GENERAL TROUBLE PROBAELE CAUSE REMEDY Blade "heels" t o r i g h t 1. Heel has not been taken 1. Refer to "STEP SIX -CHECKING THE SAW BLADE FOR out of blade. HEEL (Left and Right).'' Cannot "rip" properly, Dull blade.
  • Page 30 ..TROUBLE SHOOBUNG CHART N O T E : Motors usc!d on wood-working tools are particularly susceptible to thc accuniulation o f sawdust a n d wood chips . . . a n d should blown out or "vacuumed" frequently to .

Table of Contents