The issue with the Kenwood TS-2000 tuner remaining in CW mode after tuning could be related to the new Auto Tune function or CW features like full/semi break-in switching and delay time settings. If not configured correctly, these settings may cause the transceiver to stay in CW mode after tuning. Adjusting the delay time or break-in settings may resolve the problem.

This answer is automatically generated

Summary of Contents for Kenwood TS-2000

Page 1: Table Of Contents
ALL MODE MULTI-BAND TRANSCEIVER TS-2000/X SERVICE MANUAL © 2000-12 PRINTED IN JAPAN B51-8558-00 ( N ) 889 Phone jack (9P) Cabinet (Upper) Front glass Key top (E11-0438-05) (A01-2176-01) (B10-2608-02) (K29-5394-12) Key top Knob ring Knob Knob (K29-5391-02) (K29-5395-04) (K29-5399-03) x 3...
Page 2: Circuit Description
Overview of the operation of the independent Overview of the Operation FM/AM sub-receiver unit (sub-band side) for the The TS-2000/X basically consists of an all-mode-receiver VHF and UHF bands incorporating an IF/AF DSP for satellite communication with The local oscillator system and IF/AF signal system of the an independent FM/AM sub-receiver for the VHF and UHF sub-receiver unit are independent of the main band side.
Page 3 TS-2000/X CIRCUIT DESCRIPTION 50MHz 68.985MHz TX MIX TX MIX 10.595MHz TX MIX 75.825MHz input TCAR 10.583MHz 69.085MHz RX MIX RX MIX 10.695MHz RX MIX 455kHz 75.925MHz output LO1HF RCAR 75.955~ 58.390~ 11.150MHz 467kHz 129.085MHz 65.230MHz TX MIX 41.795MHz TX MIX LO1TX 183.795~418.205MHz (K)
Page 4 TS-2000/X CIRCUIT DESCRIPTION HF LO2 comparator, and locked. The division ratio data comes from When the HF and or 50MHz band is operating, the the control unit. HF LO2 VCO (Q409) generates 65.230 to 58.390MHz. (See The output signal from the VCO (Q409) passes through a Table 1, frequency configuration.)
Page 5 TS-2000/X CIRCUIT DESCRIPTION 144MHz LO1 9.321MHz (K), 9.112 to 9.210MHz (E)) in 10Hz steps by When the VHF band is operating in the main band, the equation f (Hz) = (10*R1)/(N1*4) and in 1Hz steps VHF REF VCO (Q441) generates 36.057 to 37.288MHz (K),...
Page 6 TS-2000/X CIRCUIT DESCRIPTION Display frequency LO1 OUT IC412ÅF DDS output (MHz) (MHz) (MHz) LMX2306TMX IC407 : AD9835BRU Start Stop 420.000000 (K) 425.999999 (K) 425.000000 (K) 431.499999 (K) – IF – IF 430.000000 (E) 431.500000 (K,E) 435.499999 (K,E) 435.500000 (K,E) 439.499999 (K,E) 439.500000 (K,E)
Page 7 TS-2000/X CIRCUIT DESCRIPTION 1.2GHz Unit Local Oscillator The two signals are compared in the phase comparator The 12LO31 signal (31.2MHz) is quadrupled to 124.8MHz within the IC and the VCO (Q301) oscillation frequency is in Q14 and 15. This signal is sent to the mixers of the trans- locked.
Page 8 TS-2000/X CIRCUIT DESCRIPTION DDS IC408 : AD9835BRU HF TX/RX LO1 CW-R Filter offset –1.5k –1.5k +1.5k +1.5k +0.7k +0.7k –0.7k –0.7k +(D RIT) – +(D RIT) – +(D RIT) – +(D RIT) – – +(D XIT) – +(D XIT) –...
Page 9 TS-2000/X CIRCUIT DESCRIPTION DDS IC4 : AD9851BRS 1.2GHz TX/RX LO1 CW-R Filter offset –1.5k –1.5k +1.5k +1.5k +0.7k +0.7k –0.7k –0.7k +(D RIT) – +(D RIT) – +(D RIT) – +(D RIT) – – +(D XIT) – +(D XIT) –...
Page 10 TS-2000/X CIRCUIT DESCRIPTION RCAR DDS IC601 : AD9835BRU CW-R FSK-R BASE 467 (kHz) Filter offset +1.5k –1.5k –0.7k +0.7k +(1.5k–Fcenter) –(1.5k–Fcenter) CW pitch – – –(PITCH) +(PITCH) – – – – FSK tone H – – – – +2.125k –2.125k–FSK SHIFT –...
Page 11 TS-2000/X CIRCUIT DESCRIPTION excellent large input characteristics. The actual circuit con- HF Receiver System and Main IF System tains two amplifiers using this FET. Large input characteris- Three antenna terminals used for the HF and 50MHz tics with a low gain are given priority on the low band (Q12) band reception are ANT1, ANT2 and HF RX ANT.
Page 12 TS-2000/X CIRCUIT DESCRIPTION The signal is then amplified by the first IF amplifier (Q18) ventional analog devices is implemented. The band in this and is converted to the second IF frequency of 10.695MHz analog stage does not affect the operation of the digital IF in the second receive mixers (Q19, 20).
Page 13 TS-2000/X CIRCUIT DESCRIPTION Speaker output changeover When external speakers 1 and 2 and headphones are When SP1 only has been connected, the built-in speaker connected, you can change over the sub/main band outputs. will change over to SP1. The headphone connection is preferred over the all the...
Page 14 TS-2000/X CIRCUIT DESCRIPTION The 118~174MHz signal distributed to the sub-receiver The 438~450MHz signal distributed to the sub-receiver unit passes through a variable tuning filter and is amplified section passes through the SAW filter (L29), is amplified by by the second amplifier (Q24). Then, it passes through the...
Page 15 TS-2000/X CIRCUIT DESCRIPTION Main receiver IF section • K destination The signal input to IC4 is mixed with the signal produced In FM mode, the signal passes through a ceramic filter by amplifying the first local oscillator RXLO1 from the PLL...
Page 16 TS-2000/X CIRCUIT DESCRIPTION Ref No. Parts No. L71-0566-05 L71-0565-05 L71-0582-05 L72-0984-05 L72-0986-05 Nominal center frequency 41.895MHz 58.525MHz 41.795MHz 455kHz 455kHz 3dB : ± 7.5kHz 3dB : ± 7.5kHz 3dB : ± 15kHz 6dB : ± 7.5kHz or more 6dB : ± 4.5kHz or more Pass bandwidth 50dB : ±...
Page 17 TS-2000/X CIRCUIT DESCRIPTION Transmit System IF Section The output signal from the IF amplifier (Q711) passes through D84, Q40, D82, D48, D80 and D81 and becomes Transmission IF the IF transmit signal for each band. D84 is a voltage con- The details of the processing by the DSP depend on the trolled attenuator circuit.
Page 18 TS-2000/X CIRCUIT DESCRIPTION The third IF signal is input to the third transmit mixer (Q44, 45). The progressive and reflected wave signals detected by A GaAs FET is used to obtain the satisfactory inter- the final section in each band enters the TX-RX1 unit (X57- modulation characteristics.
Page 19 TS-2000/X CIRCUIT DESCRIPTION R439, ALC meter Q711 10.595MHz IC14 L119 IC13 (AOUT) IC17 (Q6), D113 R509 REMOTE HF ALC (6 pin) D109 50ALC 14ALC D123 D124 43ALC X45-360 X45-360 (A/2) (A/2) 12ALC D119 D120 X45-360 X45-360 (B/2) (B/2) 43VSF 43VSR...
Page 20 TS-2000/X CIRCUIT DESCRIPTION Q101 and 102: 144MHz final amplifier Transmitter Final Amplifier A 144MHz band signal passes through the HPF and en- The final unit (X45-360 A/2) is composed of an HF and ters the branch circuit with two amplifiers.
Page 21 TS-2000/X CIRCUIT DESCRIPTION Progressive wave and reflected wave output circuits 430ANT X57-606 (43RX) The signal is detected by L7, D3 and D4. A voltage out- X57-606 put corresponding to the progressive wave and reflected Q905 Q903 Q902 Q901 wave is produced by synthesizing the magnetically com-...
Page 22 The TNC is the same as the one used in the TH-D7. The Outline TNC uses a lithium battery to back up various settings. The TS-2000/X control circuit has a multi-chip configura- When a 9600bps communication speed is used, the TNC tion centered around a main microcomputer (IC8), and con- analog signal is connected directly to the transmitter/re- tains a latch circuit for input/ output, a TNC and a DSP.
Page 23 AF signal system. These IC outputs directly enter the AF Outline amplifier, are amplified and then output from the speaker. The TS-2000/X DSP circuit is composed of two DSPs The IC input consists of the MIC input and the optional (IC515 and IC516) and CODEC ICs (IC518, IC522 and speech synthesis unit (VS-3).
Page 24: Description Of Components
TS-2000/X DESCRIPTION OF COMPONENTS FINAL UNIT (HF) (X45-360X-XX) (A/2) Ref. No. Use / Function Operation / Condition Ref. No. Use / Function Operation / Condition D206~209 Surge absorption IC205 output line protection Q1,2 Predrive amplifier HF/VHF band amplifier D210 Reverse current...
Page 25 TS-2000/X DESCRIPTION OF COMPONENTS Ref. No. Use / Function Operation / Condition Ref. No. Use / Function Operation / Condition D401,451 Surge absorption Relay (K401/K402, K451/K452) IC30 Comparator Waveform shaping of modem TX signal D501,551 Surge absorption Relay (K501/K502, K551/K552)
Page 26 TS-2000/X DESCRIPTION OF COMPONENTS DISPLAY UNIT (X54-3320-00) Ref. No. Use / Function Operation / Condition Ref. No. Use / Function Operation / Condition Amplifier HF/50MHz TX drive amplifier Q1~3 LCD backlight Q44,45 TX 3rd mixer Converts 68.985/75.825MHz to TX LCD driver...
Page 27 TS-2000/X DESCRIPTION OF COMPONENTS Ref. No. Use / Function Operation / Condition Ref. No. Use / Function Operation / Condition Q94,95 Buffer amplifier Buffer amplifier for ANO output of OP amplifier A/2 : Unused main and sub band B/2 : AGC reference voltage buffer...
Page 28 TS-2000/X DESCRIPTION OF COMPONENTS Ref. No. Use / Function Operation / Condition Ref. No. Use / Function Operation / Condition IC17 Extended I/O Q0 : H when UHF ATT is on D20,21 Switching On when RF BPF of 7.5~10.5MHz Q1 : H when VHF ATT is on...
Page 29 TS-2000/X DESCRIPTION OF COMPONENTS Ref. No. Use / Function Operation / Condition Ref. No. Use / Function Operation / Condition Switching 10.695MHz IF filter changeover, D108 Zener diode Voltage shift on when through is selected D109,110 Reverse current External ALC matching...
Page 30 TS-2000/X DESCRIPTION OF COMPONENTS Ref. No. Use / Function Operation / Condition Ref. No. Use / Function Operation / Condition D717 Surge protection Switching Sub RX AM power supply D719,720 Zener diode External surge voltage protection Switching VHF sub RX IC6 power supply...
Page 31 TS-2000/X DESCRIPTION OF COMPONENTS Ref. No. Use / Function Operation / Condition Ref. No. Use / Function Operation / Condition Q415 Buffer amplifier For HF LO2 (58.390~65.230MHz) Q461 Amplifier For PLL input Q416 Buffer amplifier PLL input buffer (378.105~418.205MHz (K) (322.950~465.050MHz (K)
Page 32 TS-2000/X DESCRIPTION OF COMPONENTS Ref. No. Use / Function Operation / Condition Ref. No. Use / Function Operation / Condition Switching On when UHF RX preamplifier is on Reverse current Produce VURXB by VRXB and Switching On when VHF RX preamplifier is on...
Page 33 TS-2000/X DESCRIPTION OF COMPONENTS Ref. No. Use / Function Operation / Condition Ref. No. Use / Function Operation / Condition D423 Reverse current Unlock signal detection (UHF VCO) High-frequency Amplifies 1104~1165MHz local prevention amplifier oscillation signal D426 Switching On in main VHF RX mode...
Page 34: Semiconductor Data
TS-2000/X SEMICONDUCTOR DATA Main CPU : 64F2633xxxx (Control unit IC8) Pin function Name Function Name Function Operation mode setting pin 1. DRES DSP reset output. Connect to Vcc. Main/sub common unlock signal. Operation mode setting pin 2. 12ULK 1.2GHz band unlock signal.
Page 35 TS-2000/X SEMICONDUCTOR DATA Name Function Name Function 3.3V. SW (MPU/MDN/ALC/Reserve). EXTAL Crystal oscillator 11.0592MHz. SW (THHF/THU/TH12/TEST). – GND. PCHECK Panel CPU connection check input signal. 87,88 DTDT DTMF decoder data input. PVcc 3.3V. VS-3 serial data input permission judgment. Phase comparison detection instruction DRU-3 message end judgment.
Page 36 TS-2000/X SEMICONDUCTOR DATA Panel CPU : 30624FGAGxxxxx (TX-RX 1 unit IC801) Pin function Name Function Name Function Key illumination LED control signal. Sub TX LED control signal. – – Pull up to Vcc. Main RX LED control signal. LSUB Sub LED control signal.
Page 37 TS-2000/X SEMICONDUCTOR DATA Extended I/O Port Final unit (X45-360) Pin No. Port name Pin name Function Active level Condition IC205 : BU2099FV, Enable : FEN1 FAN1 Low & High speed FAN1 FAN2 High speed FAN2 ANT2 HF ANT2 switching relay...
Page 38 TS-2000/X SEMICONDUCTOR DATA Control unit (X53-391) Pin No. Port name Pin name Function Pin No. Port name Pin name Function AF mute signal IC25 : TC74VHC573FT 12EN3 1.2G enable 3 PENA PLL serial-parallel enable A For TNC PEN1 PLL enable 1...
Page 39 TS-2000/X SEMICONDUCTOR DATA TX-RX 1 unit (X57-605) Pin No. Port name Pin name Function Active level Condition IC5 : BU2099FV, Enable : IEN1 49.0MHz ≤ f < 54.0MHz BPF12 BPF selection 30MHz ≤ f < 49MHz, 54MHz ≤ f ≤ 60MHz...
Page 40 TS-2000/X SEMICONDUCTOR DATA TX-RX 2 unit (X57-606) Pin No. Port name Pin name Function Active level Condition IC2 : BU2099FV AMSW AM power switch When the sub AM is selected for receiving W/NSW Wide/Narrow selection switch When the sub FM narrow is selected for receiving...
Page 41 TS-2000/X SEMICONDUCTOR DATA Serial-Parallel : BU2099FV D flip-flop : TC7WH74FU (Filter unit IC2) Logic diagram (Final unit IC205, Control unit IC530, Display unit IC4, TX-RX 1 unit IC5,16,17, TX-RX 2 unit IC2) Block diagram 20 VDD Truth table Input Output...
Page 42 TS-2000/X SEMICONDUCTOR DATA Flash ROM for DSP : 29LV800B (Control unit IC504,508) Block diagram DQ0~DQ15 RY/BY RY/BY buffer Erase circuit Input/output buffer Control circuit BYTE (Command RESET register) Write circuit Chip enable Data latch output enable circuit Y decoder Y gate...
Page 43 TS-2000/X SEMICONDUCTOR DATA DSP : 320VC5402PGE (Control unit IC515,516) Pin description Pin name Type* Description Data signal A19~A0 Parallel address bus A19 (MSB) to A0 (LSB). The low-order 16 bits (A0 to A15) of the address pin are multiplexed to address to external memory (data, program) or I/O.
Page 44 TS-2000/X SEMICONDUCTOR DATA Pin name Type* Description IOSTRB I/O strobe signal. It is always at high level (read mode) except when accessing an I/O device through an external bus. In hold mode, it becomes high impedance when the OFF signal is at low level.
Page 45 TS-2000/X SEMICONDUCTOR DATA Pin name Type* Description Host port interface (HPI) signal HD0~ I/O/Z Parallel bi-directional data bus. The HPI data bus is used by the host device bus to exchange data with the HPI register. It becomes high impedance when data is not output or OFF is low. The HPI data bus has a bus holder to reduce power consumption of unused pins.
Page 46 TS-2000/X SEMICONDUCTOR DATA CODEC (24 bit) : AK4524 (Control unit IC518) Block diagram AINL DGND DATT AINR LRCK BICK Audio I/F SDTO Controller VCOM SDTI AOUTL+ AOUTL– DATT VREF SMUTE AOUTR+ AOUTR– AGND Control Register I/F Clock Gen. & Divider...
Page 47 TS-2000/X SEMICONDUCTOR DATA CODEC (16 bit) : AK4518 Name Function DEM1 De-emphasis frequency select pin. (Control unit IC522,523) DEM0 De-emphasis frequency select pin. Block diagram AOUTL Lch analog output pin. AOUTR Rch analog output pin. AINL ∆∑ MCLK Decimation Clock VCOM Common voltage output pin, 0.45 x VA.
Page 48 TS-2000/X SEMICONDUCTOR DATA DDS : AD9835 (TX-RX 1 unit IC601~603, DAC : M62363FP (TX-RX 1 unit IC14) TX-RX 2 unit IC406~408) Block diagram Block diagram 12-bit shift register DVDD DGND AVDD AGND REFOUT FS ADJUST REFIN SELSRC MCLK FSELECT ON-Board...
Page 49 TS-2000/X SEMICONDUCTOR DATA PLL : LMX2306TMX (TX-RX 2 unit IC401,409~412,414) PLL : LMX2316TMX (TX-RX 2 unit IC402, TX-RX 3 unit IC5) Block diagram 14-bit R counter Charge Phase Comp. Pump CLOCK 18-bit 21-bit Function Lock Fast Data Register DATA Latch...
Page 50 TS-2000/X SEMICONDUCTOR DATA DDS : AD9851BRS (TX-RX 3 unit IC4) Name Function 10,19 AGND Analog ground. The ground return for the Block diagram analog circuitry (DAC and comparator). 11,18 AVDD Positive supply voltage for analog circuitry DAC R (DAC and comparator, pin 18) and bandgap...
Page 51: Parts List
LEAD WIRE WITH MINIPIN PLUG (X51 CN21, 14RX) G11-4041-04 SHEET G11-4042-04 SHEET E37-0883-05 LEAD WIRE WITH MINIPIN PLUG (X57-606A CN2,3) G11-4045-04 SHEET E37-0886-05 LEAD WIRE WITH CONNECTOR (X53 CN505) G13-1775-13 CUSHION K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 52 39PF W09-0873-05 LITHIUM CELL (X57-605 A) C102 C93-0560-05 CHIP C 10PF 212-2017-05 HEAT-PROOF TUBE C104 C93-0572-05 CHIP C 100PF C106 C93-0572-05 CHIP C 100PF K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 53 CM73F2H330J CHIP C 33PF C250 CE04EW1E471M ELECTRO 470UF 25WV C938 CK73FB1H103K CHIP C 0.010UF C251 CK73FB1E104K CHIP C 0.10UF C940 CK73FB1H471K CHIP C 470PF K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 54 L39-0421-04 COIL CN901 E04-0190-05 PIN SOCKET L801 L40-1001-12 SMALL FIXED INDUCTOR CN902 E40-5765-05 FLAT CABLE CONNECTOR CN903,904 E23-1116-05 RELAY TERMINAL L802,803 L39-1441-05 TOROIDAL COIL K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 55 1/10W R928 R92-0679-05 CHIP R 0 OHM R20,21 RK73FB2A470J CHIP R 1/10W R12-6730-05 TRIMMING POT. (220) R92-1213-05 CHIP R 1/2W R12-6737-05 TRIMMING POT. (3.3K) K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 56 CHIP C 82PF E,E2 Q206 DTC114EKA DIGITAL TRANSISTOR C353 C93-0568-05 CHIP C 47PF E,E2 Q207 DTC143TKA DIGITAL TRANSISTOR C355 CM73F2H471J CHIP C 470PF E,E2 K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 57 SMALL FIXED INDUCTOR (1UH) K201,202 S76-0423-05 RELAY K251,252 S76-0423-05 RELAY L34-1088-05 AIR-CORE COIL L40-1021-12 SMALL FIXED INDUCTOR K301,302 S76-0423-05 RELAY L39-0480-15 TOROIDAL COIL K351,352 S76-0423-05 RELAY E,E2 K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 58 CK73GB1H103K CHIP C 0.010UF C140-143 CK73GB1H102K CHIP C 1000PF C543,544 CK73GB1C104K CHIP C 0.10UF C145 CK73GB1C104K CHIP C 0.10UF C545,546 CK73GB1H103K CHIP C 0.010UF K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 59 CK73GB1H103K CHIP C 0.010UF X501,502 L77-1680-05 CRYSTAL RESONATOR (11.0592MHZ) C631 C92-0566-05 CHIP-TAN 10UF 6.3WV X503 L77-1679-05 CRYSTAL RESONATOR (12.288MHZ) C632 CK73GB1C104K CHIP C 0.10UF K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 60 R159 RK73GB1J272J CHIP R 2.7K 1/16W R582,583 RK73GB1J472J CHIP R 4.7K 1/16W R160 RK73GB1J102J CHIP R 1.0K 1/16W R584 RK73GB1J474J CHIP R 470K 1/16W K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 61 TC74VHC573FT R702 RK73GB1J103J CHIP R 1/16W IC515,516 320VC5402PGE R703-706 RK73GB1J472J CHIP R 4.7K 1/16W IC517 NJM2904V R707-710 RK73GB1J104J CHIP R 100K 1/16W IC518 AK4524 K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 62 CHIP C 0.10UF RK73FB2A684J CHIP R 680K 1/10W CK73GB1H152K CHIP C 1500PF RK73FB2A100J CHIP R 1/10W CK73GB1H472K CHIP C 4700PF R6-21 RK73GB1J101J CHIP R 1/16W K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 63 47PF C182,183 CK73GB1H103K CHIP C 0.010UF CK73GB1H102K CHIP C 1000PF C184 CC73GCH1H120J CHIP C 12PF CK73FB1E104K CHIP C 0.10UF C185,186 CK73GB1H103K CHIP C 0.010UF K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 64 CE04EW1C471M ELECTRO 470UF 16WV C292 CC73GCH1H390J CHIP C 39PF C402 CK73FB1E104K CHIP C 0.10UF C293,294 CK73GB1H103K CHIP C 0.010UF C403 CE04EW1C470M ELECTRO 47UF 16WV K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 65 CC73GUJ1H040C CHIP C 4.0PF C506 CE04EW1C220M ELECTRO 22UF 16WV C709,710 CK73GB1H103K CHIP C 0.010UF C507,508 CK73GB1H102K CHIP C 1000PF C711 CK73GB1H102K CHIP C 1000PF K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 66 CK73GB1H102K CHIP C 1000PF C851 CK73GB1H103K CHIP C 0.010UF F10-2003-14 SHIELDING CASE C852-855 CK73GB1H102K CHIP C 1000PF F53-0115-05 FUSE C858-860 CK73GB1H102K CHIP C 1000PF K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 67 SMALL FIXED INDUCTOR (2.2U) L34-4393-05 COIL L703 L33-1394-05 SMALL FIXED INDUCTOR L704 L40-1085-34 SMALL FIXED INDUCTOR (100NH) L64,65 L34-4394-05 COIL L705 L33-0695-05 SMALL FIXED INDUCTOR K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 68 0 OHM RK73GB1J102J CHIP R 1.0K 1/16W R127 RK73GB1J122J CHIP R 1.2K 1/16W R50,51 RK73GB1J681J CHIP R 1/16W R128 RK73GB1J152J CHIP R 1.5K 1/16W K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 69 1/16W R203,204 RK73GB1J154J CHIP R 150K 1/16W R286 R92-1252-05 CHIP R 0 OHM R205 RK73GB1J563J CHIP R 1/16W R287,288 RK73GB1J102J CHIP R 1.0K 1/16W K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 70 R356 RK73GB1J474J CHIP R 470K 1/16W R450 RK73GB1J102J CHIP R 1.0K 1/16W R359 RK73GB1J104J CHIP R 100K 1/16W R451 RK73GB1J272J CHIP R 2.7K 1/16W K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 71 R642 RK73GB1J222J CHIP R 2.2K 1/16W R775 RK73GB1J392J CHIP R 3.9K 1/16W R643,644 RK73GB1J102J CHIP R 1.0K 1/16W R776 RK73GB1J562J CHIP R 5.6K 1/16W K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 72 S800-842 S70-0475-05 TACT SWITCH UDZ6.2(B) ZENER DIODE 1SS226 DIODE LFB01 DIODE LFB01 DIODE DSP-301N SURGE ABSORBER DAN202U DIODE LFB01 DIODE D100 02DZ5.1(Y) ZENER DIODE K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 73 DIGITAL TRANSISTOR DTC114EKA DIGITAL TRANSISTOR Q88,89 2SB1188(Q,R) TRANSISTOR Q4,5 DTA124EKA DIGITAL TRANSISTOR FMG1 DIGITAL TRANSISTOR DTA114EKA DIGITAL TRANSISTOR 2SB1188(Q,R) TRANSISTOR Q7-10 2SK520(K44) FMG1 DIGITAL TRANSISTOR K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 74 0.5PF CC73GCH1H040B CHIP C 4.0PF C23,24 CK73GB1H471K CHIP C 470PF CC73GCH1H0R5B CHIP C 0.5PF C25,26 CC73GCH1H101J CHIP C 100PF C100 CC73GCH1H040B CHIP C 4.0PF K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 75 CC73GCH1H030B CHIP C 3.0PF C170 CC73GCH1H060B CHIP C 6.0PF C255 CK73GB1H103K CHIP C 0.010UF C171 CC73GCH1H120J CHIP C 12PF C256 CC73GCH1H120J CHIP C 12PF K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 76 CC73GCH1H050B CHIP C 5.0PF C336 CK73GB1C104K CHIP C 0.10UF C444 CK73GB1C473K CHIP C 0.047UF C338 CC73GCH1H221J CHIP C 220PF C445 CC73GCH1H030B CHIP C 3.0PF K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 77 CK73GB1H102K CHIP C 1000PF C521 CK73GB1C473K CHIP C 0.047UF C591 CC73GCH1H390J CHIP C 39PF C522 CC73GCH1H151J CHIP C 150PF C592 CC73GCH1H270J CHIP C 27PF K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 78 C92-0543-05 CHIP-TAN 3.3UF 10WV C671 CC73GCH1H390J CHIP C 39PF C753,754 CK73GB1H182K CHIP C 1800PF C672 CK73GB1H102K CHIP C 1000PF C755 CC73GCH1H180J CHIP C 18PF K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 79 CC73GCH1H270J CHIP C 27PF C835 CC73GCH1H100D CHIP C 10PF C933 CK73GB1H102K CHIP C 1000PF C836 CK73GB1H103K CHIP C 0.010UF C934,935 CK73GB1H471K CHIP C 470PF K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 80 CERAMIC FILTER L117 L34-4605-05 AIR-CORE COIL L40-1095-34 SMALL FIXED INDUCTOR (1UH) L118,119 L34-4604-05 AIR-CORE COIL L4,5 L92-0180-05 FERRITE CHIP L121,122 L40-6865-92 SMALL FIXED INDUCTOR (6.8NH) K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 81 L494 L34-2360-05 COIL L424 L40-1005-85 SMALL FIXED INDUCTOR (10U) L495 L34-4356-05 COIL L425 L40-2295-85 SMALL FIXED INDUCTOR (2.2U) L496 L40-1005-85 SMALL FIXED INDUCTOR (10U) K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 82 1/16W E,E2 RK73GB1J331J CHIP R 1/16W RK73GB1J150J CHIP R 1/16W K,KX RK73GB1J103J CHIP R 1/16W RK73GB1J101J CHIP R 1/16W RK73GB1J222J CHIP R 2.2K 1/16W K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 83 1/16W R180 RK73GB1J562J CHIP R 5.6K 1/16W R266 RK73GB1J223J CHIP R 1/16W R181 RK73GB1J182J CHIP R 1.8K 1/16W R267 RK73GB1J822J CHIP R 8.2K 1/16W K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 84 6.8K 1/16W R361 RK73GB1J272J CHIP R 2.7K 1/16W R457 RK73GB1J470J CHIP R 1/16W R362 R92-1252-05 CHIP R 0 OHM R458 RK73GB1J153J CHIP R 1/16W K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 85 CHIP R 1/16W R527 RK73GB1J561J CHIP R 1/16W R598 RK73GB1J271J CHIP R 1/16W R528 RK73GB1J682J CHIP R 6.8K 1/16W R600 RK73GB1J470J CHIP R 1/16W K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 86 CHIP R 1/16W R669 RK73GB1J150J CHIP R 1/16W R773,774 RK73GB1J271J CHIP R 1/16W R670 RK73GB1J470J CHIP R 1/16W R775 R92-1252-05 CHIP R 0 OHM K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 87 DIODE FMA1A TRANSISTOR D420 1SV283 VARIABLE CAPACITANCE DIODE DTA114EUA DIGITAL TRANSISTOR D421 MA2S077 DIODE Q400-402 2SC3722K(R) TRANSISTOR D422,423 MA2S111 DIODE Q403-405 DTC114EUA DIGITAL TRANSISTOR K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 88 CHIP C 0.010UF CC73GCH1H010B CHIP C 1.0PF CC73GCH1H100D CHIP C 10PF C96,97 CK73GB1H102K CHIP C 1000PF CK73GB1H102K CHIP C 1000PF CK73GB1C104K CHIP C 0.10UF K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 89 LEAD WIRE WITH TERMINAL (GND) C183 CK73GB1H471K CHIP C 470PF E37-0943-05 LEAD WIRE WITH MINIPIN PLUG C184,185 CC73GCH1H470J CHIP C 47PF E40-3237-05 PIN ASSY K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 90 SMALL FIXED INDUCTOR (5.6NH) L312 L40-4763-92 SMALL FIXED INDUCTOR (4.7NH) RK73GB1J271J CHIP R 1/16W L315 L40-4763-92 SMALL FIXED INDUCTOR (4.7NH) R92-1259-05 CHIP R 1/2W K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 91 CHIP R 1/16W R112 RK73GB1J222J CHIP R 2.2K 1/16W R374 RK73GB1J103J CHIP R 1/16W R117 RK73GB1J271J CHIP R 1/16W R375 RK73GB1J101J CHIP R 1/16W K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 92 TRANSISTOR Q301 2SK508NV(K52) Q302 2SC5066(O) TRANSISTOR Q303,304 2SC4617(R) TRANSISTOR Q305-307 2SC3722K(R) TRANSISTOR Q310-312 2SC4617(R) TRANSISTOR Q313,314 3SK131(M) Q315 2SC4617(R) TRANSISTOR 157-102-65001 THERMISTOR 157-502-65001 THERMISTOR K : TS-2000 (K) KX : TS-2000X (K) E : TS-2000 (E) E2 : TS-2000 (E2)
Page 93 CN504...
Page 94: Exploded View
TS-2000/X EXPLODED VIEW (FRONT PANEL) : N14-0569-04 : N19-0670-05 : N19-0673-05 TX-RX1 M2.6 x 6 (Br-Tap) : N87-2606-46 (G/9) TX-RX1 M M2.6 x 8 (Br-Tap) : N87-2608-46 TX-RX1 (C/9) M3 x 8 (TP) : N90-3008-46 (F/9) CN952 204x6 CN953 TX-RX1...
Page 95 TS-2000/X EXPLODED VIEW (CUSHION) G13-1869-05 G13-1870-05 G13-1871-05 Attach to the foil side of PCB F12-0463-04 G13-1872-05 Parts with the exploded numbers larger than 700 are not supplied.
Page 96: Packing
TS-2000/X PACKING 12 Warranty card (B46-0310-03) : E,E2 (B46-0469-10) : K,KX 10 Rating label 13 Schematic diagram (B42-7003-04) (B52-0614-00) 26 DC cord 14 Schematic diagram (E30-3157-15) (B52-0616-00) 65 Fuse (Blade) (25A) 15 Schematic diagram (F05-2531-05) (B52-0617-00) 27 Schematic diagram (B52-0618-00)
Page 97: Adjustment
TS-2000/X ADJUSTMENT Required Test Equipment 1. DC Voltmeter (DC V.M) 11. Noise Generator (Noise G.) 1) Input resistance : More than 1MΩ Must generate ignition noise containing harmonics 2) Voltage range : 1.5 to 1000V AC/DC beyond 30MHz. Note : A high-recision multimeter may be used. How- ever, accurate readings can not be obtained for high- 12.
Page 98 MAIN RF GAIN ............MAX MAIN AF GAIN .............. MIN NAIN SQL ..............MIN SUB AF GAIN ..............MIN SUB SQL ............... MIN Front panel CW TUNE 9.6k STA HF/VHF/UHF ALL MODE MULTI BANDER TS-2000 RIT/SUB F LOCK A CLEAR P.C.T MAIN AUTO MENU...
Page 99: How To Use
Service Jig Adjustment Mode Outline 1. The TS-2000/X can be adjusted manually (by turning a coil, trimmer, etc.) or by setting the service adjustment mode (adjustment with panel keys). In the service ad- justment mode (simply referred to as the adjustment mode below), adjustments items are shown in menu No.00 to 126 and all data are saved in the EEPROM (X53-...
Page 100: Adjustment Mode Menu
When any key (except [PF] key) is pressed after a fre- quency is displayed, the beep stops. 146M BPF center voltage (Sub) 146M 146.00M 2. Do not return the TS-2000/X that contains adjustment Variable capacitor voltage 118M 118.00M firmware to the user.
Page 101 TS-2000/X ADJUSTMENT Adjustment item Item Frequency Mode Adjustment item Item Frequency Mode FM S-full scale FM full 50.2M HF TX gain for power 5W/1W 14.1M SSB IF gain SSB start 144.2M ALC meter start Start 14.1M SSB S1 SSB S1 144.2M...
Page 102 TS-2000/X ADJUSTMENT Display Check Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 1. All reset 1) DC IN : 13.8V Front After displaying Display should be normal. Hold down [A=B] key and panel “HELLO”, the Should be at the reset press the [POWER]key.
Page 103: Receiver Section
TS-2000/X ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment ± 0.03V 7) VHF MAIN PLL DC V.M TX-RX2 TP503 TX-RX2 TC405 1.0V Display f. : 142.00MHz Spectrum (B/11) (H/11) Mode : FM analyzer Display f. : 152.000MHz Check 4.6V or less...
Page 104 TS-2000/X ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 3. MCF 1) Display f. : 14.000MHz Tracking Rear ANT1 TX-RX1 L54 Adjust the coils to (69.085MHz) Mode : USB generator panel (A/9) obtain the frequency 69.085...
Page 105 TS-2000/X ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 6. MAIN 1) Trap default Tracking Rear ANT430 TX-RX2 TC9 Adjust the trimmer UHF BPF generator panel (A/11) to get a null point at 366MHz 366MHz as shown.
Page 106 TS-2000/X ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 10. 10.695MHz 1) Menu No. : 20 SSG1 Rear ANT2 Front [+] key Change the adjust- IF filter SSG1 f. : 1.8330MHz SSG2 pnel panel ment values to get SSG1 output : –33dBm/5010µV 2 signal pad...
Page 107 TS-2000/X ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 17. Sub band 1) Menu No. : 10 Rear ANT144 TX-RX2 L28 After setting the S-meter voltage max. Display f. : 146MHz panel (A/11) adjustment value to...
Page 108 TS-2000/X ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment Band Frequency (K) Frequency (E) Mode SSG RF level (dBm) SSG MOD Measurement Spec. MAIN 550kHz 550KHz –85 1kHz 60%→OFF >10dB MAIN 14.200MHz 14.200MHz –119→OFF >10dB MAIN 18.200MHz...
Page 109 TS-2000/X ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 24. 50MHz FM 1) Menu No. : 32 Rear ANT1 Front [+] key 1 push S-meter lights up to S1 level. S-meter Display f. : 50.2MHz...
Page 110 TS-2000/X ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 30. 440MHz 1) Menu No. : 48 Rear ANT430 Front [+] key 1 push S-meter lights up to S1 level. FM S-meter Display f. : 438.2MHz...
Page 111 TS-2000/X ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 38. 430MHz 1) Menu No. : 65 Rear ANT430 Front [+] key 1 push sub band Display f. : 438.2MHz panel panel FM SQL Mode : FM AF V.M...
Page 112 TS-2000/X ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 5. TX BPF 1) Menu No. : 15 Spectrum TX-RX2 CN3 Front [+] key After setting the 8dBm or more (UHF) Display f. : 435.1MHz analyzer...
Page 113 TS-2000/X ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 12. Power 1) Menu No. : 68 Power meter Rear ANT1 Filter Set it at the center frequency Display f. : 14.1MHz panel position. characteristic Mode : USB DC V.M...
Page 114 TS-2000/X ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 24MHz 8) Menu No. : 80 Power meter Rear ANT1 Front [+] key Set the adjustment 100W±3W Display f. : 24.9MHz panel panel value within the Transmit [–] key limit of the specified...
Page 115 TS-2000/X ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 19. UHF 1) Menu No. : 101 Power meter Rear ANT430 Front [+] key Set the adjustment 50W±2W power POC Display f. : 438.1MHz panel panel...
Page 116 TS-2000/X ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 27. VHF SWR 1) Menu No. : 121 Ammeter Rear ANT144 Front [+] key Set the adjustment protection Display f. : 145.9MHz panel panel value within the limit Mode : CW [–] key of the specified...
Page 117 TS-2000/X ADJUSTMENT 1200MHz Unit Receiver Section Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 1. RX IF gain 1) Display f. : 1270.00MHz Rear ANT1.2G TX-RX3 L22 Level max. Mode : FM panel SSG f. : 1270.00MHz Spectrum TX-RX3 CN5 SSG output : –70dBm/70.7µV analyzer...
Page 118 TS-2000/X ADJUSTMENT 1200MHz Unit Transmitter Section Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 1. TX IF gain 1) Display f. : 1270.00MHz Spectrum Rear ANT1.2G TX-RX3 Set the carrier level Mode : CW analyzer panel at approx.
Page 119 TS-2000/X ADJUSTMENT Adjustment Points (Upper Side) FILTER UNIT (X51-315) (AMD) FINAL UNIT (X45-360) (A/2) VR102 TC101 TC102 CN11 FRONT FILTER UNIT FINAL UNIT (A/2) TC1 : Null TC101,102 : VHF Maximum power VR1 : Power frequency characteristic VR1,2,102 : Final idling current (HF/VHF)
Page 120 TS-2000/X ADJUSTMENT Adjustment Points (Lower Side) CN906 430ANT PADDLE L163 TP504 TP503 L164 H/11 G/11 CN19 TC404 TC405 TP512 VRCV E/11 TC406 TC12 TP501 TP502 TC10 CN15 HRCV D/11 TC13 TC408 TC14 TC403 TC410 W503 VR902 VULO2 L422 L427 TC409...
Page 121 TS-2000/X ADJUSTMENT Adjustment Points (Lower Side) PANEL EXT. CONT ACC2 REMOTE D-SUB EXT RX (TP4) (TP5) L63 L62 L102 L100 L99 L98 L96 L103 L105 L108 L109 L614 CN14 L613 HFTX TX-RX 1 UNIT (X57-605) (A/9) TPNB TX-RX 1 UNIT (A/9)
Page 122 TS-2000/X ADJUSTMENT 1200MHz Adjustment Points FRONT TX-RX 3 UNIT (X57-607) L399 L338 CN15 L340 L320 TC301 L341 L321 12TIF CN11 12RIF 12ANT L342 CN16 CN14 CN13 CN14 CN7 CN12 TX-RX 3 UNIT L2,3,9 : TX IF gain L5,320,321 : MCF (135.395MHz) L22,24,25,29 : RX IF gain L26~28 : MCF (135.495MHz)
Page 123: Terminal Function
TS-2000/X TERMINAL FUNCTION CN No. Pin No. Name I/O Function FINAL UNIT (X45-360 A/2) O Constantly 14V for digital circuit CN No. Pin No. Name I/O Function O 8V when the power switch on (digital) O Switched 14V for external antenna...
Page 124 TS-2000/X TERMINAL FUNCTION CN No. Pin No. Name I/O Function CN No. Pin No. Name I/O Function O Antenna 1/2 changeover relay control. O Reflected wave detection voltage “H” for antenna 2 of HF-50MHz, comes from Filter unit then combine with 144MHz VSR...
Page 125 TS-2000/X TERMINAL FUNCTION CN No. Pin No. Name I/O Function CN No. Pin No. Name I/O Function 12THV – Reserved O 5V 12UL PLL unlock detect, “L” when 1.2GHz PLL is unlocked Power switch, “L” for power on 12EN2 O Enable 2 for 1.2GHz unit INIT “H”...
Page 126 TS-2000/X TERMINAL FUNCTION CN No. Pin No. Name I/O Function CN No. Pin No. Name I/O Function MRBK O Main receive blanking control. Audio out from DRU-3A “H” for blanking AGCR O AGC reference voltage End of message from DRU-3A.
Page 127 TS-2000/X TERMINAL FUNCTION CN No. Pin No. Name I/O Function CN No. Pin No. Name I/O Function CN506 O Modulation output CN18 MDET O Main detect output, Modes other than FM : 12kHz IF output, FM mode : AF MDET...
Page 128 TS-2000/X TERMINAL FUNCTION CN No. Pin No. Name I/O Function CN No. Pin No. Name I/O Function VSFM O Forward wave detection voltage Audio Mute, active “H” to mute SP1/ of HF-50MHz VSWR, amplified by SP2 output IC19 Start switch, active “H”. When START...
Page 129 TS-2000/X TERMINAL FUNCTION CN No. Pin No. Name I/O Function CN No. Pin No. Name I/O Function SBPF O Control voltage for variable capacitor Forward wave detection voltage of SUB RX BPF of HF-144MHz VSWR O Common 8V Reflected wave detection voltage...
Page 130 TS-2000/X TERMINAL FUNCTION TX-RX 1 UNIT (X57-605 F/9) CN No. Pin No. Name I/O Function O Mode set up signal (7 seg LCD IC) CN No. Pin No. Name I/O Function LINH O Display inhibit signal (7 seg LCD IC)
Page 131 TS-2000/X TERMINAL FUNCTION CN No. Pin No. Name I/O Function CN No. Pin No. Name I/O Function REN1 IC2 enable PEN4 PLL IC (IC412) enable Serial clock PEN3 PLL IC (IC410) enable DATA Serial data PEN2 PLL IC (IC414) enable...
Page 132: Wiring
TS-2000/X TS-2000/X WIRING...
Page 133 TS-2000/X PC BOARD VIEWS FILTER UNIT (X51-315X-XX) 0-00 : K,KX 2-71 : E,E2 Component side view 144ANT K352 ANT1 ANT2 C507 K552 C358 C207 C258 C408 C457 D501 D201 D351 D251 D451 K302 D401 K502 K202 K252 K452 C209 K402...
Page 134: Final Unit (X45-360X-Xx)
TS-2000/X PC BOARD VIEW J72-0701-01 A/2 C884 FINAL UNIT (X45-360X-XX) (A/2) 0-11 : K,KX 2-71 : E,E2 Component side view C886 L111 K823 CN804 CN803 K822 144PO L112 D101 R108 CN204 HFPO C141 K819 C885 K820 C871 C140 R110 D102...
Page 135 TS-2000/X PC BOARD VIEW J72-0701-01 A/2 C884 FINAL UNIT (X45-360X-XX) (A/2) 0-11 : K,KX 2-71 : E,E2 Foil side view C886 K823 L111 K822 CN803 CN804 144PO L112 D101 R108 CN204 HFPO C141 C885 K819 C871 K820 R110 C140 D102...
Page 136 TS-2000/X Note : Components marked with a dot (·) are parts of pattern 1. CIRCUIT DIAGRAM...
Page 137 TS-2000/X PC BOARD VIEWS / CIRCUIT DIAGRAM FIANL UNIT (X45-360X-XX) (B/2) 0-11 : K,KX 2-71 : E,E2 Component side view CN907 CN905 L927 L928 C989 J72-0701-01 B/2 43RX L930 C991 L901 C904 CN906 D903 430ANT R913 C980 VR902 L919 C933...
Page 138: Display Unit (X54-3320-00)
TS-2000/X PC BOARD VIEWS / CIRCUIT DIAGRAM DISPLAY UNIT (X54-3320-00) Component side view POWER CLEAR 10 11 PROC C2 R2 C1 R1 SEND AT TUNE J72-0731-01 DISPLAY UNIT (X54-3320-00) Foil side view J72-0731-01 AT TUNE SEND C1 R1 C2 R2...
Page 139: Control Unit (X53-391X-Xx)
TS-2000/X PC BOARD VIEW CONTROL UNIT (X53-391X-XX) 0-11 : K,KX 2-71 : E 2-72 : E2 Component side view 2SC2712 2SK2596 BA10T DAT124EKA 2SA1037K DTB143EK 2SC3356 2SA1774 Ref No. Address Ref No. Address DTC114EE 2SC3722K DTC124EKA 2SC4116 J72-0702-01 IC520 C524...
Page 140 TS-2000/X PC BOARD VIEW CONTROL UNIT (X53-391X-XX) 0-11 : K,KX 2-71 : E 2-72 : E2 Foil side view Ref No. Address J72-0702-01 C516 R745 IC10 C502 R736 IC11 C501 R534 IC12 R746 IC27 C515 IC508 IC504 IC29 R731 IC31...
Page 141 TS-2000/X PC BOARD VIEW CONTROL UNIT (X53-391X-XX) 0-11 : K,KX 2-71 : E 2-72 : E2 Component side view + Foil side Ref No. Address Ref No. Address Ref No. Address IC501 IC534 J72-0702-01 C526 C527 C529 C541 C542 C544...
Page 142 TS-2000/X CIRCUIT DIAGRAM...
Page 143 TS-2000/X CIRCUIT DIAGRAM Note : Components marked with a dot (·) are parts of pattern 1.
Page 144 TS-2000/X CIRCUIT DIAGRAM...
Page 145 TS-2000/X CIRCUIT DIAGRAM Note : Components marked with a dot (·) are parts of pattern 1.
Page 146 TS-2000/X TX-RX 1 UNIT (X57-605X-XX) (A/9) 0-11 : K,KX 2-71 : E,E2 PC BOARD VIEW Component side view ACC2 D-SUB EXT. CONT D712 D713 C411 C410 EXT RX ANT R500 R494 PANEL REMOTE C529 + R775 C461 R399 C469 R497...
Page 147 TS-2000/X PC BOARD VIEW TX-RX 1 UNIT (X57-605X-XX) (A/9) 0-11 : K,KX 2-71 : E,E2 Foil side view ACC2 D-SUB D713 D712 EXT. CONT EXT RX ANT C410 C411 R494 R500 PANEL REMOTE C529 R775 C461 R399 R497 C469 C434...
Page 148 TS-2000/X PC BOARD VIEWS TX-RX 1 UNIT (X57-605X-XX) (B/9) 0-11 : K,KX 2-71 : E,E2 Component side view D803 D804 S803 D801 R805 J72-0698-01 B/9 S838 S800 S807 S825 S833 M.IN S812 R808 MENU R806 D825 R800 R802 R804 D802...
Page 149: Tx-Rx 1 Unit (X57-605X-Xx)
TS-2000/X PC BOARD VIEWS Component side TX-RX 1 UNIT (X57-605X-XX) (C,D,E,F,G/9) 0-11 : K,KX 2-71 : E,E2 Foil side Component side view J72-0698-01 R954 C951 C950 J72-0698-01 D/9 CN953 J950 C959 CN951 VR950 CN956 VR952 VR951 CN952 S AF/A SQL...
Page 150 TS-2000/X CIRCUIT DIAGRAM Note : Components marked with a dot (·) are parts of pattern 1.
Page 151: Tx-Rx 2 Unit (X57-606X-Xx)
TS-2000/X PC BOARD VIEW TX-RX 2 UNIT (X57-606X-XX) (A/11) 0-11 : K,KX 2-71 : E,E2 Component side view MBPF C205 C232 C109 CN19 C350 C304 R153 C136 C102 C164 R317 R233 C166 L160 C196 R263 C307 C298 C282 C222 L159...
Page 152: E,E2 Foil Side View
TS-2000/X PC BOARD VIEW TX-RX 2 UNIT (X57-606X-XX) (A/11) 0-11 : K,KX 2-71 : E,E2 Foil side view MBPF C205 C232 C109 CN19 R153 C304 C350 C102 C136 R317 C164 R233 C166 L160 C196 L159 C222 C307 R263 C282 C298...
Page 153 TS-2000/X PC BOARD VIEW TX-RX 2 UNIT (X57-606X-XX) (B/11) 0-11 : K,KX 2-71 : E,E2 Component side view J72-0699-01 B/11 L449 A513 A520 A511 R718 TP502 A521 R670 R761 Q447 R523 C777 R650 R521 C863 R773 R612 C916 Q461 R607...
Page 154 TS-2000/X PC BOARD VIEW TX-RX 2 UNIT (X57-606X-XX) (B/11) 0-11 : K,KX 2-71 : E,E2 Foil side view J72-0699-01 B/11 L449 A513 A520 A511 R718 A521 TP502 R761 R670 R523 Q447 R521 R650 C777 R773 C863 C916 R612 Q461 R768...
Page 155 TS-2000/X PC BOARD VIEWS TX-RX 2 UNIT (X57-606X-XX) (C,D,E,G,H,I,J,K/11) 0-11 : K,KX 2-71 : E,E2 Component side view D/11 E/11 J/11 J72-0699-01 C/11 L453 L483 R605 R677 R604 R533 R589 L493 L503 CN510 L492 A501 R697 D417 D420 D416 R532...
Page 156 TS-2000/X Note : Components marked with a dot (·) are parts of pattern 1. CIRCUIT DIAGRAM...
Page 157 TS-2000/X CIRCUIT DIAGRAM Note : Components marked with a dot (·) are parts of pattern 1.
Page 158: Tx-Rx 3 Unit (X57-6070-00)
TS-2000/X PC BOARD VIEW TX-RX 3 UNIT (X57-6070-00) Component side view : KX 12UL J72-0700-11 R361 R360 C370 R366 C372 C399 12TXB Q311 12EN3 R359 C134 R365 R364 C194 C378 C373 12EN2 12RXB C131 12EN1 C195 L399 L338 R335 R334...
Page 159 TS-2000/X PC BOARD VIEW TX-RX 3 UNIT (X57-6070-00) Foil side view : KX J72-0700-11 R381 L315 C403 R343 L318 L348 C147 C137 L347 C334 C383 R327 L323 R329 Q305 R324 C388 D303 C171 C170 C329 R383 R117 R331 R322 C395...
Page 160 TS-2000/X PC BOARD VIEW TX-RX 3 UNIT (X57-6070-00) Component side view + Foil Side : KX AK4518 UPC2709TB 320VC5402PGE M62364FP TC74LVX4245FS 12UL J72-0700-11 R361 R360 C370 R366 C372 C399 12TXB 12EN3 R359 TGT0210Q AD9851BRS C134 R365 R364 TMT0111Q LC73881M C378 C373...
Page 161: Ts-2000/X Circuit Diagram
TS-2000/X CIRCUIT DIAGRAM Note : Components marked with a dot (·) are parts of pattern 1.
Page 162: Block Diagram
TS-2000/X BLOCK DIAGRAM ANT1 ANT2 HF RX ANT 30k~1.705MHz 1.705~2.5MHz HF/50MHZ –12dB 2.5~4.1MHz ~60MHz 1.705MHz~ 4.1~6.9MHz RSSI out Q710 2SC4617(S) 6.9~7.5MHz PRE AMP 455kHz Squelch det out Q7~10 Q19,20 Q700,701 2SK520(K43) x 2 3SK131(M) x 2 2SK520 x 4 10.695MHz...
Page 163 –1dB –1dB 58.390~ Accumulator Q403 10kHz 14.5dB 65.230MHz DEN6 –8.5dBm DTC114EUA 4dBm 226,319 CN22 Ripple TX-A18 (KENWOOD DEVICE) HF 2nd Splitter Filter VCO SW –1dB 0.5ppm (–10~+50°C), 1.0ppm (–20~+60°C), –0.5 –1.5 PEN5 Q419 –3.5dBm 2SC4617(R) 945,1194 TX-RX 2 (PLL) TX-RX 1 (HF/IF)
Page 164: Level Diagram
TS-2000/X TS-2000/X LEVEL DIAGRAM (RX SECTION) TX-RX 1 UNIT TX-RX 1 UNIT (X57-605 A/9) CONTROL UNIT (X53-391) (X57-605 A/9) 14.201MHz 69.085MHz 10.695MHz 455kHz RIF 12kHz AF 1kHz –113dBm –112dBm –96dBm –87dBm –87dBm –78dBm –71dBm –41.5dBm –46dBm 45mVp-p –53.5dBm –112.5dBm –94dBm –83dBm...
Page 165 TS-2000/X TS-2000/X LEVEL DIAGRAM (TX SECTION) FILTER UNIT (X51-315) CONTROL UNIT (X53-391) TX-RX 1 UNIT (X57-605 A/9) FINAL UNIT (X45-360 A/2) AF 1kHz TIF 12kHz 10.595MHz 68.985MHz 14.2MHz 100mVp-p 100mVp-p 19mVp-p 240mVp-p 45mVp-p 280mVp-p 440mVp-p 450mVp-p 430mVp-p 2.5Vp-p 6.0Vp-p 35Vp-p...
Page 166: Mc-52Dm
TS-2000/X MC-52DM (MULTI-FUNCTION MICROPHONE WITH DTMF) External View Parts List Ref. No. New Parts No. Description parts A02-1982-08 Case (Front) A02-1983-08 Case (Rear) E30-3243-08 Microphone cord assy (Metal) K29-5101-08 Knob (PTT) K29-5102-08 Knob (Up, Down) K29-5103-08 Key top (20 key)
Page 168: Arcp-2000
TS-2000/X UT-20 (1200MHz All Mode Unit) / RC-2000 (Mobile Controller) / ARCP-2000 (Radio Control Program) UT-20 External View ARCP-2000 External View System requirements : ® • IBM PC/AT and compatible machines with Microsoft Windows ® 95 or Windows ® ®...
Page 169: Specifications
Dimensions (W x H x D) ............. 270 x 96 x 317 mm / 10.6 x 3.8 x 12.5 in (Projections included) ............. (281 x 107 x 371 mm / 11.1 x 4.2 x 14.6 in) Weight ..................TS-2000 : Approx. 7.8kg (17.2 lbs) TS-2000X : Approx. 8.2kg (18.1 lbs) Transmitter Frequency range 160m band ................
Page 170 TS-2000/X SPECIFICATIONS Receiver Circuit type Main band SSB/CW/AM/FSK ..........Quadruple conversion superheterodyne FM ..............Triple conversion superheterodyne Sub band FM/AM .............. Duble conversion superheterodyne Frequency range ( ) : VFO coverage range Main band ................0.5 to 30MHz, 50 to 54MHz (0.03 to 60.0MHz)
Page 171 Mechelsesteenweg 418 B-1930 Zaventem, Belgium KENWOOD ELECTRONICS FRANCE S.A. 13, Boulevard Ney, 75018 Paris, France KENWOOD ELECTRONICS U.K. LIMITED KENWOOD House, Dwight Road, Watford, Herts., WD1 8EB United Kingdom KENWOOD ELECTRONICS EUROPE B.V. Amsterdamseweg 37, 1422 AC Uithoorn, The Netherlands KENWOOD ELECTRONICS ITALIA S.p.A.

This manual is also suitable for:

Ts-2000x

Kenwood TS-2000 Service Manual

Quick Links

Need help?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Kenwood TS-2000

Summary of Contents for Kenwood TS-2000

This manual is also suitable for:

Table of Contents