Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Worldlawn 28?
Summary of Contents for Worldlawn 28?
- Page 1 Operator’s Manual Commercial / Residential 28″Mower Service Information ● Mower Operation ● Adjustments & Repairs ● Warranty ● Worldlawn Power Equipment, Inc. 422 Turnbull Canyon Road City of Industry CA 91744 Toll Free Number:1-866-9-Mowers(1-866-966-9377)
-
Page 2: Service Information
Service Information WORLDLAWN 28” COMMERCIAL RESIDENTIAL MOWER SERVICE AND REPAIR PARTS INFORMATION If you have questions, problems, need an Operator’s or Parts Factory specified replacement parts for your Mower are Manual, please contact your local Worldlawn authorized available from either your local worldlawn authorized dealer dealer or call the Factory. -
Page 3: Table Of Contents
Mower Deck Belt Adjustments ……………………………………………………… Transmission Drive Belt Adjustments ………………………………………………. Wheel Drive Belt Adjustments………………………………………………………. Blade Replacement…………………………………………………………………… Blade Drive Belt Replacement (1.5’’-3’’) …………………………………………… Blade Drive Belt Replacement (2’’-4’’) ……………………………………………… Synchronous Belt Replacement……………………………………………………… Transmission Drive Belt Replacement……………………………………………….. Blade Brake Pad Replacement……………………………………………………….. Wheel Drive Belt Replacement………………………………………………………... -
Page 4: Safety Information
. A replacement operator’s manual is available from your dealer or by contacting Worldlawn Power Equipment, Inc. 422 Turnbull CAUTION Canyon Road, City of Industry , CA 91744 . -
Page 5: Preparation To Mow
Adjustment & Repairs ·Each of the control rods must be connected as shown in ● Know the controls and how to stop quickly. ● Do not allow children under fourteen years old to operate the mower. FIG2. Follow the instructions to properly adjust each of the controls. -
Page 6: Maintenance And Storage
CAREFULLY READ AND UNDERSTAND ALL SAFETY INSTRUCTIONS BEFORE ATTEMPTING TO OPERATE THE MOWER. INITIAL RUN PROCEDURES ·Check the belts for proper tension at 2, 4 and 8 hours. ·Check the steering control rods for neutral adjustment . ·Check the tires for proper pressure. Drive wheels: 20 PSI (140kPa) ·Check for loose hardware. -
Page 7: Wheel Drives
The cutting height can be adjusted from 1.5” to 3” blade drive lever forward to engaged position. The blades will rotate at (WY28B: form 2” to 4”) in 0.5” increments by changing the height of high speed. Pull the mower blade drive lever backward to disengaged the mower deck. -
Page 8: Wheel Drive Belt Adjustments
Reinstall the belt cover. FIG12. Otherwise, owner/user is responsible for the mower, tension it more, otherwise, adjust the belt on the left side of accidents or injuries occurring. BLADE DRIVE BELT Replacement（2’’---4’’） the mower. FIG9. BLADE REPLACEMENT Remove the belt cover, loosen four locknuts of the belt guard bracket(s) Remove belt cover, remove blade bolts, washer, plate and locknut. -
Page 9: Transmission Drive Belt Replacement
Adjustment &Repairs WARNING: NOTE: Be sure that both blades are perpendicular to each other Shut off engine and disconnect the spark plug wire before removing belt cover. while installing, It could otherwise result in serious mower WHEEL DRIVE BELT REPLACEMENTS damage. -
Page 10: Drive Control Adjustments
Adjustment &Repairs FIG16 FIG15 SHIFT CONTROL ROD ADJUSTMENTS When the transmission is in neutral, adjust the shift control rod so that the switch travel is compressed more than 5 mm. To adjust the shift control rod, remove the hair pin on the top of the shift control rod, pull out the shift rod from the gear shift lever, turn the shift control rod as needed, then reinstall all parts in proper order. -
Page 11: Electrical Schematic
Adjustment & Repairs Electrical Schematic WIRING HARNESS DIAGRAM... -
Page 12: Service Instructions To Transmission
Adjustment & Repairs SERVICE INSTRUCTIONS TO TRANSMISSION Service Interval The first service time: 80 hours The next service time: every 300 hours Service Method · Remove drain plug from the back of transmission , and drain lubricate oil into a container, see FIG19. Caution: Make sure to completely drain all the lubricating oil from transmission. -
Page 13: Accessory
Accessory GRASS CATCHER & COUNTER-WEIGHT Grass catcher : FIG18. Model： WY28-NGC Capacity： 80 Liters（2.1 Bushels） FIG18... -
Page 14: Warranty
Worldawn Power Equipment, Inc, (“Worldlawn”) warrants Worldlawn’s sole responsibility with any claim made under that the worldlawn 28” Mower (“Mower”) will be free from this warranty is limited only to repairing or replacing the defects in material and workmanship for a period of one year mower or a defective part thereof, and no claim of breach of commercial from the original date of purchase. -
Page 15: Notes
Notes NOTES... - Page 16 Worldlawn Power Equipment, Inc 422 Turnbull Canyon Road City of Industry CA 91744 Phone:(626) 934-8552 Fax: (626) 934-8162 E-mail: worldlawnmower@adelphia.net Form No. 28102-200801...