Related Manuals for Worldlawn WY32
Summary of Contents for Worldlawn WY32
- Page 1 Operator’s Manual WY32 Commercial Mower Worldlawn Power Equipment, Inc. Industrial Park 2415 Ashland Ave. Beatrice, NE 68310 Toll Free Number: 1-800-267-4255...
- Page 3 OPERATOR’S MANUAL This manual contains assembly, operating, maintenance, adjustment, and safety instructions for your WY32 lawn mower. Before operating your mower, read this manual in its entirety carefully. Keep this mower Owner’s Manual when lent or transferred. If this mower Operator’s Manual becomes lost, damaged or illegible, replace it immediately, replacements may be ordered through our sales department.
-
Page 4: Table Of Contents
TABLE OF CONTENTS 1. SAFETY……………………………………………………………………………………………… 1.1 Safety Alert Symbol………………………………………………………………………………… 1.2 Training……………………………………………………………………………………………… 1.3 Preparation…………………………………………………………………………………………… 1.4 Operation…………………………………………………………………………………………… 1.5 Maintenance & Storage……………………………………………………………………………… 1.6 Safety Decals………………………………………………………………………………………… 2. SPECIFICATIONS………………………………………………………………………………….. 2.1 Model Number……………………………………………………………………………………… 2.2 Engine……………………………………………………………………………………………… 2.3 Frame Assembly …………………………………………………………………………………… 2.4 Drive System ……………………………………………………………………………………… 2.5 Cutting Deck ………………………………………………………………………………………… 2.6 Operator Controls……………………………………………………………………………………... -
Page 5: Cutting Height Adjustment
5.1.2 Clean Engine Air Cooling System………………………………………………………………… 5.1.3 Clean Grass Build-up from Under Deck ………………………………………………………… 5.1.4 Check Mower Blades……………………………………………………………………………… 5.1.5 Check Safety Interlock system…………………………………………………………………….. 5.1.6 Check For Loose Hardware……………………………………………………………………….. 5.1.7 Service Air Cleaner………………………………………………………………………………… 9 5.1.8 Change Engine Oil………………………………………………………………………………… 5.1.9 Check Tire Pressure……………………………………………………………………………….. 5.1.10 Check Condition of Belts…………………………………………………………………………... -
Page 6: Safety
Refuel only outdoors. and attachments approved by. Store gasoline in an approved container Worldlawn Power Equipment, Inc. and keep it out of reach of children. Add fuel before starting the engine. Never remove the cap of the fuel tank... -
Page 7: Operation
Do not operate without entire exhaust level. system in place and in proper working Refuel only outdoors, never inside an condition. enclosed trailer. Be sure all fuel tanks and gasoline storage containers have proper caps installed to prevent spillage and POTENTIAL HAZARD minimize vapor escaping into the ... -
Page 8: Maintenance & Storage
1.4.1 Give complete, undivided attention to the job overspend the engine. Operating the engine at at hand. excessive speed may increase the hazard of 1.4.2 Mow only in daylight or good artificial light, personal injury. keeping away from holes and hidden hazards. 1.4.8 Disengage the blade before starting engine. -
Page 9: Safety Decals
1.6.4 New safety decals may be obtained from your authorized equipment dealer or distributor or from Worldlawn Power Equipment, Inc. 1.6.5 Safety decals may be applied by peeling off the backing to expose the adhesive surface. Apply only to clean, dry surface. Smooth to remove any air bubbles. -
Page 10: Specifications
Forward Speed Range: 0-3.55mph (0-5.7km/h). 2.5 CUTTING DECK Type: Floating deck. 13. On the console（Recoil Kawasaki） True Cutting Width: WY32=32.0"（81.3cm）. Blade engagement: Manual operator. Cutting Height Adjustment: 1.5"（3.8cm）to 4.0" （10.16cm）, in 0.5"（1.27cm）increments. Cutting Blades 0.2" (5mm) thick, two 16.5"... -
Page 11: Operator Controls
2.7 ACCESSORIES: and moving throttle lever to the rear will Grass Catcher Assembly (WY32-NGC): 80L, see decrease engine speed. Some recoil starter FIG 2. models are not equipped with key switch. Move ... -
Page 12: Torque Requirements
2.8.5 Wheelbase: WY32: 31.8in（80.8cm） 2.8.6 Curb Weight: WY32: 100Kg （220lbs） 2.9 TORQUE REQUIREMENTS Cutter Housing Spindle Nut: 66± 13ft-lb (90± 18N-m) Engine Deck/Front Frame Mounting Bolts: 40-52ft-lb (55-70 N-m) 3. ASSEMBLY INSTRUCTIONS FIG 5 3.1 OPEN CRATE Open crate. -
Page 13: Mower Operation
into the lock position. Rotate key switch to the “OFF″ position. Remove the key to prevent children or other POTENTIAL HAZARD unauthorized persons from starting the engine. Close The rotating blades under the mower deck are fuel shut-off valve when the machine will not be used dangerous. -
Page 14: Clean Grass Build-Up From Under Deck
POTENTIAL HAZARD POTENTIAL HAZARD Excessive debris can cause the engine and Operating a mower deck with loose or hydraulic system to overheat. weakened blade bolts can be dangerous. WHAT CAN HAPPEN WHAT CAN HAPPEN Excessive debris around the engine cooling air A loose or weakened blade bolt could intake and inside of the pump compartment can allow a blade rotating at a high speed to... -
Page 15: Change Engine Oil
Do NOT wash or use pressurized air to clean paper element or inner element. 5.1.8 Change engine oil. Service Interval: 100 hrs NOTE: Change oil and filter after first 5 hours of operation. Stop engine, wait for all moving parts to stop, and remove key or pull out spark plug lead. -
Page 16: Synchronous Belt Adjustment And Replacement
Loosen locknuts of the belt guard on the belt pulley in reverse order. Adjust the belt according guard fixed seat on the mower deck; loosen bolts to the method of belt adjustment, then tighten the of the belt guard bracket beside engine pulley on nut. -
Page 17: Transmission Case Replacement
When the mower pulls left or right or is not 5.2.7 Shift Control Rod Adjustment driving in line in normal conditions, the steering Stop engine, wait for all moving parts to stop, linkage on left, right or both sides needs to be and remove key or pull out spark plug lead. -
Page 18: Troubleshooting
Remove oil plug and let oil drain into appropriate The following table lists some of the common container. causes of trouble. NOTE: Engine oil in gear case must be completely drained. ENGINE TROUBLESHOOTING TABLE Tighten the oil plug. Will not start ... - Page 19 7.1 CHECK BATTERY Check the voltage of the battery with a digital · Battery contains sulfuric acid. Avoid contact and voltmeter. Locate the voltage of the battery in the always shield eyes, face, skin, and clothing from table below and charge the battery for the battery.
-
Page 20: Electrical Schematic
8. ELECTRICAL SCHEMATIC Recoil diagram (B&S & Honda) Recoil diagram (Kawasaki) Electrical diagram（BS11HP）... - Page 21 Electrical diagram (Kawasaki) Electrical diagram (Honda) Electrical diagram（BS13.5HP）...
-
Page 22: Limited Warranty
LIMITED WARRANTY WORLDLAWN POWER EQUIPMENT, INC 32″ MOWER Worldlawn Power Equipment, Inc, (“Worldlawn”) rescission, cancellation, or voiding the contract of sale warrants that the Worldlawn 32” Mower (“Mower”) of the Mower. will be free from defects in material and workmanship... - Page 24 Worldlawn Power Equipment, Inc Industrial Park 2415 Ashland Ave. Beatrice, NE 68310 Phone: (402) 228-4255 Fax: (402) 223-4103 www.worldlawnpowerequip.com Form No. 32101-201111...