Page 1
Please read carefully before proceeding with installation. Your failure to follow any attached instructions or operating parameters may lead to the product’s failure and possible damage to property. Save manual for future reference MODELS 5 SV DELUXE RO-TFM-4SV WATTS PREMIER 25 RO-TFM-5SV...
Membrane Maintenance ........................15 Check Air Pressure in the Tank ......................16 5 Stage Reverse Osmosis System ...................... 19 California Certification ........................21 Other Products from Watts Premier ..................... 22 Warranty Registration ............................25 Service Record ........................... 27 Limited Warranty ..............................28...
Operational Parameters Do not use with water that is microbiologically unsafe or of unknown quality, without adequate disinfection before or after the system. F ° ° 8 i n i F ° ° 4 i n i i n i d i l <...
Drill a Hole for the Faucet in a Porcelain Sink Note: Porcelain sink surface material is extremely hard and can crack or chip quite easily. Use extreme caution when drilling. Premier Manufactured Systems accepts no responsibility for consequential damage resulting from the installation of faucet. A dripping or gurgling sound may be heard coming from the Air Gap hole in the faucet when the system is running.
Wave Faucet Installation Note: If using the Wave Air Gap Faucet (included), a 1 1/4" hole will be required. If using a Wave non air gap faucet, a 3/4” hole will be required. Step 6 Gather and identify the Wave faucet pieces. •...
Page 6
AG-SS with Monitor Faucet Installation Note: If using the AG-SS Monitor Air Gap Faucet , a 1 1/4" hole will be required. Step 6 Gather and identify the M-500 faucet pieces. Step 7 Remove Faucet and small parts from plastic bag. Slip the Gasket over the threaded Stem to the Faucet Flange.
Adapta Valve Installation Configuration for 3/8” Configuration for 1/2” compression fittings compression fittings Step 11 Turn off the cold water supply to the faucet by turning the angle stop valve completely off. Step 12 Attach adapta valve as illustrated in the three photos above, choosing the configuration that fits your plumbing.
Drain Saddle Installation Drain Saddle fits standard 1 ¼” – 1 ½” drain pipes Step 14 Gather the pieces of the drain saddle 1 Black compression nut 1 Semi-circle bracket with opening 2 Screws 1 Foam washer 2 Nuts for screws 1 Semi-circle bracket Step 15 The small square black foam gasket with a circle cut out of the middle...
Green Tube Connection Drape the green tube connected to the 90° Inlet white plastic elbow on the left side of the Step 19 Reverse Osmosis Module over to the adapta valve attached to the cold water sink faucet or attached to the Angle Stop Valve, leaving a gentle curve in the tubing. Cut to desired length using a sharp knife.
Black Tube Connection Note: The tubing must be as SHORT and STRAIGHT as possible, making a downward slope from faucet to drain saddle to allowfor proper drainage. Step 24 Measure the black tube from faucet to the black drain saddle and make a straight cut with a sharp knife though tube.
Step 29 Thread the 2 white plastic connectors into the final filter and tighten. Step 30 To install the 6" filter cut the blue tube from the faucet approximately in half. Insert the blue tube attached to the faucet into the “out” port of the filter.
Start up Instructions Note: If unit is supplied with GAC Carbon Filters (hard plastic case) you will need to start at step # 1 in this section. If unit is supplied with Carbon Block Filters (mesh covering) you may skip to Step 4 of this section.
√ Two 10” carbon filters √ Bucket to catch water from filter housings. √ Wrench to loosen filter bowls. (Watts Premier also sells a double sided wrench). Step 1 Turn off incoming water supply to the RO at needle valve on adapta valve.
Perform steps 4, 5 and 6 in the start up instruction section. Annual Maintenance Watts Premier sells a filter change kit which includes pre-filters, orings, a final filter, connectors, and a wrench. Call 1-800-752-5582 or buy online at www.wattspremier.com. Step 1 Perform 6 month system mainenance.
To send a water sample, include ½ cup of tap water and ½ cup of the system’s reverse osmosis water in clean containers. Clearly mark each container. Watts Premier will test the water and call or mail you the results.
Membrane Maintenance (Continued) Tip of Membrane Edge of Housing To be properly seated the tip of the Membrane must be below the Note: housing edge. After replacing membrane housing into clips, attach the green tube to Step 8 the elbow on cap using 5/8" wrench. Step 9 The flow restrictor must be changed each time you change the Membrane.
Parts List for 5 Stage Reverse Osmosis System BLUE BLUE GREEN GREEN BLACK BLACK BLUE 17 18 19 BLUE Serial # NSF Premier ..GREEN Rev 1/31/02 * The reverse osmosis system contains a replaceable treatment component, critical for the effective reduction of total dissolved solids and that the product water shall be tested periodically to verify that the system is performing properly Item # Part # Description...
Page 20
8.35% Note: Depending on water chemistry, water temperature, and water pressure Watts Premier’s R.O. Systems production and performance will vary. Efficiency rating means the percentage of the total water required to operate the system that is treated and available to the user.
Other Products from Watts Premier Watts Premier has other fine water filtration products and accessories to enhance your water and to compliment your existing RO System. Listed on the next several pages are only a few of the items we offer.
Page 22
Part No. 116006 White on chrome $25.95 Watts Premier Ice Maker Kit - High efficiency replaceable filter that can last up to 3 years or 10,000 gallons. Prefect for residential and commercial ice makers as well as refrigerators, drinking fountains, coffee & tea brewers, motor homes and camp- ers.
Page 23
FILTERED SHOWERS...”YOU CAN FEEL THE DIFFERENCE” Chlorine in Your Shower…. It kills germs, bacteria and other microorganisms. It also readily passes through cell walls, and attaches to fatty acids in the cell, disrupting life-sustaining functions. The human body is composed of billions of similar cells, which also absorb chlorine.
Watts Premeir collects personal information when you register with Watts Premier. This information is stored in our data base and we do not rent, sell, or share personal information with other people or nonaffiliated companies.
Page 26
Date of Install: _______________________ Installed By: SELF Plumbing Professional Where Purchased: ____________ Model Number: _______________________ Serial Number: ____ - __________ XXXXXX Insert into envalope and return to Watts Premier Watts Premier 1725 W. Williams Dr. C-20 Phoenix, AZ 85027 Page 26...
What your Warranty Covers: If any part of your WATTS PREMIER Reverse Osmosis System is defective in workmanship (excluding replaceable filters and membranes), return unit after obtaining a return authorization (see below), less tank, within 3 year of original retail purchase, WATTS PREMIER will repair or, at WATTS PREMIER’S option, replace the system at no charge.