Seat; Front Body - Club Car 1998 DS Maintenance Service Manual

4
BODY AND TRIM
Front and Rear Body Repair, Continued:
Club Car Touch-Up Paint Part Numbers
Beige
White
Gray
Red
Dark Blue
Dark Green
Black
Classic Blue
Burgundy
GOUGES, PUNCTURES, TEARS, LARGE SCRATCHES, AND ABRASIONS
Touch up is not recommended. Replace the entire body part or have it repaired by a professional paint and
body repair shop with experience repairing TPO bodies.

SEAT

Proper cleaning of the seat will make it last longer. Use the following guidelines:
Light Soiling: A solution of 10% liquid dish soap and warm water applied with a soft, damp cloth is
recommended. For imbedded dirt, a soft bristle brush may be used. Wipe away residue with a water
dampened cloth.
Heavy Soiling: Dampen a soft, white cloth with lighter fluid (naptha) and rub gently. Then rinse with a
water dampened cloth. See following DANGER .
DANGER
• FLAMMABLE! EXPLOSIVE! DO NOT SMOKE. KEEP SPARKS AND FLAMES AWAY FROM SEAT
AREA WHILE CLEANING. USE IN A WELL-VENTILATED AREA.
For Difficult Stains:
- Dampen a soft, white cloth with a solution of 10% household bleach (sodium hypochlorite) and 90% water.
Rub gently to remove stain, then rinse with a water dampened cloth to remove bleach concentration.
- For still more difficult stains, perform previous procedure using full-strength bleach; or allow bleach to
puddle on affected area for approximately 30 minutes. Rinse with a water dampened cloth to remove
any remaining bleach concentration.
NOTE
• REMOVE SEAT FIRST TO PREVENT BLEACH FROM STREAKING THE BODY FINISH.

FRONT BODY

See WARNING and CAUTION on pages 4-1 and 4-2.
FRONT BODY REMOVAL
1. Remove screws (3) and nylon locknuts (4) to remove front bumper (2) from vehicle frame. Remove
blind rivets (5) (Figure 4-1, Page 4-5) .
Page 4-4 1998/1999 DS Golf Car Maintenance and Service Manual
1019972-01
1019972-02
1019972-04
1019972-06
1019972-08
1019972-09
1019972-10
1019972-11
1019972-12
Seat