Engine Oil Level Inspection; Transmission Oil Replacement - Yamaha CW50L Service Manual

I I'"sP I
ENGINE OIL LEVEL INSPECTION B - 11 TRANSMISSION OIL REPLACEMENT _ _
ENGINE OIL LEVEL INSPECTION _ _ " ' __ TRANSMISSION OIL REPLACEMENT
_ • Oil level _ -_) • Drain plug @
_e_ _'_'_h,40 50 60 70
_-- _ .(_ ,, __!_//: / "Oil filler plug_
Oillevel low --Add oil toproperlevel as 'i
II
30
II
20_'?_-
_
8o
,= ,_-_l follows. ' Drain the transmission oil.
t __"_" _'_'°°El_-_ II O "OIL" indicator light 2. Check:
• Gasket (drain plug)
_J"" • O-ring (oil filler plug)
Damaged _ Replace.
OIL LEVEL AND GAUGE CHECK "_-,,"_ _ 3. Install:
_, ,_,_ -Gas ket(_
Turn main switch _ •Drain plug (_)
to. I
T
Drain plug:
_ 17.5 Nm (1.75 m.kg, 12.6 ft.lb)
I "OIL" indicator I "OIL"indicator
doesn't light, light. 4. Fill:
° Transmission case
IT°rn a'n switch ,r--m,.,on o.
to "ON". SAE 10W30 type SE motor oil
i Capacity:
I Periodic replacement
_ 0.11 L (0.10 Imp qt, 0.12 US qt)
I"OIL" indicatorgoes_ _ "OIL" indicator Total amount
stays on. I 0.13 L (0.11 Imp qt. 0.13 US qt)
_ ' NOTE:
I Inspect FaulW Engine oil level Add oil. J
electrical circuit, and electric circuit Wipe off any oil spilt on the crankcase, tire or
I
Light bulb etc. are OK. _ wheel.
t I "OlL'indicstor J 5 Install:
stays on. • Oil filler plug
.°..n,..,co.,n.ccor°--
to theAPITCTSC3standard.
Capacity :
Total:
t.3 L (1.14 Imp qt, 1.37 US qt)
NOTE:
Install the oil tank filler cap (_ and push it fully
into the filler.
Always use the same type of engine oil;
mixing oils may result in a harmful chemical
reaction and lead to poor performance.
3-9 3-10