Fueling Instructions - Gasoline Vehicles - Club Car DS Golf Car Owner's Manual

Fueling Instructions – Gasoline Vehicles
14. Connect battery and spark plug wire(s). See Connecting the Battery – Gasoline Vehicles on page 11.
15. With the Forward/Reverse handle in the NEUTRAL position, run engine for 3 minutes and check for leaks.
Observe both the drain plug and the oil filter from under the vehicle and watch for oil leaks. If filter leaks, tighten
additional 1/4 turn and retest, if oil drain plug leaks, re-torque and retest.
16. Remove the dipstick and check the engine oil as a final step. Replace the dipstick.
FUELING INSTRUCTIONS – GASOLINE VEHICLES
See General Warnings on page 9.
DANGER
• Turn the key switch to the OFF position before fueling.
• Do not pour fuel into the fuel tank when the engine is hot or while it is running.
• Be sure the fuel tank ground wire, located next to the fuel shut-off valve, is properly connected before
fueling the vehicle.
• To avoid electric arc caused by static electricity, the fuel storage/pumping device must be grounded. If
the pump is not grounded, the vehicle must be grounded to the pump before and during the fueling
operation.
• If the vehicle has an all-weather enclosure installed, be sure the fuel tank is properly vented as shown
(Figure 37).
• To avoid the possibility of fire, clean up any spilled fuel before operating the vehicle.
CAUTION
• Use unleaded gasoline only.
• Whenever possible, avoid using oxygenated and blended fuels.
• Do not use any fuel with an alcohol content that exceeds 10% by volume (such as E15 and E85).
Ethanol is an alcohol that readily absorbs moisture, causing corrosion of fuel system components. It
also damages neoprene and other plastic and rubber components. Use of these fuels in this vehicle
will void the warranty.
• To allow for expansion, do not fill higher than 2.54 cm (one inch) from the top of the fuel tank. Avoid
spilling fuel.
1. Turn the key switch to the OFF position.
2. Lift and remove seat bottom.
3. The fuel tank is located on passenger side of vehicle. Remove fuel cap and fill the fuel tank with fresh unleaded
gasoline only. See preceding DANGER and CAUTION.
4. Replace fuel cap on tank. Ensure cap is tightened securely.
5. Replace seat bottom.
Page 52 DS Golf Car Owner's Manual