Trouble Shooting Guide - BOMBARDIER EVEREST Operator's Manual

TROUBLE SHOOTING
O
NOTE: The possible causes have been listed in an order of frequency.
Therefore, items should be checked out
in
the same order as mentioned
in the trouble shooting guide.
SYMPTOMS POSSIBLE CAUSES WHAT TO DO
Engine turns over but 1.
No fuel to the engine Check the tank level and fill it up. Check for
fails to start or starts
possible clogging of fuel line, item 4.
with difficulty
2.
Flooded engine Remove wet spark plugs, turn ignition to OFF
and crank engine several times. Install clean
dry spark plugs: Start engine following usual
starting procedure. If engine continues to
flood, see your dealer.
3.
Spark plug/ignition Check for fouled or defective spark plug. Dis-
connect spark plug wire, unscrew plug and re-
move from cylinder head. Reconnect wire and
ground exposed plug on engine cowl, beiIg
cnfuI
to .....
IW8Y
from .... plug hole.
Follow engine starting procedure and check
for spark. If no sparks appear, replace spark
plug. If trouble persists, contact your dealer.
4. Clogged fuel line (water or Remove and clean the fuel filter. Change filter
dirt) cartridge if necessary. Check condition and
connections offuel lines. Check the cleanliness
of fuel tank.
5. Incorrect carburetor Contact your dealer.
adjustment
6.
Incorrect injection See your dealer.
pump adjustment
7. Engine timing Engine timing may be defective or out of ad·
justment. Contact your dealer.
8.
Poor engine compression Running with a lean fuel mixture may produce
excessive engine wear resulting inpoor engine
compression. If this occurs, contact your
dealer at once.
Engine
will
not turn
1.
Seized engine In the case of a seized engine contact your
manually dealer.
35