Starting Your Portable Spa - Cal Spas Pneumatic Series Owner's Manual

Owner's Manual

STARTING YOUR PORTABLE SPA

Be careful not to over-tighten the plumbing fittings.
NOTE:
NOTE: Never run the spa with the gate valves closed or without water circulating longer than 1 minute.
Operating the spa in this manner may damage your ppump or cause a dry fire condition.
NOTE: Never fill your spa with soft water. Soft water makes it impossible to maintain the proper water
chemistry and may cause the water to foam, which will ultimately harm the finish of the spa and void
your warranty.
Filling and Powering-Up
1. Once the spa has been placed on an approved surface and has been correctly wired by a licensed electrician,
inspect all plumbing connections in the equipment area of your spa. Ensure that these connections are secure
and that they didn't loosen during shipment.
2. If equipped, open all gate valves, or slice valves, in the equipment area.
NOTE: Before operating the spa, these valves must be in the up, or 'open', position.
3. Remove the filter basket and cartridge from skimmer/ filter canister.
4. Place a garden hose in the skimmer/ filter canister and continue filling your spa with regular tap water
up to the water level (halfway up the skimmer area).
5. Open the air relief valve located on the front of the pump housing.
6. After the air bubbles stop coming out of the air relief valve, hand-tighten the valve until it is closed (do not
over-tighten).
7. Once the water is at the correct level, turn on the power at the GFCI breaker.
Ensure that the 110V spas are connected to the proper electrical outlet.
NOTE:
8. The spa will perform a diagnostic check for 30 seconds. Once complete, the spa will automatically operate
at filter speed and continue heating until the spa water temperature reaches 100˚F. (This is every
electronically controlled default temperature.)
9. Re-install filter and filter basket into skimmer/filter canister.
10. The spa is now ready for use. For operation instructions, see the "1500 and 9000 Electronic
Operation" section of this manual.
Page 12
Your Cal Spa
Starting Your Portable Spa
Owner's Manual