Operation - Cornelius DPP 230 Installation & Service Manual

Ice Portion Size Adjustment.
Located in the rear of the electrical box assembly, you will find the ICE PORTION SIZE ADJUSTMENT
KNOB. Turn the ICE PORTION SIZE ADJUSTMENT KNOB to the left (counterclockwise) for less ice
dispensed or turn the knob to the right (clockwise) for more ice dispensed.
Adjust the ice portion size as instructed in this paragraph.
Time Delay Between Dispensed Ice Portions Adjustment.
Inside the electrical control box assembly, you will find a time delay between dispensed ice portions TIME
DELAY ADJUSTMENT SCREW (blue plastic square box with screw driver slot in center) on the portion control
board. The time delay between dispensed ice portions may be adjusted from between 0 and 60-seconds. Turn
the TIME DELAY ADJUSTMENT SCREW for more or less time between dispensed ice portions as indicated by
adjustment marks on the control board next to the blue plastic square box. This makes it inconvenient to fill the
ice chest from the dispenser.
Adjust the time delay between ice portions as instructed in this paragraph.

OPERATION

NOTE: If the dispenser has not vended ice for two hours, an automatic agitation cycle will be initiated
by the solid-state portion control and will last approximately two seconds to stir up the ice in the ice
bin hopper.
1. Referring to ELECTRICAL REQUIREMENTS, connect electrical power to the dispenser.
Manual Dispense Dispenser.
With the MANUAL/PORTION CONTROL SWITCH placed in the "MANUAL" position, pressing the Ice Dis-
pense Switch on the electrical box assembly front panel will activate the dispenser and ice will be dispensed
continuously until the switch is released. If the MANUAL/PORTION CONTROL SWITCH is placed in the "POR-
TION" position, a set time of approximately 1/2 to 20-seconds (adjustable) will be established and pressing the
Ice Dispense Switch will dispense that pre-set portion of ice.
Key Operated Dispensers.
A special key must be used to activate the dispenser to dispense ice. With the MANUAL/PORTION CONTROL
SWITCH placed in the "MANUAL" position, activating the dispenser key switch on the electrical control box front
panel will dispense ice continuously until the key switch is released. If the MANUAL/PORTION CONTROL
SWITCH is placed in the "PORTION" position, a set time of approximately 1/2 to 20-seconds (adjustable) will
be established and activating the dispenser key switch will dispense that pre-set portion of ice.
Card Operated Dispenser.
A special plastic card must be used to activate the dispenser to dispense ice. With the MANUAL/PORTION
CONTROL SWITCH placed in the "MANUAL" position, activating the dispenser with the special plastic card will
dispense ice continuously until the card is removed. If the MANUAL/PORTION CONTROL SWITCH is placed
in the "PORTION" position, a set time of approximately 1/2 to 20-seconds (adjustable) will be established and
activating the dispenser with the special plastic card will dispense that pre-set portion of ice.
10
161952801