Wheels And Tires; Fig. 8 Lifting The Vehicle - Cushman Titan 36V Owner's Manual And Service Manual

Read all of Manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notes, Cautions and Warnings
.
When lifting vehicle, position jacks and jack stands at the
areas indicated only
To raise the entire vehicle, install chocks in front and
behind each front wheel (Ref Fig. 8 on page 9). Center
the jack under the rear frame crossmember. Raise the
vehicle enough to place a jack stand under the outer
ends of the rear frame crossmember.
Lower the jack and test the stability of the vehicle on the
two jack stands.
Place the jack at the flat section of steering box skid
plate. Raise the vehicle enough to place jack stands
under the frame members as indicated.
Lower the jack and test the stability of the vehicle on all
four jack stands.
If only the front or rear of the vehicle is to be raised, place
the chocks in front and behind each wheel not being
raised to stabilize the vehicle.
Lower the vehicle by reversing the lifting sequence.

WHEELS AND TIRES

Tire Repair
Tool List
Lug wrench, 3/4" ......................................................... 1
Impact socket, 3/4", 1/2" drive..................................... 1
Impact wrench, 1/2" drive............................................ 1
Torque wrench, 1/2" drive ........................................... 1
A tire explosion can cause severe injury or
death. Never exceed inflation pressure rating
on tire sidewall.
To reduce the possibility of tire explosion,
pressurize tire with small amount of air
applied intermittently to seat beads. Due to
the low volume of the small tires, overinfla-
tion can occur in seconds. Never exceed
the tire manufacturer's recommendation
when seating a bead. Protect face and eyes
from escaping air when removing valve
core.
To reduce the possibility of severe injury
caused by a broken socket when removing
wheels, use only sockets designed for
impact wrench use.
OPERATION AND SERVICE INFORMATION
Qty. Required
Use caution when inflating tires. Due to the low volume of
the small tires, overinflation can occur in seconds. Over-
Owner's Manual and Service Guide
View from Underside of Vehicle
Steering Box
Skid Plate

Fig. 8 Lifting the Vehicle

Use caution when inflating tires. Overinfla-
tion could cause the tire to separate from
the wheel or cause the tire to explode,
either of which could cause severe injury.
Page 9