Razor Pocket Mod Troubleshooting Manual

Issue
Product Does Not Run
*
Always check to make sure charger is
plugged into charger port correctly & lights
on charger are working properly
*
Unit should be charged 12 hours before
first initial use and up to 8 hours after each
subsequent use
Product Stops Without
Applying Brakes
12/21/2006
POCKET MOD Electric Scooter Troubleshooting Guide
Symptom(s)
Unit shut off while in use Remove battery/motor cover & check fuse
Lights on throttle do light up
NOT
Lights on throttle do NOT light up Remove battery/motor cover to
Motor will not engage check for loose connection(s)
Motor engages, but unit
Check chain & rear wheel
will not move
Secure unit; turn power on & with
weight on the unit, lift back end up
Lights on throttle light up
Unit worked, but
Remove battery/motor cover & unplug
will not go after charging
brake connector from control module
Secure unit; turn power on
Remove battery/motor cover & check fuse
Unit shut off while in use
Lights on throttle do light up Remove battery/motor cover to
NOT
Motor will not engage check for loose connection(s)
Check tension; position & the
Lights on throttle light up
Turn power off & manually turn gear on
motor shaft with your fingers
Troubleshoot
located next to battery
Loose connection(s)
Chain is rotating, but rear wheel does not
NO
Rear Wheel Spins Freely
& apply the throttle
& apply throttle
Motor does
located next to battery
Loose connection(s)
Chain too loose
Chain slipped off rear sprocket
condition of chain
Chain is jammed in
Gear does
Result(s) Possible Solution(s)
Replace fuse and correct riding
Fuse burnt out conditions. (Refer to Pg 6 in Owners
Manual)
Reconnect Loose Connection(s)
Replace Rear Wheel
move
Replace Battery or Charger
Motor engages Replace Brake Lever
engage Replace Control Module & Throttle
NOT
Replace fuse and correct riding
Fuse burnt out conditions. (Refer to Pg 6 in Owners
Manual)
Reconnect Loose Connection(s)
Adjust chain
Check chain for possible damage
[Replace chain if necessary]
(Refer to Pg 5 in Owner's Manual)
Remove chain from chain tensioner;
check chain & chain tensioner for
chain possible damage
tensioner [Replace part(s) if necessary];
place chain back on rear sprocket
(Refer to Pg 5 in Owners manual)
turn freely Replace Motor
NOT
1