Fuse Keeps Burning Out; Has Short Ride Time/Runs Slow; Does Not Hold Charge/Runs Intermittently - Razor Pocket Mod Troubleshooting Manual

Issue

Fuse Keeps Burning Out

Product Has Short Ride Time
or
Product Runs Slow
or
Product Does Not Hold A Charge
Note: Product ride time can be reduced
any where from 10-20 minutes, on a fully
charged battery, depending on riders
weight; various riding conditions and/or
if product has been properly maintained
Product Runs Intermittently
12/21/2006
POCKET MOD Electric Scooter Troubleshooting Guide
Symptom(s)
Check riders weight & riding conditions
Remove battery/motor cover & check for
loose connection(s) and/or wire(s)
Check riders weight & riding conditions
Battery shows fully charged, but goes
low after only 10-15
minutes of use
Air pressure in front & rear tires
and/or
Make sure charger is plugged into charger
Unit runs (very) slow port correctly & indicator lights are
Secure unit; turn power on & with
weight on the unit, lift back end up & apply
Rear wheel barely moves
Should spin 3-4 times w/no resistance
Gently wiggle the wires around the throttle
Unit cuts in & out while in use
Remove battery/motor cover to
check for loose connection(s)
Remove battery/motor cover & unplug
Power skipped several times while in brake connector from Control Module.
use, now will not start
Troubleshoot
Loose connection(s)
No loose connection(s)
Check chain tension
Brake lever feels stiff when
Check brake cable
squeezed/cable too tight
Charger not plugged into
charger port correctly
working properly
NO
Rear Wheel Spins Freely
the throttle
Lift rear end up & manually
spin rear wheel forward Wheel does not spin freely
Unit will go when wire(s) are
for loose wires(s) wiggled/Wire(s) loose
Loose connection(s)
Motor engages/Unit runs again
Secure unit; turn power on
Motor does
& apply throttle
Result(s) Possible Solution(s)
Replace fuse and correct riding
conditions. (Refer to Pg 6 in Owners
Manual)
Reconnect Loose Connection(s)
or
Replace Control Module
wire(s) touching
Replace fuse and correct riding
conditions. (Refer to Pg 6 in Owners
Manual)
Inflate tire(s) to recommended PSI
Tire pressure low
(Located on tire sidewall)
Chain too tight Adjust chain
Squeeze brake lever firmly several
times to loosen up the brake cable
Correctly plug charger into charger
port & charge unit for 8 hrs. Refer to Pg
3 in Owner's Manual
Replace Battery
Replace Rear Wheel
Replace Throttle
Reconnect Loose Connection(s)
Replace Brake Lever
engage Replace Throttle & Control Module
NOT
2