STEELE PRODUCTS SP-GG200TDCM Owner's Manual
  1. Manuals
  2. Brands
  3. STEELE PRODUCTS Manuals
  4. Portable Generator
  5. SP-GG200TDCM
  6. Owner's manual

STEELE PRODUCTS SP-GG200TDCM Owner's Manual

2000w digital generator
Hide thumbs
Table of Contents

Advertisement

Quick Links

Owner's Manual
2000W
Digital Generator
SPoGG2OOTDCM
[_
ARNING!ToReduceThe RiskOf Injury,User ]
Must Read And Understand Instruction Manual.
FOR
SERVICE
CALL:o00
OOm
EO0t
PARA SERVICID
LLAME:
u u
_-_
u
_-_u
_
A

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the SP-GG200TDCM and is the answer not in the manual?

Questions and answers

Related Manuals for STEELE PRODUCTS SP-GG200TDCM

Summary of Contents for STEELE PRODUCTS SP-GG200TDCM

  • Page 1 Owner's Manual 2000W Digital Generator Must Read And Understand Instruction Manual. ARNING!ToReduceThe RiskOf Injury,User ] SPoGG2OOTDCM SERVICE CALL:o00 EO0t PARA SERVICID LLAME: _-_u...

  • Page 2: Troubleshooting

    •Thank you for purchasing a generator. •This manual covers operation and maintenance of the generator. • Reserves the right to make changes at anytime without notice and without taking any obligation. This publication can't be reproduced without written permission. • Pay special attention to the following words: •...
  • Page 3 • Always make a pre-operation inspection (page 8) before you start the engine. • Place the generator at least 1 m (3 ft) away from buildings or other equipment during operation. • Operate the genernator on a level surfuce. If the generator is tilted, fuel spillage may result. •...
  • Page 4 CONTROL PANEL •CHOKE LEVER • FUEL CAP LEVER • OILALERT INDICATOR LIGHT • OVERLOAD INDICATOR LIGHT • OUTPUT INDICATOR LIGHT • FUEL CAP • DC RECEPTACLE • DC CIRCULT PROTECTOR CONTROL PANEL • FUEL COCK Auto Throttle Switch •Ground • LEFT SIDE MAINTENANCE •AC Receptacle COVER...
  • Page 5 @ Check the fuel level. Unleaded or Iowleaded is preferred to minimize com-bustion chamber deposits. @ Check oil level. If the fuel level is low, refuel the fuel tank. Loosen the cover screw and remove the left side maintenance cover. Never use an oil/gasoline misture...
  • Page 6 ® Check the air cleaner. Check the air cleaner element to be sure it is clean and in good condition. Before starting the engine, disconnect any load from the receptacle. Loosen the cover screw and remove the left side maintenance cover. (_Turn the fuel cap lever fully clockwise to the ON position.
  • Page 7 ® Pull the starter grip until resistance is felt, then pull the starter grip briskly toward the arrow as shown below. CAUTION: Do not allow the starter grip to snap back• • To prevent electrical shock from faulty appliances, the generator should be grounded.
  • Page 8 NOTE: • An overloaded DC circuit will trip the DC circuit protector (push button comes out). The DC circuit protector will trip when it's overloaded• If this happens, wait a few minutes before pushing in the circuit protector before resuming operation• OIL ALERT INDICATOR LIGHT --"...
  • Page 9 • The battey gives off explosive gases; keep sparks, flames and cigarettes away. Provide adequate ventilation when charging. To stop the engine in an emergency, turn the engine switch to the STOP position. • The battey contains sulfuric acid (electrolyte). If it gets into your skin or eyes it will IN NORMAL CONDITION: cause severe burns.
  • Page 10 ® Turn the fuel cap lever counterclockwise to the "OFF" posiltion. CAUTION: Be sure the fuel cap lever and the engine switch are "OFF" The purpose of maintenance and adjustment schedule is to keep the generator when stopping, transporting and/or storing the generator.

  • Page 11: Engine Oil Capacity

    O CHANGING Drain t heoilwhile theengine i sstillwarm. CAUTION: Make sure to turn the engine switch and the fuel cap lever OFF be- fore draining• • Loosen the cover screw and remove the left side maintenance cover. • Remove the oil filler cap. •...
  • Page 12 ® SPARK PLUG SERVICE RECOMMENDED SPARK PLUG: CR5H88 (NGK) U16FSR - UB (DENSO) To ensure proper engine operation, the spark plug must be properly gapped •AIR FILTER ELEMENT and free of deposits. • Remove the spark plug maintenance cover. FILTER GAP •...
  • Page 13 • Visually inspect the spark plug. Discard it if the insulator is cracked Clean the spark plug with a wire brush if it can be reused. • Measure the plug gap with a feeler gauge. The gap should be 0.6-0.7mm,correct as necessary by carefully bending the side electrode.
  • Page 14 When the engine will not start: To check: 1. Remove the spark plug cap and clean any dirt around the spark plug. 2. Remove the spark plug and install the spark plug in the plug cap. 3. Set the plug side electrode on the cylinder head to ground. Is there fuel in the tank? Is there enough oil in the engine? 4.
  • Page 15 Appliance does not operate: Engine Is the output indicator light ON? Engine typ e 4_str0kel 0vet head Valve, single cylinder Displacement 86cc Is the overload indicator light ON? Bore X stroke ¢ 54X 38rim Compression ratio 10:1 Check the electrical appliance or speed -Engine 4000_5000r.p.m...

  • Page 16: Limited Warranty

    Limited Warranty Limited Warranty ( cont'd) Steele® warrants totheoriginal purchaser whouses theproduct inaconsumer THIS WARRANTY DOES NOT COVER: application (personal, residential orhousehold usage)that allproducts c overed under t his warranty arefree fromdefects i nmaterial andworkmanship forone year f rom thedate of , Merchandise soldasreconditioned, used asrental e quipment, orfloorordisplay m odels.

  • Page 17: Parts Listing

    EngineExplode Parts Listing PartsListing 0 ¸_ -_. APA Part No. Description Part No. APA Part No. Description Part No. 2 9\ APG3102TECM-01 Cylinder Head Comp. ¢58 3040101010110 APG3102TECM-33 Knob Collet 30159005 APG3102TECM-02 0502060121 APG3102TECM-34 3030001180200 Hexagon Flange Bolts M6X12 Magnetic Reed Switch Assembly APG3102TECM-03 Head Cover Comp.
  • Page 18 ProductExplode Parts Listing PartsListing APA Part No. Description Part No. APA Part No. Description Part No. APG3102TECM-01 Engine Assy. 3040100000000 APG3102TECM-32 Hooked Damping Pillar 3040114010000 APG3102TECM-02 APG3102TECM-33 Hook 3040114000100 Tension Increasing Fuel Tank 3030101140000 Cap Subassembly APG3102TECM-34 Sponge 3040110000100 APG3102TECM-03 3040000000600 Fueling Port Rubber Ring APG3102TECM-35...
  • Page 19 Parts Listing Parts Listing APA Part No. Description Part No. APA Part No. Description Part No. APG3102TECM-65 Screw M4X12 060404012 APG3102TECM-96 Washers 3030001112600 APG3102TECM-66 Fuel Switch Turn Knob 3030001150100 APG3102TECM-97 Clip Springs 3030001000900 APG3102TECM-67 Screws M6X14 060404014 APG3102TECM-98 Gaskets 5 030105001 APG3102TECM-68 3040000000100...

  • Page 20: Carbon Monoxide

    DANGER Carbon Monoxide Using a generator indoors WiLL KiLL YOU iN MINUTES. Carbon Monoxide Generator exhaust contains high levels of carbon monoxide (CO), a poisonous gas you cannot see or smell• If you can smell the generator exhaust, you are breathing CO.

Table of Contents