1000 WATT GE ERiATOR Table of Contents Topic Page Table of Contents Safety Information Specifications Components Starting Your Generator Operating Your Generator Stopping Your Generator Maintenance Storage Statement Trouble Shooting Generator Theory Diagram Limited Warranty Parts List...
1000 ERATOR Safety information CAUTION PLEASE READ ANDUNDERSTAND THiSMANUAL COMPLETELY,BEFOREOPERATINGTHIS GENERAZOR_ Never operate the engine in an enclosed area, All gasoline engines produce carbon monoxide gas while running. Breathing exhaust fumes can kiil_ Operate the engine in a welbventilated area, oniy_ Extract i rom CPSCDocument#5008 on CarbonMonoxide The U,S Consumer Product S Commissio_ (CPSC)has issued the following warning regarding...
1000WATTGENERATO Specifications 15 in. 12 in 14in. 44.1 tbs Air cooied 2ostroke Nonleaded gasoline with a minimum of g0% octane Twoostroke lubrication Gasoline and oil mixing ratio 50 ' 1 DiSpIacement 63 cc Starting System Recoil(Bectronic_gaition) Driving System Direct Coupling, Taper Fit Spark Plug Cooling System Forced Air...
1000 WATTGENERATO R STARTINGTHE ENGINE 1_Disconnect all electric appliances from generator before sta_ing. 2_Turn fuel shut_off I_ver to "ON" 3_Move Choke lever all the way to the ieft 4_Turn engine switch to 'sON°' position_ 5. Puil recoil starlet cord slowly until engaged, then pull briskly to sta_. 6_Once engine has sta_ed, move choke iever al! the way' back to the right°...
1000 GE ERATOR Cleanfuel filter every 150 hours of run time. 1. Remove fuel filter from inside fuel tank 2. C/can with solvent. 3. Wipe dry. 4. Inse_ filter back:in fuel tank. ff the generator will not be used for more than one month, follow the following 1.
i000 WATTGE ERATO G ENERATO R THE0 BY D iAGRA M Rotor ====================== " R1 " °°" _1--'_ MCi ,:DO : Over Volt Protective Stator DO Winding Stator Main Winding Spin Rectifier Rotor Pole Winding Single°phase Rectifier Stator Auxiliary Winding...
Limited Warranty STEELE® warrants to the original purchaser who uses the product in a consumer application (personal, residential or household usage) that al! products covered under this Wa_anty are free from defects in material and workmanship one ye_ from the date of purchase. All :products covered by this limited Wa_anty...
Page 11
ited Warranty THIS WARRANTY DOES NOT COVER: . Merchandise sold as reconditioned, used as rental equipment, or floor or display m_els. • Merchandise that has become damaged or inoperative because of ordinary misuse, cold, heat, rain, excessive humidity, freeze damage, use of improper chemicals,...
Page 13
Cylinder head system assy. "_-9 APG Part No. Part. No Description SP-GG100=A-01 GE 1E45F-A-01 FLANGE BOLT(M6 × 12) SP=GG100=A=02 CYLINDER AIR SHROUD GEl E45F-A-02 SP=GG100=A=03 GEl E45F-A-03 NUT(M6x18) SP=GG100=A=04 GEl E45F-A-04 STUD BOLT(M6x113) SP-GGI00-A-05 GEl E45F-A-05 FLANGE BOLT(M6 x 100) SP=GG100=A=06 SPARK PLUG...
Page 15
Piston and crankshaft connecting rod system assy. 5-_... f_"_, APG Part No. Part. No Description SP-GG100-C-01 GEl E45F-C-01 COMPRESSION RING A SP-GG100-C-02 GEl E45F-C-02 COMPRESSION RING B SP-GG100-C-03 GE1E45F-C-03 PISTON SP-GG100-C-04 GEl E45F-C-04 PISTON SP-GG100-C-05 GE 1E45F-C-05 PISTON PIN CLIP(10mm) SP-GGI00-C-06 GE1E45F-C-06 NEEDLE BEARING(_14x_10x13)
Page 16
Recoil starer system assy. APG Part No. Part. No Description SP-GG100-D-01 GEl E45F-D-01 STARTING COVER SP-GG100-D-02 GE1E45F-D-02 STARTER KNOB SP-GG100-D-03 GE1E45F-D-03 RECOIL STARTER ROPE SP-GG100-D-04 GE1E45F-D-04 START RETURN SPRING SP-GG100-D-05 GEl E45F-D-05 RECOIL STARTER REEL SP-GGI00-D-06 GE1E45F-D-06 BEARING PLATE SP-GG100-D-07 GEl E45F-D-07 DRIVE PLATE SP-GG100-D-08...
Page 17
Carburetor system assy. APG Part No. Part. No Description GE1E45F-E-01 AIR INLET VALVE BODY GASKET SP-GG100-E-01 SP-GG100-E-02 GE1E45F-E-02 AIR INLET VALVE BODY SP-GG100-E-03 GE1E45F-E-03 FLANGE BOLT(M6 X 20) SP-GG100-E-04 GEl E45F-E-04 CARBURETOR GASKET (IN) SP-GG100-E-05 GEl E45F-E-05 CARBURETOR ASSY SP-GG100-E-06 GE1E45F-E-06 CARBURETOR GASKET (OUT)
Page 18
Flywheel system assy. Part. No APG Part No. Description SP-GG100-F-01 GE1E45F-F-01 FLANGE NUT(M10 x 1.25) SP-GG100-F-02 FLYWHEEL GE1E45F-F-02...
Page 19
Ignition system assy. Part. No APG Part No. Description SP-GGI00-G-01 GEl E45F-E-03 FLANGE BOLT(M6 x 20) SP-GG100-G-02 MAGNETO GE1E45F-G-01 SP-GG100-G-03 LOCATING SHEET GE1E45F-G-02 SP-GG100-G-04 HIGH VOLTAGE GEl E45F-G-03 SP-GG100-G-05 STOP SWITCH CORD GE 1 E45F-G-04 SP-GG100-G-06 GE1E45F-A-01 FLANGE BOLT(M6 × 12)
Page 20
Control system assy. Part. No APG Part No. Description SP-GG100-H-01 GE1E45F-H-01 FLAT SCREW( M6 x 40) SP=GG100=H-02 CONTROL ADJUSTING SPRING GEl E45F-H-02 SP-GG100-H-03 SPEED GOVERNING GASKET GEl E45F-H-03 SP=GGI00=H-04 SPEED GOVERNING SPRING GE1E45F-H-04 SP-GG100-H-05 GEl E45F-H-05 FLANGE NUT(M6) SP=GGI00=H-06 SHIFTET GEl E45F-H-06 SP=GG100=H-07 GOVERNOR...
Page 21
1000W Muffler system assy. APG Part No. Part. No Description SP-GG100-1-01 GE 1E45F-E-03 FLANGE BOLT(M6 × 20) SP-GG100-1-02 MUFFLER COMP. GE1E45F-I-01 SP-GG100-1-03 MUFFLER GASKET GE1E45F-I-02...
Page 22
1000W Fuel tank system assy. APG Part No. Part. No Description SP-GG100-J-01 GE 1E45F-A-01 FLANGE BOLT(M6X SP=GG100=J-02 CLAMP GE1E45F-J-01 SP-GG100-J-03 FUELTUBE GEl E45F-J-02 SP=GG100=J-04 FUEL CONTROL VALVE GE 1 E45F-J-03 SP-GG100-J-05 FUEL TANK GEl E45F-J-04 SP-GG100-J-06 FUEL FILTER GEl E45F-J-05 SP-GG100-J-07 FUEL CUP GE1E45F-J-06...
Page 23
Control box assy. APG Part No. Part. No Description SP-GG100-K-01 GE1E45F-K-01 FLAT SCREW(M5 × 16) SP-GG100-K-02 AIR FILTER COVER GE1E45F-K-02 SP-GG100-K-03 GE1E45F-K-03 FLANGE BOLT(M6 x 65) SP-GG100-K-04 PLATE PAD GEl E45F-K-04 SP-GG100-K-05 AIR FILTER GE1E45F-K-05 SP-GG100-K-06 E45F-K-06 FLAT SCREW(M6 × 40) GE 1 SP-GG100-K-07 E45F-J-09...
Page 24
Control box assy. Part. No APG Part No. Description SP-GG100-K-18 AC SOCKET GE1E45F-K-17 SP-GG100-K-19 DC SOCKET GEl E45F-K-18 SP-GG100-K-20 PANEL COVER GE1E45F-K-19 SP-GG100-K-21 ENGINE SWITCH GE1E45F-K-20...
Page 25
Generator APG Part No. Part. No Description SP-GG100-L-01 GEl E45F-L-01 STATOR ASSY. SP-GG100-L-02 GEl E45F-L-02 ROTOR COMP. SP-GG100-L-03 GE1E45F-L-03 FLANGE BOLT(M8 × 155) SP-GG100-L-04 GE1E45F-B-04 RUBBER SP-GG100-L-05 GE1E45F-L-04 GENERATOR STAY SP-GG100-L-06 GE1E45F-L-05 FLANGE BOLT(M6 × 80) SP-GG100-L-07 GEl E45F-L-06 FLAT SCREW( M4 ×20) SP-GG100-L-08 GE1E45F-L-07...
Need help?
Do you have a question about the SP-GG100 and is the answer not in the manual?
Questions and answers
Spark plug wire is cut in half need to replace it not sure what wire to het