TABLE OF CONTENTS PREFACE…………………………………………………………….. 3 ASSEMBLY INSTRUCTIONS……………………………………... 4 SAFETY NOTICE…………………………………………………… 3.1 Before Driving 3.2 While Driving EMI …………………………………………………………………… 9 PARTS INTRODUCTION…………………………………………... Parts Description OPERATION………………………………………………………… 6.1 Operation Panel 6.2 How to Operate Your Vehicle 6.3 How to Set to Freewheel Mode CHARGING AND BATTERY………………………………………...
♦ This owner’s manual includes operation instructions for all aspects of the vehicle, including assembly and how to deal with possible accidents. ♦ This owner’s manual is written solely for Bladez B*Mobile, DK S320 - Executive. ♦ The symbols used in this manual are explained below.
A S S E M B LY I N S T RU C T I O N S 1. Once you have removed your scooter from the box it will be folded down with the basket and the seat with it (Fig 1). Remove the seat and basket and set them aside.
Page 5
A S S E M B LY I N S T RU C T I O N S Lastly attach the seat. Line up the pin on the bottom of the seat with the seat post and slide it into place. Lift the lever on the side of the seat to lock the seat into place.
S A F E T Y N OT I C E 3.1 Before Driving The user should become familiar with all functions and features needed to operate this vehicle before driving. Please always keep safety in mind. Initially an assistant should be present while the user becomes familiar with the vehicle.
S A F E T Y N OT I C E ■ The B*Mobile vehicle is limited to one passenger Do not carry passengers on your vehicle. (Including children) ■ Do not use this vehicle to carry or haul goods ♦...
Page 8
S A F E T Y N OT I C E ♦ When coming to an inclined road you should adjust the speed dial to a middle setting and drive slowly. Maintain a safe speed and avoid any sudden starts or stops.
Caution: It is very important that you read this information regarding the possible effects of electromagnetic interference on your electric Bladez B*Mobile vehicle. ■ ELECTROMAGNETIC INTERFERENCE (EMI) FROM RADIO WAVE...
Page 10
E M I 4. Long-range transmitters and transceivers, such as commercial broadcast transmitter (radio and TV broadcast antenna towers) and amateur (HAM) radios. Note: Other types of hand-held devices, such as cordless phones, laptop computers, AM/FM radios, TV sets, CD players, and cassette players, and small appliances, such as electric shavers and hair dryers are not likely to cause EMI problems to your powered vehicle.
PA RT S I N T RO D U C T I O N PARTS DESCRIPTION, DK S320 ■ 1. Speed Dial 2. Rear Mirror 3. Control panel 4. Tiller 5. Basket 6. Head Lamp 7. Signal Lamp 8. Windproof front shroud 9. Head – Rest 10.
O P E R AT I O N 6.1 OPERATION PANEL 1. Speed Dial 2. Horn Button 3. Directional Light Switch 4. Power Key Switch 5. Speed Control Lever 6. Battery Condition Meter 7. Warning light switch 8. High Speed / Low Speed Switch 6.2 HOW TO OPERATE YOUR VEHICLE ■...
Page 13
6 . O P E R AT I O N ■ Signal Lamp Switch ♦ The front and rear lights will flash in the direction of the turn signal indicated by the user. ← left signal lamp (1) → Right signal lamp (2) ♦...
Page 15
When you find the travel distance is about only 50% of a brand new batteries traveling distance, it is time for replacement batteries. Contact your Bladez Health Products Corporation service center for replacement batteries. If you continue to use the old batteries less travel distance will be expected.
6 . O P E R AT I O N 6.3 HOW TO SET TO FREEWHEEL MODE ♦ Drive on mode: Push the lever down completely, the vehicle can now be driven by motor power. ♦ Freewheel Mode: Lift the lever up completely, the vehicle can now be moved manually.
Page 17
6 . O P E R AT I O N ■ Starting and Driving 1. Make sure the seat is properly installed. 2. Make sure the tiller has been properly secured. 3. Make sure the armrest has been returned to the lowest position. 4.
Page 18
6 . O P E R AT I O N ■ Stopping 1. Release the speed control lever completely, and the vehicle will activate the electromagnetic brake and stop. 2. Turn the power switch to “OFF”. Then pull out the key. ATTENTION ♦...
7 . C H A RG I N G A N D BAT T E RY 7.1 CHARGING THE BATTERY Be sure to follow all procedures below. • Turn the power switch to “OFF”. • Open the charging socket cap in the rear lighting package (Fig •...
7 . C H A RG I N G A N D BAT T E RY WARNING 1. Keep away from flammable objects while charging. This may lead to fire or explosion of batteries. 2. As the batteries may produce hydrogen, do not smoke while charging. Always charge your batteries in a well-ventilated space.
Page 21
6. Clean the battery with a clean cloth. If the terminal is covered by white powder, clean it by using warm water. SUGGESTION If necessary, contact your Bladez Health Products Corporation service center for cleansing and replacement of the batteries. SUGGESTION 1.
Check the following items before driving. If you find any thing abnormal, go to your Bladez Health Products Corporation service center for further inspection before using it. Item Inspection Content ♦...
8 . I N S P E C T I O N A N D M A I N T E NA N C E 8.2 REGULAR CHECKING RECORD To make sure your vehicle remains in good condition, go to a Bladez Health Products Corporation service center regularly for maintenance and record it every six months after purchasing.
If the power switch is “ON”, and the battery condition meter is not lit, check the fuse. SUGGESTION Contact your Bladez Health Products Corporation service center for inspecting or replacing the fuse, since the tiller shroud has to be removed first for replacement of fuse.
PC circuit board. Please clean the vehicle by wiping it with either a dry or moist cloth. ♦ Please take the vehicle to authorized Bladez Health Products Corporation service center for repairs and adjustments. Improper adjustments could lead to accidents or vehicle malfunction.
9 . T RO U B L E S H O OT I N G ■ When you have trouble with your vehicle ♦ You can inspect the following before taking your vehicle to the Bladez Health Products Corporation service center.
Page 27
9 . T RO U B L E S H O OT I N G DC Status Fault Impact on Notes Indicator Description Controller Flash Code Battery needs Reduced drive is The battery voltage has dropped recharging available below 23.3 volts in neutral. Recharge batteries.
1 0 . S P E C I F I C AT I O N S DK S320 Model Name B*MOBILE - Executive Packing Size 57.8"×29.5"×27.6" (1470mmx750mmx700mm) Overall Height (without seat) 37” (939.8 mm) Overall Length 47” (1193.8 mm) Overall Width 28”...
11.2.1 Contents and Duration of Warranty ■ Contents of Warranty 1. For one year from the date of purchase, Bladez Health Products Corporation will replace at our option free of charge, any parts or electronic components found to be defective due to workmanship and/or material upon the examination by a certified Bladez Health Products Corporation service center.
Page 30
3. Tampering by changing or adding components to the vehicle that is not approved by Bladez Health Products Corporation. 4. Damage caused by not using Bladez Health Products Corporation genuine parts or any parts not recommended by Bladez Health Products Corporation.
Page 31
1 1 . W A R R A N T Y 11.2.4 Warranty effectiveness The product registration card must be completely filled out and stamped by the Bladez Health Products Corporation Dealer where it was purchased. 11.2.5 Warranty rights are non-transferable Bladez Health Products Corporation.