Fuses; Exchanging The Headlight Lamp; Replacing The Parking Light Bulb - KTM 640 LC4 SUPERMOTO 2003 Owner's Manual

32
1
3
A
2
5
4

Fuses

A
Fuse box is located under the seat.
See "Removing the seat" to remove and mount the seat.
The fuses are numbered on the inside of the fuse box.
The fuses marked "RES" are spare fuses.
1
Main fuse (20 amperes) protects all power consumers against short
circuits.
2
Fuse (10 Ampere) protects the following power-consuming units:
– electronic speedometer
– capacitor
3
Fuse (10 Ampere) protects the following power-consuming units:
– ignition
– starter system
4
Fuse (10 Ampere) protects the following power-consuming units:
– flasher lights
– brake light
– horn
5
Fuse (10 Ampere) protects the following power-consuming units:
– headlight
– parking light
Replace a blown fuse only with an equivalent one. If a new fuse that has
just been set in gets blown again, you are strongly advised to have it
inspected by a KTM dealer.
!
U
NDER NO CIRCUMSTANCES IS A STRONGER FUSE ALLOWED TO BE SET IN OR A FUSE
" ". A
ALLOWED TO BE REPAIRED N INEXPERT TREATMENT COULD DAMAGE THE WHOLE
!
ELECTRICAL INSTALLATION

Exchanging the headlight lamp

Replacing the headlight bulb
Remove the headlight mask:
Remove screw 1 on the left and right.
Tilt the headlight mask to the front and detach from the lower fender.
Exchanging the headlight lamp:
Disconnect plug 2 from the bulb.
Remove the rubber cap 3
Unhook the retaining bracket, then remove the bulb.
When inserting the new bulb make sure that the wider of the 3 tongues
is located in the corresponding groove in the socket.
!
N
EVER TOUCH THE GLASS OF THE BULB WITH YOUR FINGERS
MUST REMAIN ABSOLUTELY FREE FROM GREASE
GREASE TO EVAPORATE AND SETTLE DOWN ON THE REFLECTOR
Hook in the retaining bracket, mount the rubber cap and connect the plug
to the bulb.
Mount the headlight mask:
Position the headlight mask such that the headlight is located under the
cockpit.
Fit the headlight mask into the fender and mount screws
Replacing the parking-light bulb
Disassemble the headlight as described above and simply pull the bulb
5
socket out of the reflector.
CAUTION
CAUTION
. T
HE GLASS OF THE BULB
. H
EAT WILL OTHERWISE CAUSE THE
.
1
!
4
!