Advertisement
If thegrill failsto lightproperly:
1.
Turn gas off at source and tum the controlknob to
OFF. Wait at least five minutesfor gas to clear,
then retry.
2. Check gas supply and connections.
3. Repeat lighting procedure. If your grill still fails
to operate properly, turn the gas off at source,
turn the control knobs to OFF, then check the
following:
• Misalignmentof burnertubes over orifices
Correction: Repositionburnertubes over
orifices.
• Obstructionin gas line
Correction: Remove fuel line from grill.Do not
smoke! Open gas supplyfor one secondto
clear any obstructionfrom fuel line, Close off
gas supplyst source and reconnect fuel line to
grill,
• Pluggedorifice
Correction: Remove bumers from grillby pulling
cotter pin (beneathburner) usinga screwdriver
or pliers.Carefully lifteach bumer up and away
from gas valveorifice.Remove the orificefrom
gas valve and gentlyclear any obstructionwith a
fine wire. Then reinstallall orifices, burners,
cotter pins and cooking components.
If an obstructionis suspected in gas valvesor
gas valve bracket,please cell for repair service
at 1-8O0-4-MY-HOME.
Misalignmentof ignitoron burner
• Correction: Check for properpositionofthe
electrode tip. The tip of the electrode shouldbe
pointingtoward the bottomof the collectorbox,
as shownin Figure 11. The gap between the
spark electrode and the bottom of the gas
collector box shouldbe 3/16". Adjust if
necessary. With the gas supply closed and all
control knobs set to OFF press the electric
ignitorcap and check for the presence of a
spark at the electrode.
Disconnected IgnitionWires
• Correction: Inspectthelgnitorjunction box
found beneath the Control Panel. Connect loose
Ignitorwires to the junction box and tryto light
the grill.
Weak AA battery
• Correction: Unscrewthe IgnitorCap and
replace the battery.
WARNING
Should a "FLASH-BACK"
fire occur inlor
around the burner tubes, follow the
instructions below. Failure to comply
with these instructions
could result in a
fire or explosion which could cause
serious bodily injury, death, or property
damage.
•
Immediately turn the gas OFF at its
source.
•
Turn the control knobs to OFF position.
•
Once the grill has cooled down, clean
the burner tubes and burners according
to the cleaning instructionsfound on
page 17 in this manual.
4. If all checksor corrections have been made and
your grillstillfails to operate properly, cell 1-800-4-
MY-HOME for repair service.
15
Advertisement
