Table of Contents
Advertisement
Quick Links
U32 Gas Insert
WARNING:
Improper installation, adjustment, alteration, service or main-
tenance can cause injury or property damage. Refer to this
manual. For assistance or additional information consult an
authorized installer, service agency or the gas supplier.
FOR YOUR SAFETY
Do not store or use gasoline or other flammable vapours and
liquids in the vicinity of this or any other appliance.
Installation and service must be performed by an authorized
installer, service agency or the gas supplier.
Tested by:
918-351a
FPI FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H4
www.regency-fire.com
MODELS: U32-NG3 Natural Gas U32-LP3 Propane
Installer: Please complete the details on the back cover
and leave this manual with the homeowner.
Homeowner: Please keep these instructions for future reference.
www.hampton-fire.com
FOR YOUR SAFETY
What to do if you smell gas:
Do not try to light any appliance
Do not touch any electrical switch:
do not use any phone in your
building.
Immediately call your gas supplier
from a neighbour's phone. Follow
the gas supplier's instructions.
If you cannot reach your gas
supplier, call the fire department.
www.palace-fire.com
Owners &
Installation Manual
TM
05/04/05
Advertisement
Table of Contents
Related Manuals for FPI U32-NG3
Summary of Contents for FPI U32-NG3
- Page 1 Tested by: Installer: Please complete the details on the back cover and leave this manual with the homeowner. Homeowner: Please keep these instructions for future reference. 918-351a FPI FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H4 05/04/05...
-
Page 2: Unit Dimensions
Note: Oversize faceplate is 44" x 28" INFORMATION FOR MOBILE/MANUFACTURED HOMES AFTER FIRST SALE This FPI product has been tested and listed by Warnock Hersey as a Direct Vent Wall Furnace to the following standards: CAN/ CGA-2.17-M91, and ANSI Z21.88b-2003/CSA 2.33b-2003. -
Page 3: Table Of Contents
Conversion Kit from Natural Gas to Propane ....13 Warranty Full Screen Front ............14 Hampton Cast Faceplate Installation ......16 Warranty ..............35 Hampton Cast Faceplate Grill ........17 Kensington Front ............18 U32-3 FPI Direct Vent Gas Insert... -
Page 4: Safety Label
SAFETY LABEL This is a copy of the labels that accompany NOTE: FPI units are constantly being im- each U32-3 Gas Insert. We have printed a copy proved. Check the label on the unit and if of the contents here for your review. The... -
Page 5: Installation
More frequent cleaning supply piping system by closing its individual may be required due to excessive lint from The FPI Gas Insert must be installed in accord- manual shut off valve during any pressure carpeting, bedding material, animal hair, ance with these instructions. -
Page 6: Manufactured Mobile Home Additional Requirements
11) Install the glass front (flush or bay). See The minimum fireplace clearances & dimen- pages 10 and 11. sions for the FPI gas insert are shown in the following diagrams: 12) Install optional glass trim, or door fire screens. See pages 11 and 12. -
Page 7: Gas Connection
In areas of consistently high winds, we recom- marked with an "I", seal connection with mend using the Simpson Dura-Vent System high temperature silicone. Secure with gear (923GK adapter and 991 high-wind cap). clamp. U32-3 FPI Direct Vent Gas Insert... -
Page 8: Gas Pressure Test
Note: Aeration Adjustment should only pressure ports on the valve. be performed by an authorized FPI Installer at the time of installation 1) Make sure the valve is in the "OFF" position. or service. -
Page 9: Log Installation
Take some of the embers (approx. 1/3 of the bag) and sprinkle over the ver- miculite. F)02-48 Logs A)02-43, C)02-56, and B)02-45 in position B)02-45 Notch Bracket Vermiculite and Vermiculite and Vermiculite and embers. embers. embers. U32-3 FPI Direct Vent Gas Insert... -
Page 10: Faceplate & Trim
10) Attach the faceplate panels to the insert 4) Place the trim on the assembled faceplate body using the 4 remaining black screws. panels, aligning the wire connections from Diagram 5. the switches with the notch on the left side panel. U32-3 FPI Direct Vent Gas Insert... -
Page 11: Standard Flush Door
1) The top louver is held in place by friction fit, piece, then attach trim to the top and bottom of if the louver needs to be adjusted; bend the Flush door. bracket out as shown in the diagram. Diagram 1a Diagram 1b U32-3 FPI Direct Vent Gas Insert... -
Page 12: Optional Bay Door
3) Slide the SIT valve extension knobs onto the valve knobs. Match the correct ext. knob with the valve knob. knobs. Match each extension knob with the corresponding valve knob. Extension knobs are for Bay Front installations only. U32-3 FPI Direct Vent Gas Insert... -
Page 13: Conversion Kit From Natural Gas To Propane
12) Place the red "Converted to Propane" sticker on top of the Natural Gas information on the Serial Number decal. 13) Adjust the burner aeration setting from 3/16" to 1/4" as required for the best flame picture. U32-3 FPI Direct Vent Gas Insert... -
Page 14: Full Screen Front
2) Lift unit up slightly and push down on the corners of the Bottom Trim Bracket and slide under unit. Unit should touch tabs on Bottom Trim Bracket. Inside flange of Side Trim goes over the inner side of the unit flange. Push in Corners Bottom Trim Bracket U32-3 FPI Direct Vent Gas Insert... - Page 15 NOTE: If you find that the doors do not align properly, adjust the hinges on the door(s) by loosening them and adjust accordingly. 6) The Top Frame is held in place by friction fit, if the frame needs to be adjusted; bend the bracket accordingly. Top Frame U32-3 FPI Direct Vent Gas Insert...
-
Page 16: Hampton Cast Faceplate Installation
Attach the clip to the rear of the faceplate to ensure that the wires do not touch the side of the unit. 10) The power cord should be run behind the faceplate panel. 28" U32-3 FPI Direct Vent Gas Insert... -
Page 17: Hampton Cast Faceplate Grill
12) To put on the Hampton logo, peel the sticker from the back of the logo and place it centered on the bottom left hand corner of the faceplate. Left Side Hampton Logo Faceplate U32-3 FPI Direct Vent Gas Insert... -
Page 18: Kensington Front
The power cord should be run behind the faceplate panel. Left Side Shown Screws 3) Slide the Tabs on the Blanking Plate into the slots located on Front and secure using 2 screws. Blanking Plate Tabs Kensington Front Blanking Plate Screw Screw U32-3 FPI Direct Vent Gas Insert... -
Page 19: Kensington Front 2-Panel Door
The spacer is to be placed over the bottom pin before installing the Screen Door. 2) Mount the 2-panel Door Frame to the flange on Sub-Frame, ensuring to line up holes. Secure using the 6 screws provided. Spacer U32-3 FPI Direct Vent Gas Insert... -
Page 20: Kensington Front 3-Panel Door
A wall thermostat may be installed if desired, correctly. This includes: follow the wiring diagram below. FPI offers an 1) Install the Sub-Frame by hooking the top optional programmable thermostat but any 250-... -
Page 21: Wiring Diagram
This appliance is equipped with a three pronged (grounding) plug for your protection against shock hazard and should be plugged directly into a properly grounded three- prong receptacle. Do not cut or remove the grounding prong from this plug. U32-3 FPI Direct Vent Gas Insert... -
Page 22: Operating Instructions
The first fire in your stove is part of the paint FPI gas appliances use high tech blowers to tension springs to the door. The unit must curing process. To ensure that the paint is push heated air farther into the room. -
Page 23: Copy Of Lighting Instruction Plate
5) Keep the area near the appliance clear and paint and should only be refinished with free from combustible materials, gasoline heat resistant paint (not with wall paint). FPI CLOTHING OR OTHER FLAMMABLE and other flammable vapours and liquids. uses StoveBrite Paint - Metallic Black #6309. -
Page 24: General Vent Maintenance
Your FPI insert is supplied with high tempera- 1) Check the Venting System for corrosion in 7) Do not use this appliance if any part has ture, 5 mm Neoceram ceramic glass that will areas that are exposed to the elements. -
Page 25: Fan Maintenance
10) Unplug the wires from the fan motor (from inside the stove). 11) Lift Fan Assembly off of the 2 pins, tip forward and pull through firebox opening. 12) Disconnect green wire from power cord. U32-3 FPI Direct Vent Gas Insert... -
Page 26: Valve Removal & Replacement
15) Close the door and replace the louvers. 13/16" wrench. 4) Reconnect the quick drop out thermocouple 16) Fire up the unit again and check for proper nut with a 9mm wrench. flame appearance and glow on logs. U32-3 FPI Direct Vent Gas Insert... -
Page 27: Parts List
Brick Panel Set - Herringbone Brown 422-904 Brick Panel Set - Herringbone Red 33) * Brick Panel - Right Side 34) * Brick Panel - Left Side 35) * Brick Panel - Back 36) 400-090 Brick Clip U32-3 FPI Direct Vent Gas Insert... - Page 28 Burner Assembly (NG/LP) 73) * Log Tray Mount Bracket 74) * Log Tray Rear 90) 910-421 Pilot ON/OFF 3" (SIT) Extension Knob 91) 910-422 HI/LOW 3" (SIT) Extension Knob *Not available as a replacement part. U32-3 FPI Direct Vent Gas Insert...
- Page 29 135) 940-307/P Flush Glass 137) 904-691 U Clip 139) 936-155 Tadpole Glass Gasket 149) 420-932 Flush Trim Top/Btm (Set) -Gold 422-943 Screen Door (Optional) 171) 512-546 Door Latch Assembly 173) 430-133 Handle 904-712 U-clip for frame U32-3 FPI Direct Vent Gas Insert...
-
Page 30: Faceplate Assembly
Faceplate Top - Molded REAR VIEW 143) * Faceplate Side Left -Molded 144) * Mounting Bracket - Right 145) * Filler Bracket 146) * Mounting Bracket - Left 147) * Screw #8 x 3/4" Pan Head U32-3 FPI Direct Vent Gas Insert... - Page 31 Mounting Flange 195) Hampton Logo Plate 207) 402-981** Cast Grill (Set) - Top & Bottom *Not available as a replacement part. ** Last digit of part number represents colour: 1=Black Metallic, 5=Enamel Brown, 6=Enamel Black U32-3 FPI Direct Vent Gas Insert...
- Page 32 _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ ____________________________________________________________ __________________________________________________________ ____________________________________________________________ _______________________________________________________ _____________________________________________________ __________________________________________________________ _________________________________________________________ _________________________________________________________ ______________________________________________________ ______________________________________________________ _______________________________________________________________ ___________________________________________________________ __________________________________________________________ ____________________________________________________________ ____________________________________________________________ ____________________________________________________________ _____________________________________________________________ __________________________________________________________ __________________________________________________________ _____________________________________________________ ________________________________________________________ _________________________________________________________ _________________________________________________________ U32-3 FPI Direct Vent Gas Insert...
- Page 33 _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ ____________________________________________________________ __________________________________________________________ ____________________________________________________________ _______________________________________________________ _____________________________________________________ __________________________________________________________ _________________________________________________________ _________________________________________________________ ______________________________________________________ ______________________________________________________ _______________________________________________________________ ___________________________________________________________ __________________________________________________________ ____________________________________________________________ ____________________________________________________________ ____________________________________________________________ _____________________________________________________________ __________________________________________________________ __________________________________________________________ _____________________________________________________ ________________________________________________________ _________________________________________________________ _________________________________________________________ U32-3 FPI Direct Vent Gas Insert...
- Page 34 _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ ____________________________________________________________ __________________________________________________________ ____________________________________________________________ _______________________________________________________ _____________________________________________________ __________________________________________________________ _________________________________________________________ _________________________________________________________ ______________________________________________________ ______________________________________________________ _______________________________________________________________ ___________________________________________________________ __________________________________________________________ ____________________________________________________________ ____________________________________________________________ ____________________________________________________________ _____________________________________________________________ __________________________________________________________ __________________________________________________________ _____________________________________________________ ________________________________________________________ _________________________________________________________ _________________________________________________________ U32-3 FPI Direct Vent Gas Insert...
-
Page 35: Warranty
This limited Lifetime Warranty does not extend to or include paint, door or glass gasketing or trim. At no time will FPI be liable for any consequential damages which exceed the purchase price of the unit. FPI has no obligation to enhance or modify any unit once manufactured. - Page 36 Dealer Name & Address: ______________________________________________ __________________________________________________________________ Installer: ___________________________________________________________ Phone #: ___________________________________________________________ Date Installed: ______________________________________________________ Serial No.: _________________________________________________________ FPI, Hampton and energy are trademarks of FPI Fireplace Products International Ltd. Printed in Canada © Copyright 2005, FPI Fireplace Products International Ltd. All rights reserved.