Installing The H42Vo Log Set - Montigo H34VO Installation & Maintenance Manual

Installing the Log set:
The H42VO* is supplied with a seven ceramic fibre log logset. Unpack
the logs and handle them very carefully.
Step 1. Remove the glass door as described in the previous Instructions.
Rear / Bottom Log
Notch in Log
Pilot Assembl y
Fireplace Base
Figure 10a. Placing Bottom Rear Log.
Step 2. Place the bottom Rear log as shown in figure 10a.
Align
Bottom Left Log
Fireplace Base
Figure 10b. Placing Bottom Right / Left Logs.
Step 3. Place the bottom Right and Left logs as shown in figure10b.
Top
Left Log
Align Pins
Top Left
Log
Figure 10c. Top Left / Right Log.
Step 4. Place the Top Right log as shown in figure 10c. using the (4)
four alignment pins protruding from the top of the Right and Left Bottom
Logs, as shown in figure 10c. With these pins align the Top Right and
Left logs using the predetermined alignment holes cast into the underside
of the logs, as shown above, figure 10d.
XG0150 - 081711
Installation
Air Inlets
Bottom Right Log
Right Log
Align Pins
Notch in Log
Top Right
Step 5. Place the Centre Front log , Figure 10d below, as shown using
the notch cast in the Bottom Rear log as shown in figure 10c above.
Figure 10d. Placing Centre Front Log.
Step 7. Place the Right Centre log as shown in figure 10e.
Align
Figure 10e. Placing Right Center Log.
Step 8. Place the Right Center log as shown using the notch in the Top
Right log as a guide, figure 10f.
Top
Figure 10f. Placing Embers.
Step 9. Place the Embers as shown in figure 10f.
Log
Arrange the ember chips on top of the burner tray. Care should be taken
when placing the embers, as blocked burner ports may cause an incorrect
flame pattern, carbon deposits and delayed ignition. Also, the embers
must never be placed in a way that obstructs any of the air inlet ports,
located at the rear of the burner, as shown in figure 10b.
XW2044
H-Series VO Outdoor Gas Fireplace
Center Front Log
Centerline of Fireplace
Right Fr ont
Log
Rest Log
Place Embers in this ar ea
NOTICE
If logs are not placed properly, excessive
sooting will result.
Gr oove
in Log
Page 13