Montigo H34VO Installation & Maintenance Manual
Outdoor residential gas fireplace
Hide thumbs
Also See for H34VO:
- Installation & maintenance manual (26 pages) ,
- Installation & maintenance manual (26 pages)
Table of Contents
Advertisement
Installation & Maintenance Manual
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. If odor continues, keep away from the appliance and
immediately call your gas supplier or fire department.
CAUTION
Glass doors on gas fireplaces are extremely hot while the fireplace is on and
remain hot even after the fireplace has been turned off. Safety screens are
available and can reduce the risks of severe burns. Please keep children away
from the fireplace at all times.
XG0150
WARNING
FOR OUTDOOR USE ONLY.
Canadian Heating Products Inc. Langley, BC V4W 4A1 | Montigo Del Ray Corp. Ferndale, WA 98248
If the information in these instructions is not followed exactly, a fire or explosion may
result causing property damage, personal injury or death.
CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide which has
no odor. Using it in an enclosed space can kill you.
Never use this appliance in an enclosed space such as a
camper, tent, car or home.
®
C
US
H34VO H38VO
HL38VO H42VO
Outdoor
Residential
Gas Fireplace
WARNING
WARNING
060611
Advertisement
Table of Contents
Related Manuals for Montigo H34VO
Summary of Contents for Montigo H34VO
- Page 1 Please keep children away from the fireplace at all times. WARNING FOR OUTDOOR USE ONLY. ® XG0150 060611 Canadian Heating Products Inc. Langley, BC V4W 4A1 | Montigo Del Ray Corp. Ferndale, WA 98248...
-
Page 2: Table Of Contents
Section 6: Section 7: Installing and Removing the Door ........10 Section 8: Installing the Accessories ..........11 - 14 ▪ Installing the H34VO Log Set ............ 11 ▪ Installing the H38VO Log Set ............12 ▪ Installing the H42VO Log Set ............13 ▪... -
Page 3: Introduction
Congratulations on your purchase of a Montigo Fireplace. warranty and Installation Information: (See appendix B) With over 30 years of experience, Montigo is committed to providing you The Montigo warranty will be voided by, and Montigo disclaims any with a gas fireplace that is not only a beautiful addition to your space, but... -
Page 4: Installation
H-Series VO Outdoor Gas Fireplace Installation Installation Checklist IMPORTANT MESSAGE: SAVE THESE INSTRUCTIONS Determine the desired install location of your fireplace. The H-Series VO Ventless fireplace must be installed in accordance „ with these Instructions. Carefully read all the Instructions in this manual See Section 1, Dimensions on Page 5, and refer to the Framing „... -
Page 5: Section 1: Installation Overview And Product Dimensions
** Optiona l Drain Pan: proper clearances to air conditioning ducts, electrical wiring and plumbing. accessible path for Direct Vent installation. available for all models. H34VO Part No. OD34123 N” H38VO Part No. OD38123 H42VO Part No. OD42123 O”... -
Page 6: Section 2: Framing The Fireplace
When raising the hearth, the minimum clearance from the top of the (exterior wall). M” Q” fireplace to a combustible ceiling is 36". ** Optiona l Drain Pan: available for all models. H34VO Part No. OD34123 N” H38VO Part No. OD38123 H42VO Part No. OD42123 O” 9" Clearances... -
Page 7: Finishing Around The Fireplace
Figure 3b. Header 5½" 5½" 5½" Sides 1" 1" 1" * Shaded area must be non-combustible. Either Montigo supplied nailing flange, and Floor 0" 0" 0" cement board or other equivalent Back 1" 1" 1" non-combustible material. -
Page 8: Section 4: Wiring
The H-Series VO's gas valve, located behind the lower trim, may be connected to a wall switch. The valve generates its own power on a Montigo Part No. #HSIT07 must be encased in a water-tight millivolt circuit. Use only low voltage wire, and DO nOT connect electrical box OR ensure the box is installed in a dry location and any external power to it. -
Page 9: Section 5: Installing The Gas Line
When pressure testing the fireplace, Gas line, and input system follow the appropriate local codes or your area. DO NOT connect Montigo requires a service shut off valve be located in an „ the fireplace to pressures in excess of 1/2lb. This will damage the accessible location to isolate the gas supply. -
Page 10: Section 7: Installing And Removing The Door
H-Series VO Outdoor Gas Fireplace Installation Section 7: Installing & Removing the Door Removing the door: The H-Series VO doors are removed in a few simple steps. Follow these Step 5: below to remove the Horizontal access panel, unlatch the door buckles Ensure the tool is firmly and, remove the door. -
Page 11: Section 8: Installing The Accessories
Installing the Logs: shown in figure 27c. Install the glass door. If the flame does not ap- The H34VO fireplace is supplied with five ceramic fibre logs. Unpack pear satisfactory, double-check the air inlet and exhaust outlet pipe to the logs and handle them very carefully. -
Page 12: Installing The H38Vo Log Set
H-Series VO Outdoor Gas Fireplace Installation Installing the Log set: The H38VO are supplied with a six ceramic fibre log logset. Unpack the logs and handle them very carefully. Step 1. Remove the glass door as described in the previous Instructions. Log E Air Inlets Rear / Bottom Log... -
Page 13: Installing The H42Vo Log Set
H-Series VO Outdoor Gas Fireplace Installation Installing the Log set: Step 5. Place the Centre Front log , Figure 10d below, as shown using the notch cast in the Bottom Rear log as shown in figure 10c above. The H42VO* is supplied with a seven ceramic fibre log logset. Unpack the logs and handle them very carefully. -
Page 14: Installing The Hl38Vo Firestones
H-Series VO Outdoor Gas Fireplace Installation Section: Installing the Firestones: N.G. & L.P. Fireplaces Propane HL38VO* Fireplaces, has the option of installing the optional cultured rocks or firestones. As described below, CAUTION, the firestones or cultured rocks cannot cover the burners. Doing so produces an undesirable / uneven flame pattern, and eventual sooting. -
Page 15: Section 9: Operation
H*38DF Gas Fireplace Operation Section 9: Start-up Sequence with Continuous Pilot with American Flame Electronic Ignition For Your Safety - READ BEFORE LIGHTING: WARNING If the information in these instructions is not followed exactly, a fire or explosion may result causing property damage, personal injury or death. a. -
Page 16: Start-Up Sequence With Honeywell Electronic Ignition
H*38DF Gas Fireplace Operation with Honeywell Electronic Ignition with American Flame Electronic Ignition For Your Safety - READ BEFORE LIGHTING: WARNING If the information in these instructions is not followed exactly, a fire or explosion may result causing property damage, personal injury or death. If you cannot reach your gas supplier, call the Fire Department. -
Page 17: Maintenance
H*38DF Gas Fireplace Maintenance Burner Adjustment Lighting Instructions The H-Series VO is equipped with an adjustable burner, allowing you See pages 14 to 16. to raise or lower the flames. To adjust the flames, locate the black knob marked 'Hi-Lo', in the centre of the gas control valve (See Figure 11). General The front burners are not adjustable. -
Page 18: Replacement Parts
H-Series VO Outdoor Gas Fireplace Replacement Parts H34VO H38VO H42VO NG Gas Valve RGC1006 RGC1006 RGC1006 LP Gas Valve RGC1005 RGC1005 RGC1005 NG Pilot RPA020 RPA020 RPA020 LP Pilot RPA021 RPA021 RPA021 Burner NG RBH3401 RBH3801 RBH4201 Burner LPG RBH3402... -
Page 19: Appendix
H-Series VO Outdoor Gas Fireplace Appendix A = clearance to the termination frame above grade, veranda, porch, deck, Q = clearance above a roof [24 inches (61 cm) minimum] or balcony [16 inches (41 cm) minimum] R = clearance to adjacent walls and neighboring buildings[18 inches (46 cm) B = clearance to door, or sides and top of window, that may be opened [16 minimum] inches (41 cm) minimum for appliances ≤100 000 BTU/H (30kW)]... -
Page 20: Warranty
The duration of any implied warranty with respect to this Montigo Gas Appliance is limited to the duration of the foregoing warranty. Some states do not allow limitation on how long an implied warranty lasts, so the above may not apply to you. -
Page 21: State Of Massachusetts
H-Series VO Outdoor Gas Fireplace Appendix appendix C: State of Massachusetts amendment (Gas Fireplace / Equipment sold in the State of Massachusetts) 5.08: Modifications to nFPa-54, Chapter 10 (1) Revise nFPa-54 section 10.5.4.2 by adding a second exception as follows: Existing chimneys shall be permitted to have their use continued when a gas conversion burner is installed, and shall be equipped with a manually reset device that will automatically shut off the gas to the burner in the event of a sustained back-draft (2) Revise 10.8.3 by... - Page 22 H-Series VO Outdoor Gas Fireplace Notes Page 22 XG0150 - 081711...
- Page 23 H-Series VO Outdoor Gas Fireplace Notes Page 23 XG0150 - 081711...
- Page 24 H-Series VO Outdoor Gas Fireplace Ferndale, washington Langley, British Columbia TF: 1.800.789.6236 TF: 1.800.378.3115 FX: 1.866.3000.0927 FX: 1.604.607.6462 XG0150 - 060611...